Ford 6.7L Power Stroke Diesel :: Clicking Sound Coming From Front Passenger Wheel When Turning
What would be causing this clicking sound coming from my front passenger wheel? Wheel bearing? It ONLY clicks when turning left.
[URL] ....
Ford 6.7L Power Stroke Diesel :: Rattle In Left Front Wheel / Little Whine Coming From The Rear
So I went to the car wash this morning and when I pulled into the stall I heard a somewhat loud rattle coming from my front drivers side wheel. It sounded like there were a couple stones in the cap that covers the lug nuts. That wasn't the case. It did it in reverse also. Before I take it to the dealer Monday morning. Its a 2011 F-350 6.7 Lariat 4x4 w. 32,000 miles. I also have have a little whine coming from the rear when I take off from a standstill.
View 4 RepliesFord 6.0L Power Stroke Diesel :: Infrequent Squeaking Coming From Area Of Front Left Wheel?
Started about a month ago with a very infrequent squeaking coming from area of front left wheel. Has started getting more and more frequent to the point of being constant for about 10 minutes today, then just went away for the remaining 15 miles home. Front left hub was definitely warmer than the other one but not too hot to touch or anything. Start of a bearing issue or something to do with the auto locking hubs for the 4wd???
View 14 RepliesFord 6.7L Power Stroke Diesel :: Squeak / Rattle Type Sound Coming From Front Driver Side Wheel
I'm having a squeak/rattle type sound coming from my front drivers side wheel (more rattle). It only happens when I go over a quick bump and happens going straight and while turning. 2012 f250. 87k miles. 4x4. I have a two inch block level (southern truck) up front..
View 14 RepliesFord 6.7L Power Stroke Diesel :: 3 - 4 Lbs Of Boost When Exceed 3K RPM While Braking
While engine braking on long down hill runs I notice about 3-4 lbs of boost when I exceed 3K RPM. Why would I have any boost? Should I be concerned? It's been that way for as long as I can remember.
View 10 RepliesFord 6.0L Power Stroke Diesel :: Truck Pulls Left When Under Braking
So I've been noticing the truck pulls left when under braking. So, I replaced the front calipers. Now, it still pulls left. When I got home I felt the discs on all corners and found three about the same, barely touchable, and the front left a little warmer. So, it seems its braking more, but its brand new. So, what should I do? They are also pulsing a little.
View 14 RepliesFord 6.0L Power Stroke Diesel :: Truck Pulls Left Badly When Braking
Truck pulls to the left while braking, pretty bad. So, pulled the front right wheel off thinking the pins are stuck again as last year. Bottom pin was fine, top pin pretty gummed up but not froze so I cleaned it up good, used thin layer of the good stuff, put back together and test drove........same thing. Pulls left upon braking just as bad as before. Caliper pistons seemed fine, didn't take much to compress them either. Would a right rear cause this?
View 14 RepliesFord 6.7L Power Stroke Diesel :: Automatic Exhaust Braking Working In Tow / Haul Mode
Quick observation: with the exhaust brake switch off, I notice it appears that the exhaust brake is still working automatically when you are in Tow/Haul mode and apply the brakes coming down a hill.
I notice the engine drone and turbo boost gauge rise...although neither the drone nor the boost are as noticeable as when the switch is turned on.
I know the 2011-2014 had "auto exhaust brake only" but it appears some of that functionality is still built in.
Another question: what is the consequence of turning the exhaust brake on and leaving it on for normal driving? Is mpg affected? Engine output? Engine wear?
Ford 6.7L Power Stroke Diesel :: 2015 F250 - Slightly Slows Down When In Tow / Haul Mode While Braking
It's on my 2015 f-250....dont know if this is a new thing ..... I know my 2011 f-350 didn't have it..... Really hardly notice its working ....it slightly slows me down when in tow/haul mode while braking......
View 14 RepliesFord 6.0L Power Stroke Diesel :: Brakes Normal Under Light Braking But Weak During Fast Stop
My truck is a 2004 F350 6.0 as with most of the ford diesels from this era it has hydro boot brakes.
Under normal braking the truck felt fine and the brakes behaved as they always have. However if you where to depress the brakes hard, as if making an emergency stop, the brakes would not lock up in the way they did when I bought the truck two years and 80,000km ago. The problem was slow to appear and at first I blamed it on the larger tiers I was running (stock 2012 F350 wheels and tires (yes the offset is wrong)) but after switching back to my stock wheels for the winter I knew that something was not right. It was something I could live with, it did not make the tuck unsafe it was just that it did not stop as well as I knew it could and this avowed me. I replaced the front and rear calipers and when that had no effect I swapped out the master cylinder this still made little difference.
I drove the company truck all of last month (2008 GMC 2500 Duramax) and when I got back in mine I realised that I had to chase down the problem. I did a lot of reading online and after thoroughly flushing and bleeding my brake system I narrowed my problem down to either the hydro booster or the power steering pump. The plan we came up with for diagnosing was:
1. Thoroughly inspect for PS/Hydro boost and brake fluid leaks following the procedure found here Hydro-Boost Power Assist Systems: Operation Diagnosis and Repair
1a. Consider bleeding the brakes as a bit of trapped air would cause your symptoms.
1.b Consider flushing the PS system. Some suggest this works with tough steering.
2. Have a shop check the PS pressure is within spec. (assuming this is cheaper than buying the tool or just replacing the pump) If it is low, replace the PS pump.
3. If PS pump is fine, or is replaced and the problem is still there, consider replacing the Hydro booster.
It is not super complete but it was a place to start. We checked for leaks and found nothing. The pedal would not sink under braking but would say firm meaning the brake system was free of leaks.
I began a rudimentary test of power steering pump. With the truck in the drive way I could easily turn the steering wheel however, applying the breaks about half way would make turning the wheel imposable. This led me to believe the power steering pump was starting to go. The next step would be to have the pump tested using a power steering pressure gage or take the truck to a shop to have it tested. I found the pressure gage to be more expensive then the new pump so went that way. With 350,000km on the truck I figured it was not a bad thing to do even if it turned out to not be the cause of the problem.
It is a bit tricky to get the power steering pump out but after pulling the radiator line under the truck I could drop the pump out the bottom. The new pump went back in the same way and after a full flush and bleed of the system it was time for a test. What a difference! The truck stops like the day I got it. If your symptoms are like mine I would recommend you check the power steering pump. If it is the problem it is a lot cheaper then replacing a master cylinder or calipers.
Ford 6.0L Power Stroke Diesel :: Steering Wheel Shaking?
Was on the way home today and was taking a long sweeping left-hand curve at 60 and got a horrible shake in the steering wheel. Kinda scared me a bit and let out of the throttle a bit. Didn't happen after and never has before. I'm under the impression it is more shocks maybe then steering, Reason I say that although I don't get a lot of bounce if the road isn't perfectly smooth I can really tell it. What do ya'll think?
View 14 RepliesFord 6.0L Power Stroke Diesel :: CAC / Boost Tube Keeps Coming Off Under Power At Turbo Connection
Having this problem, what to do to correct it? There is no hole in the boot and this just started about a year ago. Does not do it all the time.
View 4 RepliesFord 6.7L Power Stroke Diesel :: Wheel Squeak - Brake Warning
Not persistent, but the squeak I had where peeps thought it was the brake warning is back, but not constant.
Seems to happen above 30, and not sure what the other conditions are (maybe hot brakes). but it sounds like only the front right this time.
I've new Rotors and pads. I am on the road right now, been since the 20th and wont be back till the 2nd or 3rd.
Ford 6.0L Power Stroke Diesel :: Float Feeling In Steering Wheel
I've got a 'new to me' 4" Lift 6.0L PSD Diesel, 2005. At 60 mph, especially 75 mph, there's some 'play' or float feeling in the steering wheel. Is that a normal thing for a 4" lift? and nothing to worry about? (the dealer that sold it said they put new ball joints in it. No cheap shock problem, right?)
View 4 RepliesFord 6.7L Power Stroke Diesel :: Turn On / Off Heated Steering Wheel?
I have a 2015 Platinum Superduty that came with a heated steering wheel but cannot figure how to turn it on and off. I have looked for a dash switch and in the climate portion of the touch screen with no luck. My wife's car has a simple dash mounted switch and also a temp sensor that cuts it on automatically when cold. No such luck with truck.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Wheel Bearing Gone Out - Making Noise?
Wheel bearing go out? My left front just starting making noise and when turned by hand you can hear the bearings are shot. Called around this morning and with my luck its on back order and the entire hub has to be replaced since the bearing is built into the hub.
Anyways, I was wondering replacing this unit themselves and how long it took to complete? I was going to let Ford do the work but I figured I have never done a job like this and wanted to give it a try and looking at some Youtube videos on older vehicles it did not look that difficult.
If I find that its not difficult I will tackle the other side as well since I figure it is probably not long before that side is gone also and I would not want that to fail while I am out towing somewhere.
IS F (2008-2014) :: Heavy Braking Experience Thunk
Under heavy braking, both of my ISF's experience a repeated "thunking." Brakes are fine, rotors aren't warped, and you don't feel anything through the pedal. Rather, it's felt through the floorboard. I bought upgraded LCA bushings, thinking this would solve it, but it persists.
View 8 RepliesSonata NF (2006-10) :: Rear Thunk / Knocking When Braking
Alright so my 06 is at about 102,xxx right now and has given me no major issues (knock on wood) besides this stupid noise that I cant pin point to fix. So far I've narrowed it down to this, sounds like its coming from the right rear and usually only happens when I am slowing down and or braking. Ive also taken note that it only happens when its really hot outside , all signs have been pointing to the rotors and brakes but i need some thoughts/opinions on what else it could be before i shell out almost $200 to get my brakes fixed. Here are some more details about the car
Rear pads replaced sometime last year they still have meat on them but i did not replace rotors nor did i get them turned.
I am sure that the noise is coming from the rear, ive been half way in the trunk while my buddy drove and i hear it coming from right rear.
Shocks have been replaced (noise was occurring before replacing them)
Nothing seems loose everything seems to be tightened down right.
Tires are brand new (noise was there before getting tires and after)
Mufflers are secured normal wiggle mounts look good.
Emergency Shoes have never been replaced but look ok.
Wheel hub looked great when i took it apart (Looks new doubt its that)
It happens when I am braking from 35mph below or sometimes 0 to 35 40mph rolling no braking then it goes away.
Ford 6.0L Power Stroke Diesel :: Low Power Before Boost Kicks In / Idling Rough With Blueish White Smoke Coming Out Of Exhaust
I just looked back and it has been since July 7th that my girl has been sitting in my shop. Well this past weekend I finally got her back together and started. It took a while to build pressure but she finally came to life..
While I am thrilled that she is running again i have low power before the boost kicks in and is idling rough with a blueish- white smoke coming out of the exhaust. Once i kick her a little she will get up and go but I've never had the smoke before.
I'm thinking maybe a bad injector???