Ford 6.0L Power Stroke Diesel :: Died - Low Fuel Pressure - Blew White Smoke - Diesel Smell?

no change, changed stand pipe and dummy plug on driver side, no change and guess what? Now I am stuck on the side of the road waiting to give my last $100 to a tow truck! Engine is hydrolocked, fuel pressure is low, starts off at around 20 and works up to 54 with key on engine off, and that is as much as I know from the side of the road with out my AE. Blew white smoke also. Smelled of unburnt diesel. I think it's linked to my rough running issue. Maybe a bad injector? But every time I did the click test they all passed. Idk, I'm gonna remove the glow plugs and see which hole is loaded and with what. . .

View 14 Replies

Ford 6.0L Power Stroke Diesel :: Turbo Seal Leak / While Smoke And Smell Like Poured Raw Oil On Hot Manifold

I suspect I have a turbo seal leak. My 2004 E350 6.0 smokes like crazy. The smoke is white and smells like you poured raw oil on a hot manifold. Definitely not diesel smoke. How can I tell if it's my turbo without tearing it out?

View 14 Replies

Ford 6.7L Power Stroke Diesel :: 2012 - Exhaust Smell Coming From Truck - White Smoke

Today I drove to dinner in my 2012 6.7 with no problems then on the way home my brother said he noticed my truck was white smoking quite a bit and he said there was a very strong exhaust smell coming from my truck ( he was in his car behind me) I ran a diagnostic test and what came up was code P0401 (I believe that's right). Need to figure out what is going on with my truck before I take it to the mechanics and get charged up. The truck still has DPFs in it just has a DPF back exhaust and has a AFE cold air intake running on a stock tune. However I do have the DPF deletes and EGR delete sitting in my garage just haven't gotten them on the truck yet.

View 2 Replies

Ford 6.0L Power Stroke Diesel :: Low Fuel Light Had Come On / No Power / Lots Of Smoke

So this morning, I stopped for fuel. My low fuel light had come on yesterday, so I planned on filling it up this morning. Swung through the local Safeway (my usual fill-up haunt) and threw 25 gallons of diesel into my Excursion. Truck started up right away, like always, pulled around in the parking lot, pulled into traffic, then got stopped at a red light. I noticed a slight unevenness in the idle for a couple of seconds, then the light turned green. Pulled out, truck accelerated a bit more labored than usual, and in my passenger's mirror, I looked back and saw some light greyish blue smoke.

The smoke progressively got heavier, power diminished, and I was no longer able to maintain speed with traffic. I pulled off onto a side road, shut the truck down, and scanned for pending codes. Nothing. So I hoped that it was just a gremlin, started the truck again, got tons of the same smoke, really rough, super clattery idle, and the engine wouldn't even accelerate in park. No hint of boost, nothing. So I turned the truck off, called a tow truck, and had her flat bed hauled home.

Background on the truck, roughly 150K miles, changed the fuel filters not too long ago (less than 7K on them), recent-ish oil change, but I was planning one for later this month. Truck is all but stock, only an aftermarket cold side intercooler tube. I recently replaced my EGR valve, less than a year ago, because it was stuck partially open, replaced it and the truck ran great after that.

I've been seeing some scary writeups for similar things, stuff involving cracked pistons, bad rings, engine teardowns, new engines required, things like that. For me, it just seems like a ridiculously convenient coincidence that the problem would happen immediately after refueling the truck. At this point, I'm planning on replacing both fuel filters and doing an oil change as preventive maintenance and as the easiest possible fix, but what else should I be looking at? Some posts suggest FICM, some suggest ICP sensor, some are saying my injectors may be shot.

View 14 Replies

Ford 7.3L Power Stroke (1999-2003) :: F250 Started Running Bad Mid Drive / White Smoke With Diesel Smell

Just happened today right after I bought diesel. thought it may be water in fuel but after researching wondering if it is injector, etc. It starts every time knocks real bad sometimes for a minute, but clears up to idle ok. During idle no smoke, slightest acceleration however produces white smoke harder I accelerate more it plumes and it smells like diesel in the air.

Cannot get past 15 or so mph till switching into 2nd gear then 25mph max. Had to drive 4 miles like this I can say it cleared up and drove 1/2 mile until I had to stop at a traffic light then going from idle to acceleration again ran bad rest of way home another 2 miles.

A few years ago I did have a rough idle and accel. similar and it ended up being the broke pick-up/sending unit in tank (but of course that was when you get to around 1/4 tank of fuel and didn't run bad above that much fuel in tank), plus there was almost or more than a gallon of water in tank. I have done the mod for the fuel pickup with hoses, filter canister, etc. but wondered at first today if I had gotten bad gas or water in the tank again. Not sure how that much water got in the tank to begin with but that was bout 5 or 6 years ago.

Truck has over 200k miles and Ive had it for 11 years. In the morning will check the ICP sensor by unplugging look at fuel filter bowl, etc. A question I have is: Is water heavier than diesel, would it run thru my line first? thinking diesel is heavier than gas because of oil content....

View 2 Replies

Ford 6.0L Power Stroke Diesel :: 2004 - Smell Of Fuel When Heater Is Turned On?

I'm hoping it's a small simple fix when I climb under the hood. Has happened before, but was an easy fix. The smell is much stronger this time. Any major problems any of you have had if I can't find the culprit?? Learning as I go...always up for checking on every possibility.

2004 F250 SUPER DUTY 6.0 ......

View 7 Replies

Ford 6.7L Power Stroke Diesel :: Misfire - Smoke - Fuel Injector Supply Line?

Went to go and start my truck this morning and noticed after it was running that it sounded like a misfire, then i seen the smoke... I shut the truck down and lifted the hood and seen that somehow i had a high pressure fuel injector supply line on the Lh side break off. The line that goes from the fuel rail to the injector port on the valve cover (theres 4 of them on a side). There doesn't seem to be an o-ring or anything on them, they are just pressed over and tighten down.

View 6 Replies

Ford 7.3L Power Stroke (1999-2003) :: Fuel Smell On And Off / Strong Odor Of Diesel

I have been smelling fuel on and off for the last few weeks. I thought it was the fuel bowl drain valve so I ordered the kit for the whole fuel bowl from diesel o-rings. I did the rebuild this morning and I don't see any visual leaks. Still smell a strong odor of diesel though. The lower engine cradle is all wet and the valley is still a little wet too. Could I still have a leak and if so where to look? Could it be just wet still from draining the fuel bowl and needs time to go away?

View 14 Replies

Ford 6.0L Power Stroke Diesel :: 2003 - When Engine Get Warm It Starts To Smoke Unburnt Fuel

I have a may 2003 6.0l f350 4x4 ,autoenginuity scanner, recently bought the truck starts fine and idles well then when engine get warm it starts to smoke unburnt fuel (white) volume of fuel desired on scanner goes from about 14 mm~3 to 27mm~3 and starts to run rough if you depress the acellerator the motor smooths out and the fuel desired goes down. No coolant smell. egr cooler removed ,oil cooler replaced, exhaust back pressure sensor and tube cleaned .ebp sensor koeo 14.2, eo 17 but jumped to 54.0 when map was at 17, bp 31.20 .... The AE is new to me Also found a superchip tuner under the back seat ...

View 14 Replies

Ford 7.3L Power Stroke (1999-2003) :: Diesel Smell Coming On And Off - Fuel Bowl Leak?

I've thought I smelt diesel fuel on an off for a while, but never found the source.

Tonight, 17 degrees out I have fuel in the valley and it appears as if the back of the drain valve is wet.

A fuel bowl rebuild is on the short list. Is this typical, the cold weather brings the issue to light?

View 10 Replies

Ford 6.0L Power Stroke Diesel :: Blue Smoke When Warm / Smells Like Oil Not Diesel

Started today. 2004 with 235k miles. Owned for last 10k miles. Engine was recently studded, has egr delete and ccv bypass. Runs and starts fine. New Ford oil cooler too. Checked for codes. None for misfires, perdel are reading 0.

If it sits, on start up clear exhaust, as it warms, more blue smoke. Smells like oil not diesel.

Researched before asking and found leaking turbo seals can cause this. So we pulled the intercooler tube in front of the engine going to the intake expecting to find oil residue. Nice and dry. Was this the correct one to look at?

When we got the truck we had the dealer do a relative compression test and was within limits, it did need 1 injector that we replaced. What would be the next logical place to look?

Couple more points:

- Just changed oil last week, checked today, it was slightly over full.
- Coolant is fresh and has not changed level since we got it.
- Pulled fuel filter to see if any oil, but it was nice and clean.

View 11 Replies

Ford 6.0L Power Stroke Diesel :: 2007 - Chugging White Smoke / Smelled Like Unburnt Diesel

2007 6.0 6 speed, 187,000 miles. The other day started truck, had been running about 20 minutes before. Started fine, go to drive, chugging white smoke, smelled like unburnt diesel, baby truck home, seemed to run ok at low rpm, truck warmed up and ran fine. But I also noticed turbo boost was acting funny. Truck ran fine next few days. Then this morning, started cold fine, started to drive it and same chugging white smoke, it quit by the time j got to the end of my driveway, but drove to work, it quit smoking, ran pretty smooth, but will not build any boost. Truck is bone stock except for exhaust, it's straight piped. Ok. So this eve I borrowed my dads edge cts, here's all the engine codes:

P0069
P0269
P0299
P2262
P2269

The last one is water in fuel, since it started this crap I did notice it was right after it came on in the dash. I'm trying to figure out where to start....

On another note. VGT duty shows 85% at idle ?
Ficm voltage is constant 48 volts
Newer batteries

View 14 Replies

Ford 7.3L Power Stroke (1999-2003) :: 2002 - White Smoke On Start Up / Quick Smell Of Oil?

my 2002 7.3 with 370k just started to puff a small cloud of white smoke on start up. i realize this is normal during cold months but it is currently 102* in Texas. it will do it on the first start up of the day or if i start it immediately after shutting it off at full operating temps and when i do get a smell of the white cloud it has a oil smell but this only lasts while the cloud is dispersing all of that only lasts about 2-3 seconds no loss of power good boost pressure when driving no rough idle at all nothing acting any different other than the cloud and the quick smell of oil...

View 14 Replies

Ford 6.7L Power Stroke Diesel :: Very Strong Diesel Smell?

One of the great things I liked about the new 6.7L engine was the lack of any diesel smell. While the tips of the exhaust pipes remain clean at 64,000+ miles, no soot, my truck now has a strong smell of diesel after each use. The truck is running strong but I can't figure out why this is happening.

View 4 Replies

Ford 6.0L Power Stroke Diesel :: 2006 F350 - White Smoke / Diesel Drip From Muffler / Poor MPG

I would like the hear what others have to say about the problems I'm having with my 2006 F-350 sd xlt 6.0 with 113,000 miles on it. It's being used as a tool truck mostly going from a shop on the property to close by buildings on the same property. In other words very short distances. Used occasionally to take a dump trailer to a close by dumping ground.

1. White smoke from exhaust. I've read this is most likely an ERG cooler that needs replacing. Any other possible causes? If I end up having to replace the cooler is there a stock cooler that is reliable or should I get the one by bullet proof?

2. Diesel is dripping from the muffler weep hole. Last full tank lasted only 60 miles. Could this be the oil cooler? Anything else? If so is the Ford replacement cooler OK or should I go with an upgraded cooler?

View 14 Replies

Ford 6.7L Power Stroke Diesel :: Whining Sound / Low Fuel Pressure And Reduced Power Warning - Fuel Pump Just Died

So, I just had the fuel pump replaced on my '15 6.7 a month ago and it just died again. (next day edit: it didn't actually die, it showed all the same symptoms)

Same symptoms: whining sound, low fuel pressure warning, reduced power warning.

This time I'm 50 miles from home so I pulled off the road before it shut off. Interesting, I was in a hilly area and my low fuel warning came on too. We are waiting for a tow. I was considering trying to push on but don't want to get stuck in a dangerous spot on the highway. We're in a church parking lot.

So, last time this happened I was on flat road with about a half tank of fuel on a lunch break. I ran a mile after the warnings came on to feel out the issue and to see what would happen. I happened to be only about a mile away from my dealer so I drove that way. I got reduced power warning and then it cut power on me (limp mode). I made it to about 100 yards away before it cut off.

This time, I was in a hilly area at night on a windy two lane road with no shoulders in the woods. I was miles from civilization and was showing below a quarter tank of fuel. ~100 miles to EMPTY. I got the low fuel pressure warning first and then the reduced power mode before the whining noise started. I was climbing a hill on a curve at the time. I drove a quarter mile and then pulled off the road into a parking lot so I wouldn't be stuck on the shoulder. It didn't actually go into limp mode.

I let it sit a few minutes, talked it over with the wife and decided to call for a tow. After talking to the tow truck driver who said he would be an hour because he had to go find a bigger truck, I decided to see what I could do while I wait. I fired it back up and the fuel level dropped to below 1/8 and I was now showing 33 miles to EMPTY. I was parked on a hill with the back end up. I had backed the truck into a space to make it easier for the tow truck driver. I let it run a minute, checked for leaks and it seemed to run fine with no studdering or additional warning lights.

CEL was on but no new warnings. I put in my code reader and pulled the P0087. Just one code. I revved it a bit to see if there were any issues. It seemed fine so I decided to try my luck. I started driving towards home with the intention to stop at the first diesel station to fill up. Truck ran fine. After two minutes of driving gently, heart racing, my fuel level came back up and it now read 88 miles to EMPTY. I drove 11 miles to the nearest station and filled up. No issues. I shut it down. I fired it back up. Still no issues so with a full tank, I drove home the remaining 30 miles without issue.

Planning to take it in to the dealer Monday to get it checked. Could this be from an air pocked due to low fuel level and hilly terrain? Is my new pump dying already? Is there something else going on inside the tank or elsewhere?

View 14 Replies

Ford 7.3L Power Stroke (1999-2003) :: White Smoke Blowing / Smells Like Fuel And Loses All Power

I am a mechanic and tow operator running a late 99 f350 7.3 6 speed cab and chassis wrecker. This truck has had a hard life and has been neglected for quite some time, and now has become my baby/headache. Truck starts great, idles nice, and will run great for about 5 minutes until it starts billowing white smoke that smells like fuel and loses all power. If you continue to drive it it will die. Sounds like it's dropping cylinders and will barely idle. If you stop for 5 minutes or so and let it idle it will smooth back out and will run great again for another minute or two, then right back to stumbling.

Using torque app, hpop pressure looks good when it's running well. Peaks at 3k, IPR maintaining 30-40% max. As soon as it stumbles you can see the hpop drop to 5-600 and the IPR will climb to 65%. Let it idea bit and they go back to normal, and stay good until it stumbles again.

Ive changed the fuel pump, ICP,rebuilt FPR, change fuel filter, pulled and cleaned the fuel tank (metal tank, no delamination, looks perfect inside). Pickup screen looked good. Cleaned the IPR, cleaned the hpop reservoir, there was no screen inside. Checked voltage at fuel pump, 11.78 across the pump with it running. Pulled valve covers, no noticeable leaks around injectors. Injectors have less than 5k miles. Remans with 100% larger tips.

To me it seems like the lpop is not keeping up with the hpop under load, starving it until you idle and let it catch up. Could it still be bad injector orings? Bad lpop? Something I'm not thinking of?

View 7 Replies

Ford 7.3L Power Stroke (1999-2003) :: Raw Fuel Smell In Cab

I'm checking all places to look for a fuel leak. I park on a concrete slab, with no drips.

I have already mopped up as much fluid from the valley from recently having all of the injectors replaced. I still need to clean it further with simple green, and stuff white paper towel in the valley so I can really know if there is a leak.

3 years ago I replaced the water drain valve o rings, but I suppose they could have gone bad again.

View 8 Replies

Ford 6.0L Power Stroke Diesel :: Loss Of Power And Lots Of Black Smoke

Today I was riding along and all of a sudden I noticed a loss of power. I look in the rear view mirror and get into the pedal and a lot of black smoke. When I get to where I'm going and stop I noticed the idol was a little loopy. I never saw a check engine light. I have the Edge insight. I had two codes. P1000 OBD System readiness test not complete. P2290 ICP TO LOW.

When I would reset the codes the P1000 came back instantly every time. I parked the truck for about an hour. When I started it back up everything was normal. The power was back and no smoke. This happened two more times throughout the day. I have heard people describe a sticking EGR Valve causing these symptoms. Is that where I should start looking or is the ICP the culprit or something else?

View 7 Replies