Ford 6.7L Power Stroke Diesel :: Oily Residue Under Hood
I got a little oily residue on my hood here. It looks like it might be a little wet near the coolant hose & throttle body area. I also have the H&S Intercooler pipe kit installed. Not sure how long this residue has been there, but it is still wet, so its not all hardened. Maybe it's just loose intercooler pipe bolts?
View 7 RepliesFord 6.0L Power Stroke Diesel :: 2006 - Oily Foam In Degas Bottle?
I have a 2006 6.0 with 165,000 miles. No over heating runs fine ,no smoke but I have oily foam in my degas bottle. No coolant in my oil. Scratching my head over this.
View 14 RepliesFord 6.0L Power Stroke Diesel :: 2006 - Code P0405 - Oily Residual In The Port For EGR Valve
I have this problem code P0405. At fist it come up with a turbo under boost. I have replaced the Turbo and egr valve and I still have the P0405. I did notice a oily residual in the port for the egr valve I see no deference in coolant. She idles good I just have no power when I put it in gear to move.
View 3 RepliesLexus GS 2013+ :: 2015 GS350 FSport - Oily Film On Both Front Windows
I just bought a 2015 GS350 FSport in December 2014 and noticed an oily film on both front windows. This happens whenever I wash my car and wipe it down. I tried to wipe it w/ glass cleaners and detail spray but doesn't come off. It almost seems to be between the dual plain glass.
View 11 RepliesFord 6.7L Power Stroke Diesel :: Diesel Exhaust Fluid Reset?
I've topped up the DEF and the warning is still showing that I'll have reduced engine power within 45kms.
Its weird, just yesterday it showed 550kms to empty so I added one full container, all day it kept showing less and less kms' til empty. Warning lights and bells etc.
This evening topped it completely and still shows. Is there a way to reset it without having to stop at the service dept.
Ford 7.3L Power Stroke (1999-2003) :: Rust Everywhere - Use Fluid Film?
I have rust everywhere but mostly surface rust. For those who use fluid film, should I just buy a few cans and paint the whole under truck with it? Do you wipe off access?
View 14 RepliesFord 6.0L Power Stroke Diesel :: No Power - Studders And White Smoky Exhaust When Warm
Say I just purchased an 06 f250 crew cab with the 6.0.
I had her trailered home due to dead batteries. I got her started up and drove about 5 miles until she got up to operating temp.
When I came to a stop and tried to accelerate, she immediately bogged down and started studdering with white smoke coming from the exhaust.
I shut her down and started her up again. She started and idled fine, but as soon as I pressed on the accelerator, she bogged and studdered again. I shut it down again and started it back up. Normal idle, and I shifted her into gear and was able to mozy on idling forward without having her bog, but as soon as I touch the accelerator, she bogs and studders.
I towed it home and the next day (today) she started just fine and I shifted her into drive and moved it forward about 10 feet. Did not touch the accelerator so she didn't big or studder.
1. I am guessing the white smoke was coolant burning through a failed EGR circuit. Do you seasoned members agree?
2. It the a check engine code when studdering. I have yet to check codes so I am still in diagnosis mode.
3. I plan to block off the EGR pipe and throw in a new oil cooler. Anything else immediate I should be considering??
Ford 6.7L Power Stroke Diesel :: Exhaust Smell In Cab - Fix?
I have an exhaust smell in the cab of the truck. It is pretty strong. Seems worse when it is really cold outside and goes away when outside temps warm up. I checked the tube (passenger side behind engine) and did not see any soot.
View 12 RepliesFord 6.7L Power Stroke Diesel :: Exhaust Smell In The Cab
Was cold this morning, -15c, and I remote started the truck and then left home about 5min later. I could smell exhaust in the cab. I read some of the other threads about this. How can I tell if it was doing a regen? I have an Edge Insight. Is the a parameter I can display to know the regen was active?
View 14 RepliesFord 6.0L Power Stroke Diesel :: SCT Tuner With Stock Exhaust
Looking for if it would be okay to tune my 6.0 with the SCT SF3 tuner with the stock exhaust, I measured it and the stock exhaust is 3 and 5/8 inches...
View 5 RepliesFord 6.0L Power Stroke Diesel :: White Smoke From Exhaust?
yesterday I went out started my truck and white smoke started coming out my exhaust so I turned it off waited a bit started it back up let it run for a bit smoke went away drove it about 60 miles. Later that night it did the same thing but I was 2 gallons short on coolant drove it another 60 miles ran fine. Next morning decided to take it to a shop put more coolant in it drove maybe 20 miles to shop got there turned it off everything was fine never over heated once. So this shop is now telling me my trucks hydro locked and I steamed the EGR valve. And there telling me it's gonna be $8000 to fix it .
View 3 RepliesFord 6.7L Power Stroke Diesel :: F350 Won't Regenerating Exhaust?
Last winter I pulled something and getting out has been difficult. Climbing in my F 350 even tougher so it hasn't been used much. Now that I'm driving a bit I have not seen it regen. Truck stop regenning, is it possible? What happens if it just stops? It use to regen every 200 miles or so and I have been paying attention.
View 7 RepliesFord 6.7L Power Stroke Diesel :: Second Exhaust Sensor Failure
I'm at 76K miles and I had another exhaust sensor go bad. This time the check engine light came on and the truck did not shut down. I was prepared this time and had an extra sensor / code reader handy.
It was the last sensor in line and very easy to get to. It took me less than five minutes to complete the job. I did use anti seize, but as easy as it came out it probably wasn't necessary.
Ford 6.0L Power Stroke Diesel :: Cannot Get Exhaust Manifold Bolts Off
I can't get my exhaust manifold bolts off. They are in bad shape. The 10mm is too loose and 3/8 just rounds. I have had the torches on them too! Can the bolts be cut off with a torch?? Haven't broken any. Can't get the bolt heads to move. It's an 04, original manifolds. I am working the driver's side. I can't figure this one out. How to get this manifold off?
View 4 RepliesFord 6.0L Power Stroke Diesel :: Changing Right Exhaust Manifold?
How difficult is it to change the passenger exhaust manifold? I have just finished replacing the left exhaust manifold. The biggest issue was rusted fasteners and inexperience. Have torches. Any you tube videos show the left manifold being changed but not the right. I do not have a hoist and work in my driveway. Is the right side more difficult and should I leave it to someone with a hoist?
View 4 RepliesFord 6.7L Power Stroke Diesel :: Steam Coming From Exhaust
So for the first time in a while I started my truck when it was cold outside, 33 degrees according to the truck. It didn't do this at initial startup but when i started driving there was what i think steam coming from the exhaust because it dissipated fairly fast. It steamed slightly until i went to pull out of my neighborhood and got on it to get up to speed which was only 45mph. The oil temp was in the 90s at that point but when i got on the pedal the truck just started pouring white steam out of the exhaust.
Over time the truck warmed up and the steam stopped and everything was fine. Even when its warm outside the truck blows something when its not at operating temp but when its warm I can only see it at night when there's headlights behind me. Since I've had the truck the only thing that I've had to replace was the radiator because it was leaking coolant and even after that i still smell burning coolant occasionally and sometimes when i check my tank its low and then sometimes it never changes. Its very inconsistent.
The only other bad thing that's happened to the truck happened after i got my oil changed for the first and last time at NTB. They replaced the filter when they changed the oil but didn't pull the old gasket off when they put the new filter on and long story short i lost about a gallon within 30 minutes because of that and had my truck towed home. My engine light never came on or anything. I fixed the problem, added new oil and that was it. The reason I bring up the radiator, the coolant, and the oil is because i don't know if that could have anything to do with the steam.
Ford 6.7L Power Stroke Diesel :: Stock Exhaust Removal - Need DEF?
I want to get rid of the stock exhaust and run a 4' or 5' exhaust all the way back. Will I still need to use DEF? Completely remove the whole system.
View 9 RepliesFord 6.0L Power Stroke Diesel :: Low Power Before Boost Kicks In / Idling Rough With Blueish White Smoke Coming Out Of Exhaust
I just looked back and it has been since July 7th that my girl has been sitting in my shop. Well this past weekend I finally got her back together and started. It took a while to build pressure but she finally came to life..
While I am thrilled that she is running again i have low power before the boost kicks in and is idling rough with a blueish- white smoke coming out of the exhaust. Once i kick her a little she will get up and go but I've never had the smoke before.
I'm thinking maybe a bad injector???
Ford 6.7L Power Stroke Diesel :: Downside For Exhaust Brake Usage?
Any downside to using (enabling) the Exhaust Brake (aka 'Jake' Brake) all the time?
I ask since there is a switch to turn this on and off, and I wonder why. My experience driving fire trucks in a previous life was that the Jake Brake was always enabled (I do not recall there being any way to turn it off).
I suppose that on icy roads, it is probably a good idea to not have it on, but that is all I could come up with. Am I missing something?