Ford 6.0L Power Stroke Diesel :: Fuel Pressure Dropping Under Acceleration Intermittently
Been having a problem with fuel pressure dropping under acceleration intermittently. Normally runs around 65psi, sometimes at idle or normal driving is only 55-60psi lately. Most of the time it has done this it dropped to 50 and I let of the pedal and it will slowly go back to around 55. Then I just baby it and it will slowly creep back up to 60 or maybe 65. A couple times it has gone below 50 after letting of the pedal and wouldn't go back up, so I actually pulled over and shut the engine off and cycled the key to get it back up. Once this happened while towing up a hill, I could only get to around 35mph really had to baby it and at the top I pulled over and cycled the key and it came right back up. At the time I attributed it to the steep hill, 11k trailer, and the tank only being about 1/4 full.
Since I put the fuel gauge on way before any of this started happening, it has always fluctuated 2-3psi at idle. I always thought it was kind of odd, maybe pointing to combustion gasses entering the injector through a bad seal or something weird like that, but a couple of people have told me that fluctuation is normal.
I'm thinking there's either a restriction in the fuel pickup or the pump is going bad. This problem happens even when the tank is full, but seems worse on a low tank. I change my fuel filters every 10k mi, I'm at about 9k right now so I guess it could be dirty filters? Got lots of towing over the passes coming up as fishing season is just starting and I'm sure we'll be spending as many weekends we can at the beach camping.
Ford 6.0L Power Stroke Diesel :: Stuttering On Acceleration / Fuel PSI At Idle Barely Move
I fear my truck may be stuttering on acceleration.
I hooked up a fuel pressure gauge tonight and the fuel PSI at idle and under acceleration... barely moved. Stayed between 60-62PSI.
I'm thinking this isn't normal... shouldn't the PSI be reduced especially when I accelerate hard ?
I'm thinking the "delivery" fuel line... perhaps there is a bottle neck somewhere which is causing constant PSI at the fuel housing ?
Ford 6.0L Power Stroke Diesel :: Running Rough After Installed Trans Tune?
I towed my 32 ft/ 600lb travel trailer 115 miles into arkansas today. When I arrived at the campground, the engine was running rough and shaking the vehicle. I saw highs of 175 (trans temp) 1150 (EGT), 214 (ECT), and 224 (EOT).
I recently installed the canned trans tune from my new SCT X4.
I pulled codes (none), checked cylinder misfire count on scangauge 2 (none). In fact, all gauges on the SG2 were within spec. I popped the hood and let it idle for 15 mins. Temps all dropped down to what I usually see after normal driving (not towing).
The engine did start to calm down as it cooled, but still sounded a rough
Ford 6.0L Power Stroke Diesel :: Oil Pressure With Race Tune On Stock Injectors
I have a bit of a quandary with my 6.0 and I'm wondering how it compares to others. If you have a hot or race tune (example: super panty dropper) on your 6.0 with stock injectors, what is the peak high pressure oil that you see at full throttle?
Need to know high pressure oil PSI @ full throttle, year (or better yet which style hpop you have if you know), if your ecu tune is a "race" tune, and if you have any FICM tuning.
Ford 6.7L Power Stroke Diesel :: 2013 - Tune Getting Hot And Keeps Going Into Limp Mode When Towing Up Hills
What's the best tune for this motor? I have an hs mini max with the spe hot tune and has nothing but problems towing with with it. They swore up and down for a year I was the only one with issues for a year and then finally admitted it's not good for towing and lots of people had issues with it so they gave me their towing tune for free but it isn't very good either.
The hot tune is a little too hot and keeps going into limp mode when towing up hills even on the lowest stock setting, or really getting on the throttle on any setting not to mention way too high of boost for a stock turbo at 30-32 on every level . It makes sports cars look slow before hitting limp mode though.
Their tow tune fixed that problem but it's boost is too low at only 18-19 (had 24 running stock Ford programming) and it smokes like crazy, more smoke on higher settings without getting any faster or any more boost. It doesn't smoke much on the stock setting but clearly the other settings aren't very well tuned.
I want a tune that will tow 25k without issues and smoke(not literally) sports cars off the line at factory boost level s so it doesn't blow the turbo.
Ford 7.3L Power Stroke (1999-2003) :: Shuddering Low Gear Acceleration When Towing Heavy?
2002 F350 7.3, MANUAL transmission ZF6.
Bought this truck used for hauling an excavator, and after fixing damn-near everything engine/turbo/and-cooling-system-related ---- it's finally seeing some use.
Just recently started hauling 12,000lb payloads. When I accelerate hard in Low gear, and then shift into 1st and accelerate hard again, I feel the whole truck shuddering. It's like a shimmy-shaking vibration all through the vehicle.
It doesn't happen in higher gears, only when the following conditions are met...
1) Starting from a dead stop
2) 12,000lb payload (heavy)
3) Accelerating hard (Low, First gear)
I would also like to add that I experienced this shuddering vibration very intensely when I put the transfer case in 4wd LOW (front manual hubs left unlocked) and towed 14,000lb up a steep hill in 1st, 2nd, and then 3rd transmission gears.
^^^ By leaving front hubs unlocked and transfer case in 4wd LOW, I was effectively lowering my final drive ratio even more for extra pulling power in 2wd hill-climbing. I don't do this often, only when absolutely necessary. ^^^
I must also add that I do have slightly taller rims/tires than OEM ford WITH the original ford gearing (3.73) so I'm more like 3.51 final drive ratio.
02 F350 7.3l ZF6
Ford 7.3L Power Stroke (1999-2003) :: Zf-6 Trans - Slips Under Heavy Acceleration In 6th Gear?
Ok, my clutch has been giving me trouble for a little bit and I'm almost positive that I have a bent release fork. It also slips under heavy acceleration in 6th gear. I am planning on doing a clutch, compete with flywheel and release fork and a new rear main seal. My problem is, here within the last couple of days the trans would pop out of 4th gear if I was just coasting. It has been getting noisy over the last few weeks also. I'm no manual tyranny expert, but this is making me think I'm gonna need to have it rebuilt.
View 14 RepliesFord 7.3L Power Stroke (1999-2003) :: Smoke / White Haze Under Heavy Acceleration On Occasions
My truck 00' 7.3 255k is smoking white. It's not thick its more of a white haze. Sometimes it does it sometimes it doesn't. It has a 6637 intake, exhaust, and wicked wheel. No tuner or such. Im thinking either the turbo is going out or maybe a leaky injector? Just checked the turbo wheel and it has a little side to side play. On start up itll puff white then go away but then under heavy acceleration on occasion there is a haze of white then goes to haze of black. It also feels like the truck is lacking some power. There is no oil in the coolant or coolant in the oil. Not consuming oil or coolant. And there is no excessive pressure coming out of the oil fill.
View 8 RepliesFord 7.3L Power Stroke (1999-2003) :: High Pitched Turbo Whine Under Heavy Acceleration
I'm on the road and I pulled over for a pit stop so I don't have time for a search right now, but I noticed under heavy acceleration a turbo whine so high pitched it almost sounds like metal on metal. Is this normal and I just noticed it, a leak somewhere, or maybe indication of something worse? The truck seems to be running ok otherwise. It's an '02 w/7.3 and 220k miles.
View 3 RepliesFord 6.7L Power Stroke Diesel :: Randomly Cuts Out When Accelerating
I have a 2013 that randomly stutters or cuts out for a second while accelerating. This happens whether I am slowly accelerating or full throttle. This used to happen once every few months but it is happening more frequently now. It will randomly happen while trying to accelerate on the freeway. The truck feels like it stalls, then takes off. It feels like it loses boost pressure so maybe a wastegate issue or possibly an EGR valve issue. No codes are set.
View 14 RepliesFord 6.0L Power Stroke Diesel :: Intermittent AC / Cuts Off After Some Time
I have a 2004 F250 4x4 with 204,000. runs great! But last year, I noticed the A/C would work fine to begin with, but after running down the road a bit, it would cut off and I would have to turn it off, let it "rest" a bit, then it may or may not come back on, now I am a electrician by trade, and I figure it is a bad switch somewhere, but a intermittent problem is heck to find sometimes!!!
I replaced the low pressure switch in the accumulator, then I was thinking the little wiring plug might be bad, so I replaced that but it's still doing it. I was going for the relay next, but I'm not sure which one it is and can't seem to find a wiring diagram for the system. I'm stumped on which way to go. Its full of 134a and will freeze you out--- when it works!!
Ford 6.0L Power Stroke Diesel :: Truck Overheats And Cuts Off
I have a plow truck that over heats and cuts off. And when it cuts off it won't start till next day? I know the plow has to be low this is not my first plow truck.
View 1 RepliesFord 6.0L Power Stroke Diesel :: Whistle Under Heavy Load
I posted earlier about a whistle that appeared when I was towing my old travel trailer (6000 pounds). It only happened a couple of times, and I had a hard time replicating it, so I elected not to waste any money with the deductable, and possible additional costs for a non-covered issue at the stealership.
Now, I am towing a larger 5th wheel trailer (11000 pounds), and am experiencing this whistle on every steep grade, while towing. Below are a couple of things I noticed, that had to be, before I would get the whistle:
* It only seems to happen while the cooling fan is engaged, and also only when the rpms reached 2800 and above.
*If the fan was on, but the rpms were turning below 2800 rpms, then it would not whistle. It would, however, after the transmission downshifts, bringing the rpms back up, while climbing.
*If the engine was spinning at 2800 rpms, and the engine fan was not engaged, then it would not whistle, until the fan would kick in.
* It only seems to occur when I am climbing a steep grade, on a warm day. Although, I haven't experimented on steep grades on a cold day...
It sounds to me like there is an issue with the engine fan system, but I thought I would put it out there, just in case any of the diesel guru's out there might know of something else that would cause a whistle like this, i.e., turbo?
Oh by the way, I also think that I have a performance reduction lately. However, I can't know for sure, as I have never towed this much weight with my truck before. I just kind of expected that I would be able to pull to the top of these grades, with a little extra peddle to spare. I have to floor it, just to "try" and keep up with traffic. And I haven't calculated my fuel mileage while towing this beast yet, but WOW, that fuel gauge needle sure does drop like a rock!
Ford 6.7L Power Stroke Diesel :: Bluetooth Cuts Out Then Came Back About 5 Minutes Later
Where the factory BT module is located? The other day while listening to music, I hit a bump and my bluetooth cut out, then came back about 5 minutes later. Almost as if it lost connection to the stereo then reconnected....wondering if something isn't connected securely...
View 3 RepliesFord 6.7L Power Stroke Diesel :: Radio Makes A Pop Noise Then Cuts Out?
Lately (within the last year) after about an hour in the truck my radio will make an electrical pop sounding noise and then the sound cuts out for about one second. The pop is not very loud. It will do this about every 15 seconds at first and then after ten or so minutes it's every 1-3 minutes. Doesn't matter the source, it does it on all of them. The volume is at normal (adult ) listening volumes. Interestingly the subwoofer does NOT cut out which points me towards the amp inside the radio. It also seems as if heat may be part of the issue as it takes a while before it happens. If I turn the radio off and wait 15 minutes and then turn it back on it will work for a few minutes and then start popping.
View 14 RepliesFord 6.0L Power Stroke Diesel :: 2003 - Misfire Under Heavy Load?
I have a 2003 f 350 6.0, when under a heavy laod such as towing a 3000-pound trailer up a long hill at approx 60mph and 2000 rpm it intermittently mis fires.The boost gauge bounces up and down and i here a poping sound from the engine compartment.I have had it to several dealer and independent shops but with out the trailer or a heavy load it runs perfectly.They have told me fuel pressure is good and changed all fuel filters with OEM parts.
View 3 RepliesFord 6.7L Power Stroke Diesel :: Regen While Towing Heavy With Low Soot Already?
Over the holiday weekend I towed my 13k# 5th wheel 180 miles to the campgrounds.
According to my Torque Pro app, soot was around mid 30% when I left home. Upon arrival it had passively dropped to single digits.
After driving unloaded a few times over the weekend, the soot level had gone back up to mid 30s.
While towing home it again had passively dropped back to 1.1% .......... then boom! A regen starts.
After 22 miles it completed and soot had dropped to -13.2%.
So towing heavy, passively burning soot off, exhaust temps in the 700-800 weren't good enough for the system.
It had to start a regen and boost tempts to the 1100-1200 range WHILE TOWING to basically burn off NOTHING.
Not to mention drop my already poor MPG to single digits.
Just venting about what appears to be unnecessary exposure to high temps and wasted fuel.
Ford 6.7L Power Stroke Diesel :: How Long To Idle A Hot Engine After Heavy Towing
Now that I have gotten my ScanGauge II to monitor all 4 egt sensor, I am wondering about temperatures while towing, especially how long to idle a hot engine after heavy towing.
I realize all 4 sensors are post turbo (and there is no chance I'm going to drill for an after market pre-turbo sensor). It seems the first one downstream will be the one to watch.
What temperature range we should look for before turning off the engine? IIRC, Ford recommends idling for 3 to 5 minutes, but watching the temp seems a bit more specific.
Ford 6.0L Power Stroke Diesel :: Knocking Sound / Heavy White Smoke
So I am owning my first diesel so I am still getting use to it. Shortly after I bought it, I had to make my 900 mile drive to work and it ran great. After being here for a week or so I noticed heavy white smoke bit thought it had to do with the -5- -10. And haven't seen the white smoke since the weather warmed up. Since then I have noticed a "knocking" sound that to me sounded like a rod that I didn't notice before. After reading through these forums, it sounds like I probably have a cracked injector. I have had no engine light or anything. So my question is, can an injector fail or be cracked without an engine light and can a code reader detect which one it is with no light on?
View 6 Replies