Ford 6.7L Power Stroke Diesel :: Low Fuel Pressure - Sensor?
truck runs fine changed fuel filters could it be bad sensor .no cold weather
View 2 RepliesFord 6.0L Power Stroke Diesel :: Oil Sensor Location?
was looking for the oil pressure sensor and can't find it got it narrowed to 2 there is a sensor between the the oil filter and fuel filter i think thats the temp sensor and then there's 1 at the say 11 o'clock position behind the the oil filter...both have a 2 pigtail connector.
View 4 RepliesFord 6.7L Power Stroke Diesel :: EGT Sensor Location Diagram?
The tech folder "Coffee Table" book link is broken - no more visual aid from there! So, Looking for a copy of the illustrations that show the EGT sensor locations?
View 3 RepliesFord 6.0L Power Stroke Diesel :: Transmission Speed Sensor Location
I've been searching and searching but I just cant find out the location of the Transmission Speed sensor, It would be the one that controls your speedo and Transmission pressure? Is it located on top of the rear differential?
View 4 RepliesFord 6.0L Power Stroke Diesel :: 2005 - Oil Pressure Switch Location?
where the oil pressure switch is on a '05 E350 6.0 PSD? My filter is on the bottom, is it near or part of that housing?
View 9 RepliesFord 6.7L Power Stroke Diesel :: Low Fuel Pressure And Reduced Pressure Limp Mode
My truck gave me low fuel pressure and reduced pressure limp mode at 21,000 miles. The fuel and air filters were changed at 16,000. The dealer said all they found was the fuel filters (at 21,000) were what needed to be changed. Also, why does my truck hum??
View 14 RepliesFord 6.7L Power Stroke Diesel :: Whining Sound / Low Fuel Pressure And Reduced Power Warning - Fuel Pump Just Died
So, I just had the fuel pump replaced on my '15 6.7 a month ago and it just died again. (next day edit: it didn't actually die, it showed all the same symptoms)
Same symptoms: whining sound, low fuel pressure warning, reduced power warning.
This time I'm 50 miles from home so I pulled off the road before it shut off. Interesting, I was in a hilly area and my low fuel warning came on too. We are waiting for a tow. I was considering trying to push on but don't want to get stuck in a dangerous spot on the highway. We're in a church parking lot.
So, last time this happened I was on flat road with about a half tank of fuel on a lunch break. I ran a mile after the warnings came on to feel out the issue and to see what would happen. I happened to be only about a mile away from my dealer so I drove that way. I got reduced power warning and then it cut power on me (limp mode). I made it to about 100 yards away before it cut off.
This time, I was in a hilly area at night on a windy two lane road with no shoulders in the woods. I was miles from civilization and was showing below a quarter tank of fuel. ~100 miles to EMPTY. I got the low fuel pressure warning first and then the reduced power mode before the whining noise started. I was climbing a hill on a curve at the time. I drove a quarter mile and then pulled off the road into a parking lot so I wouldn't be stuck on the shoulder. It didn't actually go into limp mode.
I let it sit a few minutes, talked it over with the wife and decided to call for a tow. After talking to the tow truck driver who said he would be an hour because he had to go find a bigger truck, I decided to see what I could do while I wait. I fired it back up and the fuel level dropped to below 1/8 and I was now showing 33 miles to EMPTY. I was parked on a hill with the back end up. I had backed the truck into a space to make it easier for the tow truck driver. I let it run a minute, checked for leaks and it seemed to run fine with no studdering or additional warning lights.
CEL was on but no new warnings. I put in my code reader and pulled the P0087. Just one code. I revved it a bit to see if there were any issues. It seemed fine so I decided to try my luck. I started driving towards home with the intention to stop at the first diesel station to fill up. Truck ran fine. After two minutes of driving gently, heart racing, my fuel level came back up and it now read 88 miles to EMPTY. I drove 11 miles to the nearest station and filled up. No issues. I shut it down. I fired it back up. Still no issues so with a full tank, I drove home the remaining 30 miles without issue.
Planning to take it in to the dealer Monday to get it checked. Could this be from an air pocked due to low fuel level and hilly terrain? Is my new pump dying already? Is there something else going on inside the tank or elsewhere?
Ford 6.0L Power Stroke Diesel :: Oil Pressure Switch (Sending Unit) Location On E350
Will the oil pressure switch (sending unit) on my E series van be in the same location as on an F series truck even though the van's oil filter is under the engine instead of on top? I'm referring to the single wire sender for the dash gauge.
View 2 RepliesFord 6.0L Power Stroke Diesel :: Surging After Oil Pressure Sensor Replaced
I have a 2007 f350 6.0, just replaced the oil pressure sensor in January, now, my truck is surging like crazy! I heard it could be the ICP sensor, how easy is this to change? And where do I find it if this is the problem!
View 1 RepliesFord 6.0L Power Stroke Diesel :: Died - Low Fuel Pressure - Blew White Smoke - Diesel Smell?
no change, changed stand pipe and dummy plug on driver side, no change and guess what? Now I am stuck on the side of the road waiting to give my last $100 to a tow truck! Engine is hydrolocked, fuel pressure is low, starts off at around 20 and works up to 54 with key on engine off, and that is as much as I know from the side of the road with out my AE. Blew white smoke also. Smelled of unburnt diesel. I think it's linked to my rough running issue. Maybe a bad injector? But every time I did the click test they all passed. Idk, I'm gonna remove the glow plugs and see which hole is loaded and with what. . .
View 14 RepliesFord 6.0L Power Stroke Diesel :: Code P0470 Pointing At The Exhaust Pressure Sensor
I have a 2004 6.0 with 75000 miles on it. My truck is throwing a P0470 code pointing at the exhaust pressure sensor. my question is do I need this sensor or can i bypass it? When I look up the part it only shows 2005 and up.
View 6 RepliesFord 6.7L Power Stroke Diesel :: Low Fuel Pressure Came On?
Driving to work out of town and low fuel pressure came on screen.... fuel filters??
View 14 RepliesFord 6.0L Power Stroke Diesel :: Low Fuel Pressure At WOT
I just installed my fuel pressure gauge, only to find out that I'm running with low fuel pressure at wot. My filters have a little over 2000 miles on them and I've had the blue spring installed for a while now. It drops to about 36psi from 61 or 62psi. What could be the culprit? Also I'm running the out of the box street tune that comes with the sct x4 because I get about 15mpg with it.
View 11 RepliesFord 6.7L Power Stroke Diesel :: Water In Fuel Sensor
Tonight I changed my fuel filters for the first time. Went well. However, when I was hooking up the WIF sensor connector, it wasn't pushing in very well. I looked and the pins were straight, I kept messing with it. I noticed that the sensor was loose in the housing. It looks like there are about 4 tabs that hold the end of the sensor in the housing. When the end of the sensor came off, one of the two springs and 0-ring popped out. I managed to find them and re-assemble it. Is this a normal occurrence? Do I need to order a new housing? If it falls apart and I get a WIF message, is there any type of de-rate that happens or can I keep driving?
View 1 RepliesFord 7.3L Power Stroke (1999-2003) :: 2002 - Fuel Pressure Gauge - Install Sensor Into Lift Pump?
I am installing a fuel pressure gauge into my 02 7.3 I went to the thread the sensor into the plug hole on the fuel filter housing and it wasn't threaded, turns out the sensor thread is slightly smaller and a different thread ... The directions say to install it into the filter housing or the lift pump ... So I'm assuming I have to go the lift pump direction of installing it but where the lift pump is or how to install the sensor into it while not throwing a code or causin problems ... A step by step and even pictures.
View 14 RepliesFord 6.0L Power Stroke Diesel :: Fuel Pressure Dropped
I recently installed a glow shift fuel pressure gauge. All seems good.
@ idle 58-60 psi
@ WOT drops to 50 psi, no less.
Tonight I went to catch up to a car that had no lights on at all to tell them and during WOT fuel pressure gauge showed it dropped to less than 30! I let off immediately and it went right back up. I tried to repeat it with another go @ WOT and it would not go under 50 psi like normal.
Motorcraft fuel filters less than 3000 miles ago .. Blue spring installed over the winter.
Ford 6.7L Power Stroke Diesel :: Low Pressure Fuel Pump
So I just replaced the low pressure fuel pump on my 14 6.7 and it seems to be running as good as it was before. I need to get an aftermarket fuel filter setup for my truck. So what are you using, why did you pick that particular system and is it working, does it really work for taking out water and other contaminates? These fuel systems don't seem to be up to par in filtering modern day fuel, I need peace of mind.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Low Pressure Fuel Warning Came On
Low-pressure fuel warning came on two separate times Sunday ... I know what caused it the fuel gel 18 below not enough anti gel in the tank no big deal warm the truck up everything's fine now no more warning lights coming on does the dealer need to reset anything I guess I'm asking did it throw a code that needs to be cleared? Its running fine now I guess I'll just have to put a little extra in when it gets that cold wasn't expecting - 18 checked drain no water just gel up could here the pump under the truck fighting to pump for a few minutes.
View 14 RepliesFord 6.7L Power Stroke Diesel :: Low Fuel Pressure Warning?
65 miles an hour driving down the interstate (I-5) pulling my 5Th Wheel and I look in the mirror and I see at first what I thought was smoke coming from the trailer and then I glanced at my dash and up pops "warning of Low Fuel Pressure". I pulled over as quickly as I could and when I stopped there was diesel fuel spray coming from under the hood. Turned off the key yelled for wife to get out of the truck now. Popped the hood and there was fuel dripping from the engine the all the way to the rear bumper and the front of the trailer.
Since I just had Ford service the truck and change the fuel filters three weeks ago I knew exactly what happened as I looked at the fuel line and seen the green retainer clip wasn't seated properly to the filter canister. I pushed the line in and seated the green clip. What I don't understand is I have driven the truck 200 miles since it was serviced. I re-attached the line and made sure the clip was seated correctly, poured 5 gal of water on the engine plus after using a roll of paper towels to soak up fuel. I didn't want to panic the dear wife but it could have very easily all went up in smoke!
What a mess it made of the Trucks undercarriage and 5th wheel. Going give a call to Ford tomorrow to hear what they can do to clean up this mess.
Question? This happen on a 6.7 after a filter change?