Ford 6.0L Power Stroke Diesel :: 2003 F350 - No Headlights / Overhead Console Is Dead
Just bought a 03 F-350 dually today. 6L 4x4.
Headlights don't work , everything else does? Dash lights , taillights , cab marker lights all work. Headlights and front park lights don't?
I also see the overhead console is dead and shows nothing? Plus the ignition turns without a key being in it?
Ford 7.3L Power Stroke (1999-2003) :: 2001 F350 - Swapping Overhead Console With Longer One?
I was wondering about swapping out the short OH console on a 2001 F350 Lariat with the longer one that has two doors for a garage opener etc? Are the clips on the base plate the same? I see the longer console shells on e bay for a little over 100 bucks which seems like a no brainer if it snaps in place of the shorty. Looks like the temp and compass slots are identical.
View 4 RepliesFord 6.0L Power Stroke Diesel :: Compass On Overhead Console Gone Dead
2004 6.0 lariat ... The compass on my overhead console has gone dead or at least doesn't show anything other than sometimes calibrating ... All other functions miles to empty etc work fine just the compass feature ...
View 2 RepliesFord 6.0L Power Stroke Diesel :: No Power To Overhead Console
Just did an interior conversion to my truck from xlt to lariat. I installed a new headliner with the overhead console, took the kick plate off where if it existed would be. Found the harness to plug into but noticed it only had a thicker black wire coming out of it, the harness for the overhead console had around 12 or 13 wires. I don't have a volt meter to test the wire on the truck side. But beings this is my first time installing an overhead console I'm not sure what hardware I need or what I'm doing wrong. Did research on the Internet and there's not much on installing overhead consoles. All I've seen were repairing the circuit board which visually checked and didn't see any cracked solders.
View 3 RepliesFord 6.0L Power Stroke Diesel :: 2004 F350 - Missing Like Lost Injector And Losing Power
I have a 04 F30 4x4 with a sick 6.0 power stroke. It has 230k on the mileage and ran good. I was driving at speed when she started missing like it had lost an injector and loosing power. The RPM's dropped under 1000 so I had to pull over off the highway. When i pulled over and put it in park it shutoff. Tried several times to get to start but after 10 minutes it started up. I drove about 2 miles and it started the same process. This went on 2 more times before I was able to finally limp home the 40 miles.
It never shut off again but ran very poorly. I put a new valve in and when I tried to start it just mad a pound clunking/clacking noise. The repair shop put a starter in it because it had stopped engaging and was going to ruin the fly wheel. I looked at it and it was eaten up pretty bad from trying to get the engine to turn over. So now all it will do is a single clunk and will not turn over. He says it could be a bad injector that flooded a cylinder or blown up in the bottom end. He did take serpentine off and still no go.
Ford 6.0L Power Stroke Diesel :: 2004 F350 Started Sputtering Like Missing / Black Smoke
My dad has a 04 f350 6.0 and on his way back from a trip he filled up and drove 60 miles and it started smoking white smoke, after he let it sit a while he added fuel injector cleaner thinking it might have been somewhat bad fuel. Drove it 20 more miles and it it changed to black smoke and started sputtering like it was missing. Blowing a lot of smoke. Took it to ford dealer and they checked for codes and it said the #8 injector was bad and needed replaced. My question is would the injector going bad cause all the smoke and missing?
View 1 RepliesFord 7.3L Power Stroke (1999-2003) :: Overhead Console Removal
A while ago (1 yr) I read and did the pull the wire thing to keep the lie o meter bright all the time. It worked fine, but all of a sudden it seems dim. I can barely read it in the day time. Fine at night. Could it be that the LED's are starting to fail, or some other weirdness? How to remove the overhead console?
View 12 RepliesFord F-150 (2004-2008) :: 2007 - Power Mirrors And Overhead Console Lights Not Working?
I have checked the fuses, Checked the relays, Checked for pinched wires and checked for a loose connection at the fuse box, Both power mirrors and the overhead console lights do not work, Power windows work fine, Manual seats .
View 1 RepliesFord Super Duty (1999-2016) :: 2004 F250 - No Power On Overhead Console With Sunroof
2004 F250 - My problem is that it started with no power on LCD (the one that shows the MPG,compass and outside temperature) but if I give toc, toc, toc with my knuckles the LCD works but it went off about 2 weeks ago and stop function,the other things like the sunroof switch and the 2 lights are ok...
View 5 RepliesFord 6.0L Power Stroke Diesel :: 2004 - Missing When Cold - Swapping Injectors?
I have 1 bad injector well it's missing when it's cold and two others that are "weak" I'm wondering what kind of job it would be to do by myself?
View 14 RepliesFord 6.0L Power Stroke Diesel :: 2004 - Missing And Rough Idle After Sitting All Day In Rain - Parked
Truck (04 excursion, 2WD, early build 6.0, 160k) started missing and rough idle on way home from work after sitting all day in rain - parked. started fine in morning and drove to work with no trouble - it was raining over night too.
To get you up to speed. for a few weeks before had intermittent trouble starting. would fire up as normal, fast and loud, but then stall immediately (usually after sitting overnight). would start back up but with a little long on the key and some gas pedal action. only happen one out of ten or twenty starts and seemed to follow getting fuel in unknown locations while on a trip out of town. decided to change out fuel filters and drain separator. seemed to fix it for a week or so then it happened again two days before above event, while weather was dry. Not sure if related but only recent problem to speak of.
Back to current:
- no check engine light or codes (I have a scanner)
- stalled out close enough to home the night in question I rolled it into driveway and tried to start it while rolling in neutral - no start
- once parked in driveway also no start
- next evening wanted to get it into garage (to dry off) and it started but rough idle and missing. this was after 24 more hours sitting in rain.
- been in garage 24 more hours and this evening got it to run but same result (rough idle and hard start). tried to check connections (mainly FICM) and move wire loom around - still same.......
Where to check next, need some diagnostic...
Ford Excursion :: 2004 Expedition Overhead Console Identical To XLT?
Do the Ford Expedition overhead console is identical to the Excursion? I have an '04 XLT and the overhead console is damaged. I found a replacement unit for the '04 Expedition in the same color and the seller has no idea if the units are interchangeable.
View 2 RepliesFord 6.0L Power Stroke Diesel :: 2004 F350 - Oil In Coolant
I have an 04 f-350 that I did an EGR delete, new Ford oil cooler, new radiator (not ford), new thermostat (not ford), coolant filter, glow plugs and harness, MBRP theoretical 4in downpipe (was 3.5 to converter) flushed cooling system with lots of tap water before the delete, replaced coolant with Cat 1 ELC and distilled water, fresh T6 5W-40 and filter, several weeks ago. Was troubleshooting a wireing problem and found what looks like oil sludge in the degass bottle while under the hood.
Possible that while doing EGR delete I clipped a gasket? Truck runs great, no smoke out the tail pipe. There is what looks like about a cup floating on top the coolant. Oil level is down about a 1/2 quart and clean, no water in it. Where do I start looking?
Ford 6.0L Power Stroke Diesel :: 2004 F350 - Fan Won't Turn Off
I have a 2004 Ford f 350 superduty. Everything runs great. Now the other day my fan came on and stayed on for three days now. It goes with my rpm so when I am doing a 100 down the highway in hopes it will disengage but won't.. Everything is Stalk.
View 3 RepliesFord 6.0L Power Stroke Diesel :: 2004 F350 - Lack Of Power While Accelerating / Stall And No Start
I have a 2004 f350 with a 03 bullet proofed motor. The truck did not have any power and the turbo wouldn't support until I put a new vgt solenoid in and it ran great for about 3 miles... Stalled doing 65 kinda lacked power while accelerating but got up to speed quick. I pulled over and no start. It is running error code kam on pcm from disconnecting batteries but could this cause the stall and no start? Or should I be looking into icp sensor?
View 2 RepliesFord F-150 (2004-2008) :: Overhead Console Map Light Bulb Replacement
How to change out the bulb(s) for the overhead console map lights. The lights that you push on / off. Since the owners manual doesn't cover bulb replacemnet for that.
View 14 RepliesFord Audio/Video System :: Tapping Into Power At Overhead Console
I'd like to stick my Garmin up next to the rear view mirror and not have a wire hanging down. Tapping into power above the overhead console? I should be able to clip the plug off the Garmin power cord and tie into 12vdc directly and tuck the short wire where the rear view wire comes out.
View 3 RepliesFord 6.0L Power Stroke Diesel :: 2004 F350 Cutting Out / Sometimes Won't Even Crank
About a month ago my truck was cutting out at one point it wouldn't even crank, got it going took it to the shop found my driver side battery clamp cracked, replaced it aswell as the egr valve because I had a p0401 code. Valve was pretty gummed up. Now recently it started doing it again. It cut out and it started right back up then later that night drove it two blocks and died, turn the key on and my glow plug light stayed on and wouldn't crank, was checking over all my connections and nothing seemed to be wrong. And then randomly it seemed like everything reset and my injectors would buzz, glow plugs cycled and fuel pump kicked on and started right up and drove home.
I replaced the pcm relay because one terminal looked to have gotten hot. Let her warm up in the driveway and she cut out twice but started right up. Checked over the connections again, replaced and cleaned both batteries, took it for a drive and no problems, later on started up again and let her warm up and cut out again, this time I got the p0401 code again. (Egr insufficient flow). I'm at a loss not sure where to keep going. It's an 04 f350 with egr delete, banks turbo and intake, with edge juice with attitude tuner on level 3 never switched levels around. And some other add on and mods that could make the list go on.
Ford 6.0L Power Stroke Diesel :: 2004 F350 Will Run Great Then Eventually Die
2004 later year 6.0 F-350. 155,000 miles. All stock.
It will start and run fine. Drove it for an hour then began running rough. Nursed it back home. When idling it eventually died. It will eventually fire up but runs really bad. It has done this a few times. I've done fuel filters and 911 fuel treatment because thought it was gelling. No luck...
It has injector circuit fault codes that pop up. Only other code is MAF sensor low but in range. First it was codes for cylinders 3,5. Then 3,5,8. Then 1,3,5,8. Now just injector 1. Keeps changing as I refresh. Battery power fine. FICM is 47.5- 48volts and in sync. ICP at idle is 600-700psi. IPR is 25%.
We had a problem with blowing turbo pipe off so may be overboosting. Not sure. No code thrown relating to that. Possible wire chafing? Maybe bad tank of fuel? Not sure where to turn at this point.