Hyundai - Elantra :: 2002 - Rough Idle And Misfire When Hot / Intermittent Hesitation When Accelerating
2002 Hyundai Elantra GT 2.0L 140k miles
Symptoms:
- Intermittent rough idle when hot, slight shutter, surges between 700-800rmp
- Intermittent hesitation when accelerating, cylinder 2 misfire when hot and under load
- Misfires in all gears under load, mostly when under 2000rpm
- Code P0302 when scanned, no other codes
- Symptoms appeared suddenly, not gradually over time
What's been changed:
- Replaced spark plugs, little or no improvement. Old plugs looked worn, but generally in good shape with no significant deposits.
- Cleared code and swapped injectors between cylinders 1 and 2, after test drive P0302 code came back, so it seems that the injectors are good. If the injector were bad I would have expected the misfire to change from cylinder 2 to cylinder 1.
Inspection and Testing:
- Ignition System Testing
- Spark plug wires and primary coil are within specification.
- Secondary coil resistance is high on both packs. Could this be causing a problem with just cylinder 2? Is it worth replacing?
Spark Plug Wires: Specification: 5.6 Kohm/meter +- 20%Cylinder 1: 2.49 Kohm (Longest)Cylinder 2: 2.03 KohmCylinder 3: 1.64 KohmCylinder 4:1.36 Kohm (Shortest)
Primary Coil: Specification : 0.58ohms +- 10%Actual: .6 and .6
Secondary Coil: Specification: 12.2 Kohms +- 15%
Actual (Cold): 16.03K for Cylinder 2-3 pack and 15.94K for Cylinder 1-4 pack
Actual (Hot): 18.54K for Cylinder 2-3 pack and 18.44K for Cylinder 1-4 pack
Air/Fuel System Testing:Fuel system seems to check out. I do not believe the problem is fuel related. There are no obvious cracks or leaks on the intake manifold. A good spray of Carb cleaner all around the manifold causes no change in idle. I might try propane later. No obvious vacuum leaks.
Fuel Injector: Specification: 13.1-14.5 ohms
Actual: Cyl 1: 14.9, Cyl 2: 15.3, Cyl 3: 15.3, Cyl 4: 15.7
Compression Testing:Compression is not great, but within specification. Could the slightly lower compression in Cylinders 2 and 3 indicate a head gasket leak between those cylinders? Could this cause a misfire in Cylinder 2?
Dry Compression: Specification: 145-218psi, <15psi between cylinders
Actual: Cyl 1: 165, Cyl 2: 155, Cyl 3: 155, Cyl 4: 160
Oil/Coolant/Tailpipe:
- Oil looks normal, not brown or milky
- Coolant looks normal and is full, no signs of leaking (coolant has not been changed in a very long time, could a coolant flush work?)
- Exhaust looks and smells normal from tailpipe.
Sticking valve? How would I check this? Bad sensor somewhere? Doesn't a bad sensor usually throw a code?
Elantra XD (2001-06) :: 2003 - Rough Start And Stalls On Full Tank
I just recently had a new (used) gas tank and new fuel lines (front to rear) put on the car.
On the first fill-up, I pulled out from the gas station, drove 20 seconds to the next red light. The car stalled (automatic transmission) when I came to a stop. It was hard to start and hard to keep going, and had intermittent periods of extreme power loss when I drove it down the highway.
Took it back to the shop, there was an engine code for the O2 Sensor, so the O2 was replaced, but made no difference. They checked fuel pressure and the catalytic converter, both were fine. They wanted me to keep driving it until another code came up.
As the tank neared empty, the car started driving almost perfectly. Filled it up again, and the problems started all over again. I have tried driving it with the gas cap off to make sure air can get in to replace the gas, but made no difference.
I changed the spark plugs, and all 4 of the old ones were covered in black carbon from the fuel running too rich (i assume).
Also, when the car is idling and it starts struggling, the exhaust does smell extremely strongly and is grey.
Now, engine code [P1166 O2S Controller Adaption Diagnosis Malfunction (bank 1)] is appearing (I have to check with the garage monday to see if it is the same code they had earlier).
I'm not sure why a new tank would cause this, unless somehow dirt/rust ended up where it didn't belong during the changeover.
Golf IV / Jetta IV :: 2001 VW 1.8T - Rough Idle And Often Stalls Out When Press The Gas
I have a 01 vw bora 1.8t and recently I let it sit for one day and now it has trouble starting when it's cold and when it does start it has a very rough idle and often stalls out of you try and press the gas. Once it has warmed up she runs fine. My check engine light is on but I have no way to take her down to a shop to get the codes read. What is wrong with my car? One of my friends told me it could be a cool pack or a sensor.
View 1 RepliesSanta FE SM (2001-06) :: 2003 - Rough Idle / Stalls At 2000 Rpm
I have a 2003 santa fe I just replaced the cat. in it because it was running so poorly. Now that I've replaced the cat it seems to be worse. The car idles real rough, and cant get it to go over 2000 rpms. No engine light. Had the codes checked and all came out fine. I pulled out the plugs and replaced with new. The car in park ran great until I put it in gear then went back to the same no power, rough idle and cant get more than 2000rpm with out a stall. Stalls but dose not die. Disconnected the pre o2 sensor no change.
View 2 RepliesSanta FE SM (2001-06) :: 2003 2.7L - Rough Idle / Stalls After Short Warm Up
We are at 120K miles. The vehicle runs fine most of the time, but every once in 10-15 starts, it will rough idle or stall after a short warm up time when my wife stops at an intersection. Once she restarts it, it runs fine.
I have changed the spark plugs and wires, the fuel pump, the crankshaft position sensor (was fried) and after consulting this forum, I checked the fuel pressure regulator and the diaphragm is not leaking.
I was able to recreate the rough idle and the CEL on the dash, but my two OBDII readers said there were no codes And the bluetooth reader I am using is indicating that the following tests are not completing: Fuel System, Catalyst, Evaporative System and Oxygen Senors.
The dash CEL resets itself upon restart and does not light until the symptoms return.
After reading the Haynes Repair Manual, I am wondering about the Evaporative Emissions Control (EVAP) system? But I don't want to lead the troubleshooting.
We bought the vehicle at 60K miles and it has been mostly reliable.
Elantra XD (2001-06) :: Rough Idle Stop For A While?
I have 2005 elantra ve and I got rough idle stop for a while.
View 12 RepliesElantra XD (2001-06) :: 2003 - Rough / Jerks At Idle
Below is a link to a video showing what my 2003 Hyundai Elantra is doing. It is idling very rough (Jerks at idle) and can actually be heard in the exhaust. I think it may be miss firing?? Does not do it at speeds over 60. Under 60 it can be felt at times, but only at low RPMs. [URL] ....
View 16 RepliesElantra XD (2001-06) :: 2004 GLS - Sudden Rough Idle Under 1k RPM
I have an '04 Elantra GLS with 274k on it. I've been caring for it myself with basic maintenance; that said, I changed the oil in it about 100 miles ago. Halfway through my drive home it started to idle rough under 1k rpm.
I've noticed a lot of other Hyundai's have the same issue. What would be/is the most COMMON cause of this? Timing belt? Basic tune up? I moved a state away from my local shop and I refuse to go to a Midas/Jiffy/ect.
Elantra XD (2001-06) :: 2002 - Rough Idle / Now Car Won't Start
I had a rough idle and now car wont start. 2002 elantra, 4 cylinder. replaced tps, replaced fuel filer, cleaned IAC. I can hear fuel pump car wont stay running...
View 22 RepliesElantra XD (2001-06) :: Rough Idle Under 1000 RPM - Sputtering Backfire
2003 Elantra gt 90,0000 miles manual transmission. Rough idle under 1000 rpm it smooths out completely above 1000 rpm.
Also the engine makes a ticking noise from a cold start up. It stops making the ticking noise after 1500rpm or when the engine warms up.
Occasionally the car has a sputtering backfire. This happens when I park the car after being on the highway.
Replaced the plugs, wires, and the pcv valve. Dropped the oil pan and it and the oil pump pick up screen were clean.
The only check engine light to come on was for the speed sensor. It has since gone out on it's own.
Elantra XD (2001-06) :: 2004 - Rough Idle When In D And Foot On Brake
I have an 04 elantra 2.0. Seems to idle rough when in D and foot on brake at the the lights etc. Put it into N roughness goes away.
View 15 RepliesElantra XD (2001-06) :: 2002 - Erratic Idle And Ran Rough At 1200 Rpm
I just picked up an 02 Hyundai elantra manual trans that needed a transmission. ran fine before I replaced transmission but after putting it all back together the car now how has an erratic idle. it will rev from 2-4000 rpms. I tried spraying for vacuum leaks idle didn't pick up any higher. replaced tps and iac and didn't make a difference. the only thing that did make any difference is unplugging map sensor. dropped idle to about 1200 rpm but ran rough. could this affect the idle.
View 1 RepliesElantra XD (2001-06) :: Cylinder 2 Misfire / Rough Idle Especially After Fill Ups
I have a 2001 Elantra with 170K miles. well taken care of. I've been having a rough idle issue for some time now. The car idles very rough. I checked for codes and I got the cylinder 2 misfire code (P0302)...
I started out and replaced the plugs and wires, no solution...
I replaced the coil packs, no solution...
I replaced the MAP sensor, no solution...
I figured it may be no to low compression, so I did a compression test and all cylinders came back normal, still no solution...
I figured it might be a dirty injector, so I poured some seafoam in the gas tank, and no solution...
So my next step is to switch out the injector. Is there anything I am overlooking?
Here's the big thing that is happening too... Everytime I fill up the gas tank, I turn the car on and it idles even rougher. Like if you talk while sitting in the car, you sound like Chevy Chase when he is on the vibrating bed with Beverly D'Angelo in the movie vacation! LOL. It slowly goes away after 10-15 minutes of driving. All this rough running engine ONLY happens at idle, otherwise it runs very smoothly.
Elantra XD (2001-06) :: Rough Idle - No Check Or Service Engine Light
I just purchased my first foreign car ever. it is a 2002 Elantra it idles very rough changed plugs using NGK and wires new fuel filter and ran 2 full tanks of high grade fuel with STP fuel injector cleaner. but had no effect on idle also have no check or service engine light. What to check next?
View 3 RepliesSilverado :: 99 With 4.8 - Rough Idle And Hesitation On Cold Start Up
I have a 99 silverado with the 4.8 w/186k on the clock. I am having an issue with rough idle and hesitation on cold start up. Once the truck warms up the idle and hesitation go away. I have replaced the PCV valve hoping this fixed it, but it did not. I have also cleaned the TB and the MAF.
View 2 RepliesPontiac - Grandam :: 2004 V6 - Rough Idle And Hesitation
I own a 2004 Pontiac Grand Am V6... recently it has developed a rough idle - kind of like the car is hiccuping - and it hesitates when I accelerate from a stop. Now, it doesn't have issues changing gears so I'm not inclined to believe its a transmission issue...thought it might be the fuel filter, but I changed it and that did nothing.. I'm not getting a check engine light, which is frustrating because if I try to pull the codes it won't throw me any... so it's a guessing game now. I've gotten mixed reviews - anything from a bad catalytic converter to a faulty O2 sensor or idle air controller or a bad head gasket.. but my exhaust is completely clean...others say maybe its bad spark plug wires or other electrical issue (which is a whole other ball game) or possibly bad fuel injectors causing a misfire?
View 14 RepliesGolf IV / Jetta IV :: Rough Idle - Hesitation In First Gear Taking Off
So this morning when I started my car to warm up everything was fine. I went inside to make some coffee and I heard my idle change slightly and didn't think to much about it but when I got in I could feel my car shaking a little bit then when I pulled off my road there was a little hesitation in first gear taking off and when I would shift I would get a little rev hang between gears. So I've realized when idling its slightly fluctuating between 6-7 hundred rpm. I have no loss of power and it has not hesitated since the first take off. I'm thinking its something to deal with air. I checked my airbox and realized the bolt closest to the battery wasn't threaded so I fixed that and tried looking for any leaks but haven't found anything.
View 4 RepliesSanta Fe (CM - 2007-12) :: Engine Running Rough Idle And Hesitation
I have an 07 with the 3.3L and on start up the engine runs really rough and while driving when warm it keeps losing power with a regular rhythm. It almost feels like and injector or ign coil is dropping out. I have no CEL and have recently changed the spark plugs and rear upper O2 sensor.
View 5 RepliesAzera TG (2006-11) :: Rough Idle, Engine Hesitation / Vibrations
I have a 2006 azera limited 63k miles on it and I'm getting a rough idle that sounds worse when the weather is cold. also when I press the gas there is hesitation from the car to accelerate. on top of that, I feel vibrations from the engine all through the driver and passenger seat. When I turn the car on it idles at 1300-1500 rpm and takes about 5-7 minutes to come down. when it does , it idles at 650 rpm. I'm not getting any check engine lights or codes. I've replaced spark plugs, air filter, had the air induction service done at the dealership, and had to have Hyundai put on a new throttle body last march when it gave out on me while at work. the dealership doesn't know what it is and said to use a fuel additive when I fill up the tank. I have and am waiting to see if that does anything. I put in a bottle of CRC 1 Tank fuel system cleaner 2 days ago. I've even changed my brand of gas from exxon to bp just in case. I think it may be a bad hose for the idle and a bad motor mount for the vibration. Could an O2 sensor be going bad?
View 1 Replies