Golf IV R32 :: Catalytic Converter - Heat Shield Rattle
The catalytic converter shield is tack welded on the front end but free on the rear end. There was originally some braided wire packing at the rear to keep the shield from rattling against the pipes. Mine was deteriorated and had been damaged, I think, when I sustained some oil pan damage last summer -- big jolt to the system when running over a muffler on the highway.
The fix is simple. Bought a foot of 3/16" braided stainless steel cable. I used about 8 inches and layed in the lower bead line on the catalytic converter shield (see picture below). You can see a bit of the cable thru the gap in the upper/lower shield on the left side. (1/4" cable would be a better fit, but this will work for a long time.) Cost: $1.84
The local VW parts man dug out an exploded drawing of the system but it showed NO parts or packing for this problem.
Corolla / Matrix 2009-13 :: Removing A Catalytic Converter?
Replacing a Cat with a test pipe for added HP?
View 14 RepliesSuzuki - Xl7 :: Exhaust Heat Shield On Catalytic Converter Fell Off
My wife drives a 2001 Suzuki XL7. While she was out, the exhaust heat shield fell off the catalytic converter. My question is does this affect the car's ability to function in any way? Is it still safe to drive? My wife is freaking out over it.
View 6 RepliesHonda - Accord :: Catalytic Converter Heat Shield Recently Fell Off
My wife drives a 2005 Honda accord and the catalytic converter heat shield recently fell off. I am wondering if it is safe to continue driving the car without the heat shield? I have read that the main function of the heat shield is to prevent fires when parking in long grass. Does it also protect the bottom of the car from starting on fire?
View 1 RepliesCivic - Honda :: Heat Shield On Catalytic Converter Rusted And Hanging On
The heat shield on the catalytic converter of my 2005 Honda Civic rusted and was hanging on by one nut, so I decided to rip the bottom part off. Is it necessary to get a replacement or can i go without it?
View 5 RepliesCorolla / Matrix 2009-13 :: Front Plastic Air Shield Under Head Lights Bracket Broken
Managed to break loose a corner of the plastic air shield under head lights bracket is broken. Does epoxy repair kits will work ok on this.
View 1 RepliesFord Exhaust :: 2001 F150 4.2L - Moving Heat Shield Right Front Cat Converter
I want to replace the auto trans coolant lines on my 2001 F150 4.2L. I discovered I can actually see the top coolant line flare nut from outside the right wheel well, with the wheel and wheel liner removed. The lower line is just a few inches below. See photo, it's a little off, so the line connector is not seen:
The heat shield is just a little bit in the way for my hands, I have to put one through the red circled area. A 1/2" hex head bolt holds the shield to the frame (circled in green). This was easy to remove from the wheel well. After that the heat shield could be moved slightly away from the points I need to access.
I would prefer to unfasten the shield & move it out of the way for my hands. I found another bolt holding the rear end of the shield down to the frame, wasn't able to remove this - the bolt fastens to a U-nut in the frame that broke off & has trapped the bolt. Are there any other bolts fastening the heat shield down?
I was able to remove the old flare nuts with a 5/8" flare nut wrench, but have not been able to start the new nuts into their fittings, just not quite enough visibility and access.
Golf IV R32 :: Rattling Sound Like A Heat Shield
I have a major rattling sound from under my car... it sounds exactly like a heat shield. I have been up under my car 5 times and I can not find a loose shield anywhere. the cat insulator mesh is still in perfect condition and it now seems the sounds is coming from somewhere in the back of the car, perhaps the muffler area.
This car does have the flapper mod done... could there be something inside the muffler itself? the car only has 40k on the ODO and I have not hit anything or do not have a dented muffler. As a fellow VW'er I do not want to be the only one running around town rattling...
Golf IV / Jetta IV :: 2001 - Exhaust Rattling / Catalytic Converter
My exhaust on my 01 was rattling. It was coming from the catalytic converter, I assumed it was the heat shield. Put it up on the lift and lo and behold it was something in the cat that was rattling. I was popping a code for the cat anyways so figured I'd just swap it out. Fast forward to tonight. I get the car back up on the lift and I wiggle the cat but no rattling? I go farther back to the first muffler/resonator now it's rattling. It's not a hanger or a heat shield or metal to metal on the outside, there is obviously something of substantial mass inside of it I can almost feel where it is by wiggling around. I chose to wait and cut the exhaust up a different night because I plan on taking that section out as well now, hoping to get out whatever is rattling. If not I'll just have some spare pipe on hand to replace it.
View 6 RepliesSonata NF (2006-10) :: Catalytic Converter Clicking / Ticking / Rattling?
I have noticed lately, when the car is hot, while pulling into my quiet garage, and even when the car is in park, engine running --- hearing some clicking / ticking coming from, or near the Catalytic Converter.... It sounds as if a small piece of metal is rattling inside with the flow of air... It stops clicking once the engine is turned off.
View 5 RepliesCorolla / Matrix 2009-13 :: Rattling On Start Up Like It Isn't Getting Oil
Quick search found this post asking about changing the ECU, so it sounds like I'm not the only person to have heard this.
I've had my '09 Corolla for almost exactly 1 year and I've put 22k miles on it. All oil changes with Toyota elements and conventional oil at 1k miles and Mobil 1 5W-20 at 5, 10, 15, and 20k.
It's rattling like it isn't getting oil at start-up... intermittently. Sometimes it starts up just fine and others it rattles like it doesn't have oil for the first second or two. What's going on here?
I'm about ready to take it in to the dealer for an assessment, but with it being intermittent and all, I'm not expecting to be well-received. I know if I was looking at this as a used car and I heard what I've been hearing, I'd run.
GTI 337/20th Anniversary :: Exhaust Rattling Against The Heat Shield
I have a 42 DD tb exhaust. And so far I've used a 3" exhaust clamp over the last hanger (after the muffler) which raised the exhaust all the way up against the heatshield, eliminating the rattle over the rear axle beam. But the exhaust was rattling against the heatshield.
So I bought 15 ft of exhaust wrap and wrapped the section that comes in contact with the heatshield. It worked a bit but it still rattles a little! I hate this rattling! How to get rid of the rattling? Should I just use more exhaust wrap?
Golf IV R32 :: Rattling From Under Car - Heat Shield Continually Loosens
Looking for a cure for a heat shield that continually loosens, and causes a annoying rattle? I have been up under the car and re-tightened the suspected shield a couple times, the screw that holds the clip is not damaged, and the clip itself is not damaged... and on top of it all, I can never quite get that clip on tight enough to stop the rattle all together. is there a tool to get it tighter? i use micro needle nose pliers that fit and tighten it that way.
View 24 RepliesToyota - Prius :: 2004 - Catalytic Converter Rattling Under Heavy Acceleration
Toyota says the code is P0420 and the Catalytic Converter is rattling under heavy acceleration showing the Catalytic converter is bad and should be replaced. Toyota wants 2,334.00 which seems very high to me. Is it the Catalytic converter? The car is a 2004 Toyota Prius.
View 12 RepliesCorolla / Matrix 2009-13 :: PCV Valve Rattling After Replacement
I replaced the PCV valve (with OEM). The old one looked dirty, but still rattled when I shake it. However, now with the engine at idle, I can hear a metallic clicking coming from the area of the new PCV valve. It's difficult to verify, because it's behind the intake manifold, but since I just replaced the PCV valve, what else could it be? The clicking also seems to sync up with the engine cycling..
My corolla has been burning 2 quarts of oil every 5000 miles since 80k miles. It's at 100k now. I guess worst case is there's a broken valve seal and I'm getting high pressure in the crank case. I also heard it could be a vacuum leak. I'm going to try and check the vacuum pressure, but is there anything else that I should be looking for?
I rigged a gauge from a brake bleeder pump into a tee in the vacuum booster line and it ran pretty steady at 20Hg. Accelerated a little and it hit 25Hg and came back down. It flutters a little at around 1 Hg, but I'm wondering if my vacuum rig is a bit leaky itself.
Here's a recording of the clicking: [URL] ....
Toyota - Corolla :: New Catalytic Converter Burns More Gas
I recently had the catalytic converter replaced on my 1999 Toyota Corolla and the gas mileage dropped from about 28 mpg to 21 mpg.
View 18 RepliesCorolla / Matrix 2009-13 :: Rattling Noise At High Speed (Above 50 MPH)
I have a 09 Corolla with low mileage (33,000 miles). It drove without a problem until recently.
About 1 month ago I started noticing some rattling noise at high speed (>50 mph) coming from the engine compartment on the passenger side. the noise seems to get more frequent the faster i go and disappears when the speed drops below 40 mph. It is not loud but still noticeable. The car itself does not shake.
I drove through a snow storm before the noise happened. not sure if this has any thing to do with it.
Golf/GTI VI :: 2011 - Heat Shield Rattling Sound Coming From The Underside
So, I have discovered my first rattle in my GTI (8500 miles). Seems to be from the underside, sounds like a heat shield rattling, certainly sounds metallic. Did some spirited driving yesterday and hear the rattle today. Any target areas to check when I take a look under it?
View 6 RepliesCorolla / Matrix 2009-13 :: XLE - Rattling Sound From Engine Compartment When Start The Car
I have just purchased my first Toyota. Formally a Subaru man. It is a 2009 corolla XLE with 95,000 miles. It is a one owner car in excellent condition and I have all the service records from the Toyota dealer where the work was done.
When I start the car most of the time there is a rattling sound that comes from the engine compartment and lasts just a couple of seconds. In my manual there is something in the ABS section about noises from the ABS system. Could the ABS system be the cause of this noise?