Caravan/Voyager :: Whistling Noise At Start Up When Engine Cold
We have a 2012 Dodge Grand Caravan and has a whistling noise when starting up? We are in Wisconsin and its damn cold. It only does it when its cold out. Once the engine warms up it goes away. But my wife is freaking out about it. I am thinking it might be something with the air intake but not sure.
View 3 RepliesCaravan/Voyager :: 1999 - Whirring Sound / Low Voltage When Idling
I have a 99 voyager that has started making a whirring sound this last week. The water pump, serpentine belt, tensioner have all been replace several months ago. The battery light came on for about a minute and then went off the last night. I checked the voltage with the engine running and it measured 12.5, the same as when it is off. When I revved it up the voltage went up to 14.4 volts. Is this normal? What could be making the whirring sound?
View 2 RepliesCaravan/Voyager :: GC Started Cutting Out While Idling In Gear
MY gc started cutting out a few weeks ago while idling in gear. I changed out the four plugs I could get the wires off. It's a v6. It started running better for a couple of days. I need to know of any way to get the stuck boot off. I also have a feeling there is something else wrong. Anything else that might be causing it to cut out. It has progressed to cutting out while going down the highway.
View 4 RepliesCaravan/Voyager :: 1999 Cannot Get Started - No Pressure On Fuel Rail
A friend has a 1999 Caravan with the 3.0L engine. He couldn't get it to start and to make a long story short, I checked the fuel pump relay and fuse and they were good but there was no pressure on the fuel rail. Turning the key I couldn't here the fuel pump come on and determined the fuel pump was bad.
I changed the fuel pump and fuel filter put in 1/4 tank of gas and turned the key, and it turned over but wouldn't start. I can audibly hear the fuel pump come on for a second or so, and feel the vibration when I put my hand on it, but there is still no pressure at the fuel rail.
Caravan/Voyager :: 1996 Van Started Chugging - Random Misfire / Bad Cylinder
Last week, my van started chugging and the keydance code indicated random misfire. I changed the front spark plugs and wires and it ran a little better but still showed the error. Took it to my trusted mechanic and he changed the back 3 wires and plugs and the coil pack. Code now showed misfire on one of the back cylinders(I forgot which one). 2 Mechanics both confirmed good spark and gas at the cylinder. He is saying that there is a mechanical problem in the cylinder and the fix would be over $1k.
The van has over 250k on it so it's not worth the engine work. I asked about a compression test and was told that it's almost impossible to test the rear cylinders without doing a ton of work, and that they are 95% sure that it is a mechanical problem with the cylinder. I've known the mechanic for over 20 years and he is an honest guy, and knows that I won't do the expensive repair, so he's not trying to rip me off.
I don't have the facilities or knowledge to do the work, so it looks like I'm screwed. Is there anything else that I should be doing before I write the van off? It does run, but very rough at low speed, and no power at high speed, and mech says that the unburned gas will eventually screw things up.
Caravan/Voyager :: Check Engine Light Came On And Started Blinking - Random Misfire
I have a 96 Grand Voyager that had had sat for a year undriven or started due to being out of state. It ran like a champ when I parked it. Now I charged the battery and went for a drive on the freeway and my check engine light came on and started blinking. I had the code read it came back with 2 codes a P0306 and a P0300. I noticed that the cylinder 6 spark plug wire was arcing on the core support. So I replaced all the plug wires and spark plugs with Champion platinum spark plugs. I cleared the codes and took it on a test drive and the P0300 code came back. Is there anyway the old gas is causing the random misfire? or what else could it be?
View 1 RepliesCaravan/Voyager :: 05 - Transmission Slipping When Engine Is Cold
My transmission is slipping when the engine is cold. Fluid levels seem fine. I do have a fluid leak that I monitor and add fluid when needed. It's an 05 touring with 167k miles.
View 1 RepliesCaravan/Voyager :: 1996 - Heat Just Blowing Cold Air Out
1996 Plymouth Voyager ... My Van has about 90,000 miles and runs good. The heat worked great last year but is just blowing cold air out this year. I do not know where to start looking for the problem. I do not have a over-heating problem and it blows air out just as strong as before this problem. I had to replace the battery last month, could that have anything to do with this problem?
View 3 RepliesCaravan/Voyager :: 2005 Dodge Blowing Smoke When Cold Even In Warm Weather
Alright, dodge grand caravan 3.8. Year: 05' ... Just broke 100k miles on this thing, last time i changed the plugs i noticed plug 2 had oil all down in it. I completely forgot about the problem cause i got side tracked with bad sway bar bushings. Anyways, what is the cause of the oil leakage? It has gotten so bad that I am blowing smoke when its cold, even is warm weather. There is also caked on oil and dirt on a lot of the parts down the front left side of the motor. Blown head gasket? Bad valve cover gasket? I want the best way to approach this . The smoke is white, but not enough smoke to be a completely blown head gasket.
View 3 RepliesCaravan/Voyager :: 2008 GC - When Engine And Tranny Is Cold Transmission Shifts Very Hard Until It Warms Up
I have a 2008 GC 6 speed transmission that has 55000 miles on it. When the engine and tranny is cold the transmission shifts very hard until it warms up. There are times when shifting from reverse to drive it shifts very hard. Also, the siding doors creak when driving over rough roads. Can they be adjusted?
View 2 RepliesCaravan/Voyager :: 2005 - Thumping Noise At Very Low Speed
Dealer replaced rack,twice. Still thumping,they installed new struts and 4 sway bar links and bushings same thump still there. I unhooked swap bar links and tied them to brake line and backed it out is my shop and thump is still there and sounds like both sides. This van has 56,000 miles on it and the ball joints and control arms feel and look tight. Is there anything about how frame mounts that might cause this?
View 2 RepliesCaravan/Voyager :: 1997 - Thumping Noise From The Engine Compartment
I have a 1997 Voyager that I am having a thumping noise that is coming from a black module that is mounted in the engine compartment over the passenger side fenderwell. It has 2 vacuum lines and an electrical connection coming off of it, one of the vacuum lines has a tag on it that says EVAP. The engine seems to be running fine, although every now and then it seems like it might idle a bit rough, and there are no CEL on or codes in the computer. Don't know what is this module called.
View 3 RepliesCaravan/Voyager :: Intermittent Rumble At Idle - Noise From Alternator
2007 Grand Caravan 3.8L 100K mi. New noise chirp-chirp-chirp Sometimes an intermittent rumble at idle seems to be in synch with the serpentine belt especially when the A/C is engaged. I changed the serpentine belt which did not look bad and did not emit the noise. Noise seems strongest at the alternator when I use a stethescope. I noticed the pulley seems a little loose with the belt removed, but the bolt is tight. This alternator has an overrunning alternator decoupler (OAD) pulley so maybe the loosness is normal. The bearings seem smooth when I spin it with the belt off, and it charges fine. Just the noise is bothersome. Do I need to change out the alternator or just the OAD pulley?
View 2 RepliesCaravan/Voyager :: Changed Cabin Filter - Humming Noise When AC Or Fan Turned On
I changed my cabin filter on my 2013 Dodge Grand Caravan and now there is a humming noise when AC or Fan is turned on. The noise increases and decreases with fan speed. I tried putting the old cabin filter back in to see if the new one was loose or defective, but the humming noise was still there. I also made sure airflow arrow was pointing downward. Could it be that a leaf or something fell off of the filter and is now in the blower. How do I check the blower?
View 2 RepliesCaravan/Voyager :: Click Noise Coming From Relays Behind Alternator Near Dash
I have a 91 grand voyager an every time I hook up battery there is a click noise coming from the relays behind the alternator near dash. I'm also having battery drain issues also an had alternator an battery tested, ok. Is this click from relay draining battery and what relay could it be? I switched them an had same click .
View 3 RepliesCaravan/Voyager :: Door Ajar Light Stays On / Warning Noise Keep Going Off
My door ajar warning light stays on and at the same time the warning bell/noise keeps going off. Is there something that I can disconnect to make the noise stop?
View 4 RepliesCaravan/Voyager :: 1996 - Clicking Noise Inside Dashboard While Driving
Issue on grand caravan 1996 happen, while driving all one time I hearing a clicking noise inside dashboard and abs+airbag and weather control, they stopped to work all in one shot .
View 1 RepliesCaravan/Voyager :: 2000 Dodge 3.3 Engine Noise At Idle And Under Low RPM Load
I have an engine noise on my 2000 Dodge Caravan with the 3.3 engine. It sounds a lot like the grinding of a rotating part. It occurs at start up, momentarily, then goes away. If I drop it in gear and start doing low speed maneuvering in the driveway, it comes back. If I turn on the AC it comes back. In all cases, the noise goes away at around 1200 rpm.
The noise occurs again, when I shut the engine down.The engine performs and runs smooth and normal otherwise. No stalling, stumbling, or bad gas mileage to report.
I can "feel" the noise with my hand, when I put my hand on the ac compressor bracket, or the intake manifold, or the valve cover. I've tried the listening through the stick method, and it seems to be coming from the front area of the engine. But I can't be sure. It is something internal. Let me describe:
I thought it was my AC compressor or clutch going bad. The fact that my AC had stopped working well, and was making jet engine noises at high rpm supported me decide this. I replaced the compressor. The AC works great now, and the jet engine noises went away. But the grinding noise is still there. As described.
I wishfully thought it was the belt tensioner or idler pulley. I replaced both of those. Noise still was there. I pulled off the serpentine belt, and started the engine. It made the noise, very briefly as it started, then went away completely. It made the noise again briefly as I shut the motor off. So it's still there without any of the accessories turning.
The noise is loud and obnoxious at idle when under load. It just can't be good. I've read theories about similar sounding problems, saying they could be loose timing chain, bad oil pump, slapping pistons, crank journals, flexplate/flywheels cracked.
I'm going to try doing an oil system flush, and then I'll change it out with a little thicker oil. See if that makes any difference in the noise. Currently I'm running 5w-30 Mobile 1. I think. I'll let you know if it changes anything. I'm also thinking I want to make a short video of the car idling and making the noise for my video camera. I'll post that on youtube and link it here.
Caravan/Voyager :: 1999 - Noise From Front Struts When Passing Over Bumps
I am experiencing an annoying noise from the front struts when passing over bumps. I do not believe that the front end is bottoming, but it seems to give a deep thud sound. It is not a tin sound, but more like something loose and insulated. What is a jounce bushing? Are these something in the strut assembly and susceptible to getting loose? I have read about the springs could be the culprit, but could it be that the front spring is bottoming and the strut is hitting a bottoming rubber ? Jounce bushing?
View 2 Replies