Caravan/Voyager :: Intermittent Rumble At Idle - Noise From Alternator
2007 Grand Caravan 3.8L 100K mi. New noise chirp-chirp-chirp Sometimes an intermittent rumble at idle seems to be in synch with the serpentine belt especially when the A/C is engaged. I changed the serpentine belt which did not look bad and did not emit the noise. Noise seems strongest at the alternator when I use a stethescope. I noticed the pulley seems a little loose with the belt removed, but the bolt is tight. This alternator has an overrunning alternator decoupler (OAD) pulley so maybe the loosness is normal. The bearings seem smooth when I spin it with the belt off, and it charges fine. Just the noise is bothersome. Do I need to change out the alternator or just the OAD pulley?
View 2 RepliesFord F-150 - 1997-2003 :: 2002 V8 - Click In Dash When Turn The Key - Bad Relays?
I have a 2002 F-150 xlt 4x4 5.4l V8, 96k miles. been sitting about 3 weeks i went to start it and nothing.. thought ok jump. We tried jumping/charging the battery nothing. then we switched batteries from running car same thing when i turn key just hear a click in dash. battery light remained on even when we swapped out. The theft light was off as well.
View 1 RepliesCaravan/Voyager :: 2005 - Can Hear Solenoid Click But No Starter Engagement
A couple of years after buying this I had problems with door locks and power windows. (No locking or unlocking or up/down) after looking this up as recommended I removed and replaced all the relays in the power distribution panel. (No fix) I next removed the battery so I could turn this power distribution panel over, then unplugged all the plugs and reseated them. (Wiring plugs) this got everything working. About 1 year later the same issue, with the same fix. About one more year later I encountered a starting issue... you could hear the solenoid click, but no starter engagement.
I checked the starter and it was good. So on a hunch I flipped the fuse panel over, reseated the wire plugs and it started right up, but it was intermittent for a few weeks. After several unplug and reseat the wires it was good again. Six months later it would spin the starter fine, but wouldn't start up. I first checked for fuel and it was good. Next I checked for spark and there wasn't any. Just a hunch... I went after the power distribution again and ended up taking it completely apart, also computer on the end of it, cleaned up all the connections and it fired right up.
Ford Excursion :: No Start - Relays Click Under The Dash And Airbag Light Flashes When Turn The Key
Ok, I have a strange no start issue right now. My excursion won't start. I have power to everything and both batteries are at 12 volts or a bit more but the starter won't engage. If you turn the key to start all that happens is relays click under the dash and the airbag light flashes. It almost seems like the transmission is in gear. It did this twice about a month ago and has been fine ever since until today.
View 8 RepliesCaravan/Voyager :: 1997 Plymouth - No Dash Gauges But Dash Lights Working Fine
1997 Plymouth Grand Voyager SE 180K 3.3L
I read other threads about the connections under the hood, both sides, which I unplugged and replugged. I also pulled the IOD fuse for a little bit. Then I removed the cluster and looked it over. Looked good to me.
Got code P1698 for manufacturers assembly control or something to that effect. Thought I checked all the usual culprits. The dash lights work fine, so does everything else. The dash gauges just don't work. This is something that has been an intermittent problem with the dash gauges going out periodically when hitting a bump. It leads me to believe a connection. But I checked all those.
Caravan/Voyager :: 2010 - Humming Noise Coming From Front Left Near Tire Assembly
This a 3.3L engine although the noise has nothing to do with the engine but front left near tire assembly, what can it be?
View 6 RepliesCaravan/Voyager :: 97 2.4 - Shut Down While Driving / No Dash Codes
97 2.4 caravan dies while driving. Its been going on for awhile, coded at o'riellys and autozone several times. It started with having the camshaft and crankshaft replaced. Problem solved for a few days but it always returned.It would restart a few minutes later then it got worse. I called it the 30 mile van 'cause that's all it would go before dying or not restarting immediately.
Go to the grocery store, have to wait another 30 minutes to go home. Then it started only going a few blocks before shutting down while driving. I replaced the o2 sensor, the shutoff and fuel pump relays and finally took it to a shop that engine coded it. On their advice, they said the codes were all over, jumping everywhere, we replaced the ECM. It went 5 hours driving great then died and immediately restarted. Again no dash codes.
Caravan/Voyager :: 99 Won't Start - Clicking Under Dash - New Battery
I have a 99 Voyager with 88,000 miles. Brand new battery 12/12/06- won't start 3 weeks later - cleaned & protected battery connectors - still no start if left for more then 4 hours undriven Battery tested fine- being drained approx 2 amps- something left on...? Now there is a clicking sound under the dash before trying to start. Could it be some type of relay being left open or fuse or
View 6 RepliesCaravan/Voyager :: 2008 Brake Warning Light On Dash Is On
I'm working on a 2008 Grand Caravan SE 3.3L Brake warning light (!) on dash is on. Datastream on my OTC Genisys shows that the Brake fluid level switch is 'ON'.
The van does not have pad wear indicators; fluid is full; there are no leaks in the system; no brake pull, uneven braking or other performance issues.
Scantool says Park Brake is off and I disconnected it to be sure.
When checking connector at switch on the master, one wire has continuity to ground and the other has about 12.5V on the DMM but won't light my test light.
Caravan/Voyager :: ABS Light Keep Coming On
On my 2005 3.3L Grand Caravan the ABS light keeping coming on. I inspected the sensors for the front and used my compressor to give them a quick puff of air to get rid of dust. The light went off for about 5 days. Now it is back on.
How does one read ABS codes? If I knew for sure that the problem is a speed sensor and which one I could clean or replace the faulty sensor.
If I clean to sensor are there any special precautions I need to take? As far as I could see they didn't look very dirty.
Caravan/Voyager :: 07 SXT - ABS Light Is Coming On Intermittently
Intermittently the ABS Light is coming on. 84,000 miles.
Brakes have been changed once, 10,000 miles ago.
Minor clunk sound when light is on.
Light goes off after van has set, brakes work fine at that point.
Dodge - Caravan :: 2004 Won't Start - No Crank / Grind / Click And Dash Lights
My friend (yes, really, a friend, not me) parked her 2004 Dodge Caravan in the driveway the evening before. The next morning it would not start. No crank, no grind, no click, and no dash lights, nada, nothing. She took it to the shop she's taken the car to for years for repair and maintenance. She trusts them. They've replaced the battery and run a full diagnostic on it, but are unable to solve the problem. The shop is telling them her it could run into the thousands just to figure out the problem. What could they be missing?
View 4 RepliesCaravan/Voyager :: 1996 - Front End Shakes Like The Wheels Are Coming Off
My daughter has a 1996 Grand Voyager that she would like to sell. However, right now when you drive it the front end shakes horribly like the wheels are coming off. I mean the whole dash is shaking. Scary! In addition, I swear I've seen the front wheels appear to wobble when she's driving it. Ive changed the wheel bearing on the passenger side and was astonished to find that it made no difference. I was wondering about the half shafts and CV joints and such. How can I tell if these are bad? I've grabbed them and tried to move them and they don't move.
View 2 RepliesCaravan/Voyager :: 1998 - Whistling / Humming Sound Coming From Rear Of Van
It is as an electronic whistle/humming. The sound is coming from the rear of the van, and no, not when it's moving, even though it still does it when moving. The only thing I can think of would be the fuel pump. Because It's loudest just before the rear tires, not after them. My fiancee has heard it twice now, when she first heard it, I didn't, but this last time when I heard it, I also noticed that the gas gauge was reading just below 1/8 of a tank.
Would like to know if it's the fuel pump or something else I'm no thinking of. And if it means I have to replace the pump.
Caravan/Voyager :: 1997 - Airbag Light Coming On Then Off / Clock Spring?
I have a 97 voyager. recently the airbag light has been coming on then off. now it is on all the time. In addition to the air bag light being on the horn and the steering wheel cruse control does not work. The fuses and relays are all good. I was wondering if the clock spring is the problem?
View 2 RepliesCaravan/Voyager :: Whirring Noise When Car Started (Cold)
2007 town & country with 93k when car is started (cold) after setting to completely cold have a whirring noise that goes away after car is completely warmed up thought was alternator but noise doesn't seem to be coming from there .... 3.3l engine ....
View 1 RepliesCaravan/Voyager :: 2005 - Thumping Noise At Very Low Speed
Dealer replaced rack,twice. Still thumping,they installed new struts and 4 sway bar links and bushings same thump still there. I unhooked swap bar links and tied them to brake line and backed it out is my shop and thump is still there and sounds like both sides. This van has 56,000 miles on it and the ball joints and control arms feel and look tight. Is there anything about how frame mounts that might cause this?
View 2 RepliesCaravan/Voyager :: Whistling Noise At Start Up When Engine Cold
We have a 2012 Dodge Grand Caravan and has a whistling noise when starting up? We are in Wisconsin and its damn cold. It only does it when its cold out. Once the engine warms up it goes away. But my wife is freaking out about it. I am thinking it might be something with the air intake but not sure.
View 3 RepliesCaravan/Voyager :: 1997 - Thumping Noise From The Engine Compartment
I have a 1997 Voyager that I am having a thumping noise that is coming from a black module that is mounted in the engine compartment over the passenger side fenderwell. It has 2 vacuum lines and an electrical connection coming off of it, one of the vacuum lines has a tag on it that says EVAP. The engine seems to be running fine, although every now and then it seems like it might idle a bit rough, and there are no CEL on or codes in the computer. Don't know what is this module called.
View 3 Replies