Caravan/Voyager :: Door Ajar Light Stays On / Warning Noise Keep Going Off
My door ajar warning light stays on and at the same time the warning bell/noise keeps going off. Is there something that I can disconnect to make the noise stop?
View 4 RepliesCaravan/Voyager :: 1998 - AC Stopped Working
I have a 1998 Plymouth Grand Voyager SE. It has 122000 mi. I just bought it a few months ago and have came across a few minor problems and all have been easy DIY projects (couple of blown fuses, wiper replacement etc..) Recently, I noticed the AC stopped working (it was only tested once when I bought it, but have not used it since)
Where to begin the diagnosis. Is there a fuse connected to the functioning of the AC? I really don't know a whole lot about cars, but I am pretty good at fixing things in general.
Caravan/Voyager :: 1998 Dodge - Putting A New Tailgate On Car
I'm about to put a new tailgate on a 98 Dodge Caravan. I got hit in the back and I bought a new back door at the junk yard. It looks pretty easy, but I thought I would touch base here and there are a couple of potentially tricky parts...
Does that wire bundle have a block somewhere that you can plug, or am I going to be splicing them one by one? (I don't have power locks. I have windshield wiper, back door inside light, license plate light, heat wires in the glass.) The other tricky part..changing the lock.
I think that's all.. the bolts and star screws look pretty straightforward. I got it used with 48k miles a couple years ago and I only have 75k now. It was a government car.
Caravan/Voyager :: 1998 SE - Radiator Fan Running Constantly
My father's 1998 Dodge Grand Caravan SE radiator fan runs constantly - even with the ignition off. He has to disengage the battery for the fan to quit running - what might be wrong?
View 14 RepliesCaravan/Voyager :: 1998 - Engine Cooling Fans Won't Go On
I have a 1998 Caravan and the engine cooling fans wont go on. Ive replaced the relay and the temp sensor. When I pull the connector off the temp sensor the fans go on so I know the fans and fuses are fine. For some reason it seems the computer module isnt sending a signal to the relay to turn the fan on. I get the trouble codes P1491(radiator fan relay circuit fault) and P0118(engine coolant temp circuit high input).
I am also having a problem with the air conditioning not working. When I do the self diagnostic test on the A/C the results are that it fails the cool-down test. Why the computer module isn't sending a signal to the relay? Could the A/C problem be causing the cooling fans not to come on?
Caravan/Voyager :: 1998 - Battery Light Comes On - Not Charging
The battery light came on, alt not charging. I have taken it off twice and had it checked, both times I had it checked it showed good, when I put it back on it charged for a bit and then the light came back on and it showed no charging at the battery. Second time the place checked it they ran the check cycle 4 times in a row to see if it had a problem when the electronics started warming up... still showed all green.
I thought perhaps the wires going to the alt, so I had the wife start the van up and I moved the wires around going to the alt to see if it made the batt light flicker, no joy. (real fun getting your hand back there while the van is running)
The large wire shows batt voltage where it hooks on to the alt, running or not...... the two prong plug that goes into the alt shows no voltage unhooked with the key on, and no voltage plugged in with the key on or running.
I have been told there is a control unit that controls the output of the alternator. I have checked every fuse in the fusebox under the dash and in the engine compartment. Fuseable link on big wire going to the alt should be good as I do get battery voltage to the alt from the battery, correct?
Caravan/Voyager :: 1998 - Tachometer And Speedometer Drop To 0 While Driving
My wife has been driving our 98 Dodge Grand Caravan the last couple of days and while she is driving the Tachometer and Speedometer will drop to 0. This does not affect the performance of the engine or anything else. Runs and drives "perfect" (or at least for its age and mileage). The dash seems to "reset" when she parks and turns off the ignition then restarts it.
View 2 RepliesCaravan/Voyager :: 1998 - Heater Fan In Van Only Work On Full Blast
The heater fan in the van will only work on full blast and the rear wiper/ ac button lights flash which I had another 98 caravan that I was driving that had the same issue with the flashing lights. What is that all about?
View 2 RepliesCaravan/Voyager :: 1998 - Flashing HVAC Lights After New Battery
Just changed the battery on a '98 Grand Caravan 3.3. In the process of tightening the positive terminal I accidentally touched the wrench to the negative. There was a spark, of course, but otherwise no biggie. However, now the HVAC indicator lights, including the rear wiper, defroster, etc. indicator lights, all blink continuously until about 15 minutes of driving, then they return to normal. I disconnected the battery thinking that I needed to clear the PCM but the blinking always returns. Is this some sort of manual code reading deal? If so there's no mention of it in the Haynes manual.
View 14 RepliesCaravan/Voyager :: 1998 - Whistling / Humming Sound Coming From Rear Of Van
It is as an electronic whistle/humming. The sound is coming from the rear of the van, and no, not when it's moving, even though it still does it when moving. The only thing I can think of would be the fuel pump. Because It's loudest just before the rear tires, not after them. My fiancee has heard it twice now, when she first heard it, I didn't, but this last time when I heard it, I also noticed that the gas gauge was reading just below 1/8 of a tank.
Would like to know if it's the fuel pump or something else I'm no thinking of. And if it means I have to replace the pump.
Caravan/Voyager :: 1998 - Passenger Side Window Keeps Falling Off Track
My 1998 T&C has a problem where the front passenger window keeps falling off the track (caused by hard slamming of the door).
I've gone into the door multiple times to pop the rear-most peg back into the white plastic window track "dog", but it keeps popping out after moderate door slams. Do the black pegs that are glued to the window wear out? (I think they're metal).
I think the plastic track dog is fine, and I make sure the metal clip is fully engaged with the window peg each time I pop it back in. The only reason I can come up with for this problem is that the window peg is worn down and has lost its "edge" and thus the metal clips can no longer retain it. Sound reasonable? Probably need a new window from junkyard correct?
Caravan/Voyager :: 1998 Dodge V6 - Driver Side Brake Light Not Working
98 dodge caravan 3.3L v6 ..... All lights work including driver's side tail lights. only problem is that when pressing brake pedal, the driver's side brake light does not light up. i changed the bulb and checked the brake light fuse under the hood, but it was fine (as i guessed since the passenger side and middle brake lights work). I took the assembly off and reseated the connector to the tail light assembly, but same issue.
View 2 RepliesCaravan/Voyager :: Intermittent Rumble At Idle - Noise From Alternator
2007 Grand Caravan 3.8L 100K mi. New noise chirp-chirp-chirp Sometimes an intermittent rumble at idle seems to be in synch with the serpentine belt especially when the A/C is engaged. I changed the serpentine belt which did not look bad and did not emit the noise. Noise seems strongest at the alternator when I use a stethescope. I noticed the pulley seems a little loose with the belt removed, but the bolt is tight. This alternator has an overrunning alternator decoupler (OAD) pulley so maybe the loosness is normal. The bearings seem smooth when I spin it with the belt off, and it charges fine. Just the noise is bothersome. Do I need to change out the alternator or just the OAD pulley?
View 2 RepliesCaravan/Voyager :: Idle (RPMs) Were Very High - Check Engine Light On
My check engine light came on today and while driving, the idle (RPM's) were very high. At about 80KMs, it was about 3500 and when I accelerated, the engine would race along with the RPMs. While stopped, idling seems fine. I couldn't get over 80KMs/Hr without the idle going too high.
What it could be? Haven't had time to check codes as it is long weekend and garages are now closed till tuesday.
Caravan/Voyager :: 2000 Dodge 3.3 Engine Noise At Idle And Under Low RPM Load
I have an engine noise on my 2000 Dodge Caravan with the 3.3 engine. It sounds a lot like the grinding of a rotating part. It occurs at start up, momentarily, then goes away. If I drop it in gear and start doing low speed maneuvering in the driveway, it comes back. If I turn on the AC it comes back. In all cases, the noise goes away at around 1200 rpm.
The noise occurs again, when I shut the engine down.The engine performs and runs smooth and normal otherwise. No stalling, stumbling, or bad gas mileage to report.
I can "feel" the noise with my hand, when I put my hand on the ac compressor bracket, or the intake manifold, or the valve cover. I've tried the listening through the stick method, and it seems to be coming from the front area of the engine. But I can't be sure. It is something internal. Let me describe:
I thought it was my AC compressor or clutch going bad. The fact that my AC had stopped working well, and was making jet engine noises at high rpm supported me decide this. I replaced the compressor. The AC works great now, and the jet engine noises went away. But the grinding noise is still there. As described.
I wishfully thought it was the belt tensioner or idler pulley. I replaced both of those. Noise still was there. I pulled off the serpentine belt, and started the engine. It made the noise, very briefly as it started, then went away completely. It made the noise again briefly as I shut the motor off. So it's still there without any of the accessories turning.
The noise is loud and obnoxious at idle when under load. It just can't be good. I've read theories about similar sounding problems, saying they could be loose timing chain, bad oil pump, slapping pistons, crank journals, flexplate/flywheels cracked.
I'm going to try doing an oil system flush, and then I'll change it out with a little thicker oil. See if that makes any difference in the noise. Currently I'm running 5w-30 Mobile 1. I think. I'll let you know if it changes anything. I'm also thinking I want to make a short video of the car idling and making the noise for my video camera. I'll post that on youtube and link it here.
Caravan/Voyager :: 2012 - Programming New Key
We just purchased a 2012 Grand Caravan and was wondering where to get a key and program it. I know the key will be an arm and a leg if i get it from the dealer. Is there a tutorial that tells how to program it as well?
View 3 RepliesCaravan/Voyager :: Heat Comes And Goes Every Minute Or So
2006 Caravan. Heat comes and goes every minute or so. Also noticed the temp gauge goes from normal operating range to cold and back again frequently. Hasn't overheated. Does that sound like a thermostat problem?
View 2 RepliesCaravan/Voyager :: ABS Light Keep Coming On
On my 2005 3.3L Grand Caravan the ABS light keeping coming on. I inspected the sensors for the front and used my compressor to give them a quick puff of air to get rid of dust. The light went off for about 5 days. Now it is back on.
How does one read ABS codes? If I knew for sure that the problem is a speed sensor and which one I could clean or replace the faulty sensor.
If I clean to sensor are there any special precautions I need to take? As far as I could see they didn't look very dirty.
Caravan/Voyager :: 05 - Clunk In Front End When Hit Bumps
What am i missing i have a terrible clunk in the front end when i hit bumps. I thought it was the struts and mounting plates so they are new . no change Stabilizer links were tight but i replaced them as well. Everything else seems tight but the noise has not changed with any of the above mentioned repairs.
View 13 Replies