Caravan/Voyager :: 1999 - Noise From Front Struts When Passing Over Bumps
I am experiencing an annoying noise from the front struts when passing over bumps. I do not believe that the front end is bottoming, but it seems to give a deep thud sound. It is not a tin sound, but more like something loose and insulated. What is a jounce bushing? Are these something in the strut assembly and susceptible to getting loose? I have read about the springs could be the culprit, but could it be that the front spring is bottoming and the strut is hitting a bottoming rubber ? Jounce bushing?
View 2 RepliesCaravan/Voyager :: 2003 - AWD Clunk From Rear When Turning
When we turn the wheel of the van sharply in either direction, it produces a distinct clunk from the rear. This isn't the AWD engagement symptom I've read about - it seems to be strictly connected to a sudden change of direction, and the noise is definitely coming from the rear. I can also get the noise to happen when going over a large bump, such as a speed bump, but a moderately sharp (so nothing you wouldn't do in normal driving) flick of the wheel produces the noise very easily and consistently.
I doubt it's the axles, because the way we drive this van, the AWD is actually seldom engaged, so the axles have seen very little wear. Could it be the rubber bushings that support the leaf springs? It's such a simple rear suspension design that there isn't a whole lot to go wrong/replace, but I don't want to start throwing parts at it without at least a stab at a diagnosis.
The van has 123,000 miles, and has been doing this for a long time, and it doesn't seem to be getting any worse, but I'd like to get to the bottom of it. Otherwise, the van has been amazingly trouble-free.
Caravan/Voyager :: 2008 - Front End Clunking While Driving
I had to replace my swaybar links on my T&C due to it not passing state safety inspection. There was also some random noise that occasionally occurred on bumps. The tech said the "book" said to replace the strut and strut mounts but he could not see anything wrong. After replacing the swaybar links, there is now clunking while driving. I thought it was a lack of grease in the links but I greased them and while it got a little better...it still happens.
View 5 RepliesCaravan/Voyager :: Front Blower Resistor Failure
Front blower resistor going bad over and over? I've replaced it 4 times and it will last a few months. Then the van comes back with high blow only. There is an electrical component built into the resistor that has failed every time. I don't know if this is built-in fusible link or what. I've measured the resistance on a new one, which was basically 0 ohms, so I doubt it's a resistor, and can't be a capacitor. I've been wondering if the blower motor is drawing too much juice ( never blown the fuse ). How many amps the blower should draw. This is on a 2001 Grand Caravan Sport w/ rear ac.
View 14 RepliesCaravan/Voyager :: 1996 - Front End Shakes Like The Wheels Are Coming Off
My daughter has a 1996 Grand Voyager that she would like to sell. However, right now when you drive it the front end shakes horribly like the wheels are coming off. I mean the whole dash is shaking. Scary! In addition, I swear I've seen the front wheels appear to wobble when she's driving it. Ive changed the wheel bearing on the passenger side and was astonished to find that it made no difference. I was wondering about the half shafts and CV joints and such. How can I tell if these are bad? I've grabbed them and tried to move them and they don't move.
View 2 RepliesCaravan/Voyager :: Front Brake Caliper Frozen And Cannot Turn The Tire
My right front brake caliper is frozen and I cannot turn the tire. This happened about a month ago and I went to Autozone and they gave me a new caliper, rotor and brakes, under warranty, and now the caliper is frozen again and I cannot turn the tire when jacked up. It seems to release after a period of time. I am not sure if it has a proportioning valve for the front brakes, but the driver side wheel turns freely and is not stuck.
View 2 RepliesCaravan/Voyager :: 2009 - Front End Grinding Noise Only When Braking To A Complete Stop
Back in June I replaced all 4 brakes and rotors. Now all of sudden I hear a loud grinding noise in the front end only when I'm braking to a complete stop.
I took all 4 tires off and then took off the pads. The pads and rotors are all still brand new and have very minor normal wear. Also the calipers still look good.
I then put everything back together and went for a test drive. The grinding noise is still there. It's very loud and only when I come to a complete stop.
Caravan/Voyager :: 2010 - Humming Noise Coming From Front Left Near Tire Assembly
This a 3.3L engine although the noise has nothing to do with the engine but front left near tire assembly, what can it be?
View 6 RepliesFord F-150 (2004-2008) :: Clunk From Front End On Bumps
I have a 04 4.6 f150 4x4. I have had some off road wear on the truck but put a stop to it here recently. I have replaced ball joints , struts , sway bar linkage , hubs , and now have a clunking sound going over every bump no matter the speed. Everything is tight underneath while stopped, other than the front driveshaft. It seems to have too much play to me? What it could be ???
View 8 RepliesElantra XD (2001-06) :: 2003 GT - Clunk On The Right Front When Hit Bumps In The Road
2003 Elantra GT has a clunking on the right front when I hit bumps in the road. It is loudest when I first start to drive. After about 10 minutes it quiets somewhat and sometimes is gone completely. I looked at the CV joint and the strut but they appear ok. Also checked sway bar and tightened all bolts.
View 3 RepliesTiguan :: 2011 - Loose Clunk In Front Going Over High Frequency Bumps?
Have just picked up a 2011 Tiguan Highline, and there is a loose clunk in the front going over high frequency bumps in the road. I own a MKIV Jetta TDi and it feels similar to bad sway bar bushings on my MKIV, however it's not the bushings on the Tiguan.
I crawled underneath and tried to find looseness in the suspension with no luck. The sway bar end links seem tight (compared to the MKV Jetta I also have), and the strut mounts do not seem to be loose.
What I did find were some suspect control arm bushings. I'm new to suspension noises in this platform, our MKV has been flawless for the past 7 years. Could these worn bushings cause a loose clunk?
I also checked the subframe bolts and fuel lines that come up in common searches.
Golf IV / Jetta IV :: Front End Clunk Sound Occurs While Braking And Accelerating Over Bumps
A clunk sound coming from the front end. Drivers side and Passenger side. Not really a metal on metal sound. The problem started after coilover install. The sound occurs while braking and accelerating over bumps. So what I've replaced:
-Strut Mounts and Bearings
-Lower control arm bushings (R32 bushings)
-Drivers Side CV axle
What I've checked:
-Tie rod ends have no play
-Ball joints have no play.
-I have no sway bar, so not the sway bar bushings.
-Its not the axle hitting the frame.
Could possibly be the dog bone mount but when I installed the 1' motor mounts I saw no issue but could possibly be the bushing. feel the clunk in my foot as well.
MK4 2000 Jetta 2.0 5speed With Raceland Ultimo Coilovers (Junk)
Sonata NF (2006-10) :: 2007 - Clunk In The Front Suspension Making Noise While Going Over Small Speed Bumps
I have a 2007 Sonata Ltd (63000 miles) and had a clunk in the front suspension. I had the front upper control arms replaced (which were visually badly worn) and that fixed the problem. But now, a several months later another similar clunking noise has developed when I go over those small speed bumps in parking lots.
View 18 RepliesCaravan/Voyager :: 2012 - Programming New Key
We just purchased a 2012 Grand Caravan and was wondering where to get a key and program it. I know the key will be an arm and a leg if i get it from the dealer. Is there a tutorial that tells how to program it as well?
View 3 RepliesCaravan/Voyager :: Heat Comes And Goes Every Minute Or So
2006 Caravan. Heat comes and goes every minute or so. Also noticed the temp gauge goes from normal operating range to cold and back again frequently. Hasn't overheated. Does that sound like a thermostat problem?
View 2 RepliesCaravan/Voyager :: ABS Light Keep Coming On
On my 2005 3.3L Grand Caravan the ABS light keeping coming on. I inspected the sensors for the front and used my compressor to give them a quick puff of air to get rid of dust. The light went off for about 5 days. Now it is back on.
How does one read ABS codes? If I knew for sure that the problem is a speed sensor and which one I could clean or replace the faulty sensor.
If I clean to sensor are there any special precautions I need to take? As far as I could see they didn't look very dirty.
Caravan/Voyager :: 1996 / 3.0L - Scanner Does Not Link With ECU
I'm having trouble with my 96' 3.0L, its kind of crazy its intermittent and while driving the engines surges one or twice and then dies... when I try to crank it up again cranks but don't starts if I try again it wont even crank ( no starter winding up ) what I noticed is that is I'm driving when it dies my check engine light disappears for a while and if I connect my OBD 2 reader does not link up with the ECU if I wait a while and I crank it up again its starts and the while cranking up I can hear a bang noise from the engine compartment drives side and then after a couple of minutes dies again...
View 4 RepliesCaravan/Voyager :: 2006 / 3.8 Just Stalled At A Set Of Lights
I have a 2006 Grand Caravan 3.8 that just stalled at a set of lights yesterday and have had it towed back to the shop here. I turns over and starts briefly then will die and then just turn over strongly. I cleaned the throttle body and IAC but this did not work. I connected fuel pressure tester and have no pressure when turn key on or turn it over.
The fuse and relay check out ok, so I'm thinking bad or clogged fuel pump.
I have a 2004 Caravan out back that I have used for other small parts to interchange before and was wondering whether or not the fuel pumps between these two are compatible. Be a lot of work to pull the one off the one in the yard, only to find out its not going to fit.
Caravan/Voyager :: 3.3L Van Won't Accelerate (Code P0132)
142k, having some problems lately, the van won't accelerate now and again, moreso when the engine isn't up to temp, but lately it's gotten more and more prevalent. I have done some recent and needed maintenance in hopes of fixing the issue, but to no avail so far. I've replaced the plugs and wires, air and fuel filters, and both upper and lower O2 sensors (first replaced the upper with a Bosch, almost immediately had problems with P0134 code, so instead went with a Denso, hasn't come back yet). I checked fuel pressure, 60 psi sitting in the shop, the cat doesn't seem to be clogged, and it idles fine all day long.
Problem resembles running out of fuel, or more maybe like I'm letting off the gas, but my cheap scanner says the TPS is working fine, and I was watching the TPS percentage as I was driving it was reading normally. As I'm accelerating slowly from a stop, it'll start to cut out around 30 mph, but speed doesn't seem to matter, if I accelerate sharply it just bogs and slows down, if it does shift up a gear, the rpms will jump to about 5k, then slowly decrease even if I've got my foot on the floor. I keep coming back to the fuel pump, but I don't have a long enough hose to have it connected while test driving. Considering removing the hood so I can prop the gauge up so I can see it while driving. I am getting a P0132 code now, but I'm more concerned with the accelerating issue.