Camry :: 2004 - Ignition Coil Connector Broke - Connect Directly?
I replaced my valve cover gasket yesterday on my 2004 Camry. While putting back together, three of the tabs on the connectors for the ignition coil harness snapped off and would not stay together because of tension on the harness. I tried to zip tie them because I read that in another forum post but the clips (alligator clips?) inside the connector did not seem to be making contact with connector on top of ignition coil. The car was mis-firing and running very rough.
After much frustration, I finally removed the wires with the alligator clips from inside the connector and plugged them directly into the top of the ignition coil. Well, the car started and seems to be running/idling fine although now the Check Engine Light is on. Also, I have not driven car yet.
My question: Can I drive the car like this or will the vibration from the engine eventually loosen the connections. I am planning on ordering the connectors but they will not be in for a few days and I need to drive the car.
Touareg :: How To Remove Coil Packs To The Plugs
I've decided to jump on the DIY bandwagon a do my own 60K service. I've found the great write-ups on the oil changes, and even the spark plug removal; but need a detailed explanation or even pictures of how to remove the coil packs to the plugs; I don't want to break anything.
View 3 RepliesLexus GS 2006-11 :: 2008 - How To Get The Coil Packs Out
I am trying to get my spark plugs changed and having a hard time trying to figure out how to get the coil packs out. I have done some research already but couldn't really find anything solid for the GS 460 specifically. Many people had useful information on the other GS models (300,350 etc) but since the 460 is not as common, I couldn't really find anything.
I read the guys use pry bars to wedge the motor a little to have extra clearance to pull the coil packs out but it seems the LS has a little more room to work with. On the GS 460 however, it is pretty tight and even using a pry bar I really do not believe the coil pack will have room to be remove completely.
Camry :: 2004 - Spark Coil Connector Holding Crack Off?
Scheduled maintenance for changing spark plugs for my Camry 2004 2.4L is either 120k miles, or 144 months (12 years). My Camry reached 12 years first. In removing the coil connectors, 3 of 4 holdowns cracked off. I guess not so surprising after 12 years subject to engine heat. I'm NOT going to replace the connectors. Looking for a patch for this problem? Duct tape will just result in adhesive getting everywhere it shouldn't. Maybe there's a high temperature "crazy glue" I could apply at the connector interface that will last another 12 years, or 120k miles?
Otherwise, I'll use the "hope adhesive". That means I'll just hope the connectors don't work loose at a bad time.
Camry :: 2007 V6 - Wire Unseated From Connector During Ignition Coil Removal
Any easy solution to reseating this wire in the connector? It got yanked out by accident when i was removing an ignition coil under the wiring harness. 2007 camry v6
View 3 RepliesTrailBlazer :: Ways To Test Coil Packs?
2004 TB EXT, 4.2L I-6. Steady misfire on a single cyl. Changed spark plugs, (installed A/C Delco Iridium, 41-103). Fired it up, and miss was gone for about 20 seconds, then came back. Scan turned up P0301, Cyl #1 misfire. I picked up a coil pack, but before installing it, is there any diagnostic tests I can do on the connector, or any tester for coil packs? Not wanting to install this $80 part, (rendering it non-returnable), and have it make no difference. Hoping to at least be able to check for proper voltage supply and trigger signal at coil connector, if possible. Also, any checks I can perform on the injector harness? Thinking it may be one or the other. Or should I swap coil pack to another cylinder, and see if problem moves with it?
View 2 RepliesGolf V R32 :: Won't Start - Six Faulty Coil Packs
Having issues with some or all of the coil packs going bad? Because it looks like all 6 coil packs on my R32 went bad...
Brief history, my car stopped turning on about a month ago, it was working just fine when one day when going to lunch it stopped wanting to turn on, I had to crank it about 3 or 4 times and it turned on, I went to lunch then got back but when I left for the day (at work) I once again didn't want to turn on and that's about it. I had to tow it home and a couple of friends and I began trying to figure out why we tested the fuel system and electrical. We could get no little to no spark on all 6 coil packs. Ran vag com and nothing would come up, I tested the Crank position sensor and it tested fine but broke the connector so I replaced it with a new CPS. Still, would not start.
So after a couple of days, we decided to try 6 known good coil packs and it fired right up. So yeah I've never heard of all six coil packs going bad at the same time, so what could cause that ? btw soon after the car started, about the 3rd time turning it off and on the starter decided to stop working, I'm thinking it was because of all the times I tried to start it, it was allotted. : thumb down
Passat (B5) :: Coil Packs Went Out - Codes P0301 And P0420
After changing 3coilpacks on my Passat 04 1.8T soo far finally the last one went out. The codes I got are P0301 (which is misfire cylinder1) and the other code is p0420 which I do not know what it is... I think it might do something with cat or something.
View 1 RepliesGolf IV / Jetta IV :: VR6 Won't Start And Smoking From Coil Packs
I've had my 24V off the road for about a year now working on it. I did some wire tucking and what not, nothing major. Now when I go to start it, it won't start and it will make a popping noise from a coil pack and it starts to smoke.
View 6 RepliesAccent LC (2000-05) :: 2002 - Cylinders 2 And 3 Dropping / Changed Coil Packs
I have an 02 accent with a 1.5L and it is dropping #2 & #3 cylinders. I changed the coil packs and still had no spark on #2 & #3. I checked the wires going to the coils and had no voltage feeding the coil packs.
View 1 RepliesCamry :: Broken Wire Harness Spark Plugs
Two of my plugs locking clips broke today on the wire harness side where the coil over plugs into the harness today while changing spark plugs. They will plug back up, but they won't lock together like they are suppose to. How critical is this? It is my wife's car will she break down? I drove the car maybe twelve miles, and everything seemed fine.
View 8 RepliesFord Super Duty (1999-2016) :: 2009 F250 - Coil Packs Slowly Failing
I have a 2009 f 250 5.4 v8 trition motor my coil packs are slowly failing. I want to replace all 8 of them. Which coils and plugs I am going to need. I guess I'll replace the plugs also, how are the accel coil packs and ngk plugs....
View 1 RepliesFord Super Duty (1999-2016) :: 2003 - Replaced Coil Packs Now Runs Rough - White Smoke?
I have a 03 250 5.4 with 160k. I just recently replaced #4&3 coil packs. Truck was running great again. Then a few days later the truck was running extremely rough and white smoke from the exhaust. I noticed the pcv valve was not all the way in(pretty much out) put it back in and ran fine for two days now running rough every now and then and the pcv valve is making a vibrating noise but stops if I pinch it slightly. I did replace the plugs a year ago.
View 14 RepliesPrius (2010-12) :: Clips Holding Plastic Cover Broken?
I opened the hood today to install the Carbon Fiber logo and noticed that the plastic cover sitting on top of the radiator was loose. That's when I noticed that the 2 clips holding the plastic cover were broken.
View 3 RepliesFord 6.7L Power Stroke Diesel :: 2011 - Broken Fuse Box Clips?
Just picked up a new to me very nice 2011 F350 SWB 4X4 Lariat. While going through it and I missed this when buying it, the top of the under-hood fuse box was missing and just covered over by a makeshift cover of rubber and black duct tape.
I have ordered and received the the new fusebox cover ( what a bear to get into place ) and then figured out that the PO had broken the clips that lock it down.
I have tried to get a long zip-tie around it, not much luck, and now I get a C-clamp into there to keep it closed?
I really do not want to have to order a new fusebox and pull this one apart and rewire, that just screams electrical gremlins for the life of the truck.
Prius C :: Connector On The Spark Plugs Has Different Color
Bought my car three weeks ago. I was looking around under the hood and noticed that the color of the connector on the spark plugs is different. Two are grey and two are black, in alternating order. What's up with that?
View 5 RepliesFord F-150 (2004-2008) :: Plug Connector On Coil 3 No Longer Snaps On
I changed out my plugs. The plug connector on the #3 coil no longer snaps on. My only option is to use a small ziptie to hold it in place. Can cut it off and wired a new plug end on..
View 3 RepliesFord Escape / Hybrid :: 2005 XLT - Ignition Coil Connector Wires
I had squirrels eat wires to the front 3 Ignition coil connector on my a 2005 ford escape XLT,my question is the new connectors have a white and black wire and the old ones had a red and a colored wire, but comparing both old and new connectors I notice the new connector has the black wire where the old connector has a red, so do I use the black wire to replace the old Red? , it's rather confusing to me when you plug in the new connector you can see the black wire is where the red wire was on the old one, or does it matter which wire goes where?
View 2 RepliesFord F-150 (2004-2008) :: Broken Locking Tab On COP Connector
In removing the COPs on my 2004 F150 Lariat 5.4L for a spark plug change, I noticed that the locking tab on one of the electrical connectors that plugs into the COP is broken. The previous owner had a zip tie on it to keep it on. Can I purchase a new connector and splice it on so that I don't have to use a zip tie? If so, what is the part number?
View 11 Replies