Dodge - Caravan :: 2000 - Power Door Actuator Is Noisy?
So I needed some electrical parts for the 2000 Caravan mostly the power door actuator is noisy and one vent window motor is shot. So I went to the local pull a part, paid $2 admission fee. Found my parts but no way to test them. Went to pay for them, they wanted to charge me $25 for each part, were not willing to have it returned in case it did not work, and did not have a battery for me to test them either. Is this the norm or should I have gone there with my oldest T-shirt? These parts sell probably for $45 to $80 new/on-line. I was trying to save money but felt if I end up buying the part again, it is essentially worse than just buying new.
View 3 RepliesDodge - Caravan :: 2000 - Puff Of Blue Smoke Come Out Of Exhaust
I have a 00 dodge caravan. Has always been a good van. Recently when I start it up first thing in the morning there is a puff of blue smoke come out of the exhaust. This will not show up again if you start the van up wth in an hour or so. If you leave it for 3 or more hours you will get a puff of blue smoke but not as much as the one after it has sat all night. What this might be????
View 6 RepliesCaravan/Voyager :: 2000 Dodge Grand - Driver Side Not Bowing Hot Air?
Drivers side not bowing hot air? We changed the blower motor and the resister on the passenger side. We hadn't tried to use the heat until last night when we needed the defrost and that's when we realized only heat on passenger side.
View 1 RepliesCaravan/Voyager :: 2000 Dodge 3.3 Engine Noise At Idle And Under Low RPM Load
I have an engine noise on my 2000 Dodge Caravan with the 3.3 engine. It sounds a lot like the grinding of a rotating part. It occurs at start up, momentarily, then goes away. If I drop it in gear and start doing low speed maneuvering in the driveway, it comes back. If I turn on the AC it comes back. In all cases, the noise goes away at around 1200 rpm.
The noise occurs again, when I shut the engine down.The engine performs and runs smooth and normal otherwise. No stalling, stumbling, or bad gas mileage to report.
I can "feel" the noise with my hand, when I put my hand on the ac compressor bracket, or the intake manifold, or the valve cover. I've tried the listening through the stick method, and it seems to be coming from the front area of the engine. But I can't be sure. It is something internal. Let me describe:
I thought it was my AC compressor or clutch going bad. The fact that my AC had stopped working well, and was making jet engine noises at high rpm supported me decide this. I replaced the compressor. The AC works great now, and the jet engine noises went away. But the grinding noise is still there. As described.
I wishfully thought it was the belt tensioner or idler pulley. I replaced both of those. Noise still was there. I pulled off the serpentine belt, and started the engine. It made the noise, very briefly as it started, then went away completely. It made the noise again briefly as I shut the motor off. So it's still there without any of the accessories turning.
The noise is loud and obnoxious at idle when under load. It just can't be good. I've read theories about similar sounding problems, saying they could be loose timing chain, bad oil pump, slapping pistons, crank journals, flexplate/flywheels cracked.
I'm going to try doing an oil system flush, and then I'll change it out with a little thicker oil. See if that makes any difference in the noise. Currently I'm running 5w-30 Mobile 1. I think. I'll let you know if it changes anything. I'm also thinking I want to make a short video of the car idling and making the noise for my video camera. I'll post that on youtube and link it here.
Stall - Dodge - Caravan - Timing-belts :: 2000 / 3.3L Starts Right Up, But Then Stalls
I have a 2000 Dodge Caravan SE 3.3L. The timing chain recently broke. So I replaced the timing set, cover, water pump, camshaft sensor, and oil pan. The timing is all aligned. It starts right up, but then stalls. Unplugged the front three spark plugs to see if one of those were the problem, and then it ran better and didn't stall out.
View 3 RepliesDodge - Caravan - Relay - Fans - Radiators :: 2000 - Cooling Fan Won't Turn On?
I have a 2000 Dodge Grand Caravan that has 195,000 miles. My radiator fan won't turn on and I'm stumped! The issue presented itself with a check engine light and the radiator cooling fan not turning on. The trouble code indicated the cooling fan relay was faulty. In all cases below, I tested the radiator fan by turning on the air conditioning (thus forcing the cooling fans to run) and also for it to come up to a high temperature coming close to the danger zone.
1. Fuse - first tested the fuse and it was OK. Had to start with simple things first.
2. Cooling fan relay - I replaced the relay which has a reputation for failing on the Dodge. Still the fan did not kick in.
3. Cooling fans - tested the cooling fans and the motor was seized. Replaced the cooling fans and tested them by jumping them. The cooling fans still do not turn on. There is no voltage leaving the cooling fan relay and coming into the cooling fan harness.
4. Wiring - tested the wiring between the relay and the fans. They checked out OK (good continuity and resistance check). There is no voltage leaving the cooling fan relay. Now it's getting more complicated... I unplugged the wiring harness from the ECM and tested the wiring between the ECM and the cooling fan relay. A-OK.
5. ECM - it is unclear how to check the ECM for functionality of the cooling fan.
There are 3 wires (supply, ground, and switch wire?) The supply voltage and ground is good, but I don't know what voltage the switch wire should be. I've read that it is pulse width modulated so I can't measure this with a simple voltmeter. I've also read that the switch wire goes to ground thus triggering the relay. I don't know which is correct. Several mechanics I talked to were skeptical that the issue is with the ECM, they knew of very few instances of this being the culprit. I even replaced the new cooling fan relay with another new cooling fan relay on the off chance that the replacement was faulty. Did I miss something in my logic and diagnostics? I've resorted to wiring a switch directly to the cooling fans and toggling them on and off.
Dodge - Caravan :: 2002 - At Start Up Won't Shift?
a couple of weeks ago, when it was about -15 here, my car started acting strange. In the morning after I started it I tried to shift into drive and it wouldn't engage. The same happened in reverse. I would shift into drive (or reverse) and it would not shift. I would put it in the park then shift back to drive and after a couple of times it worked. Once I am up and running it seems to be fine, it shifts up as it is supposed to when I am increasing speeds and it does not slip out of drive. I thought at first it was the cold, but has continued to happen - usually just in the mornings - even now that the weather has warmed up (!) to 20. The fluid seems fine according to the dip stick and the color of the fluid is pink and has a sweet smell, no burning smell. Could this be a first sign of bigger issues or something that can be taken care of with a fluid change or flush?
View 3 RepliesDodge - Caravan :: Will Almost Start But Then Stop / Grinding Sound
I've had this '96 Dodge Caravan for just over a year now and suddenly I go to try and start it and it will almost start but then stop. All my dash comes on like it supposed to but when I turn my key it just stuggles and makes a grinding noise. The only thing i know is my common sense is saying if it makes grinding noise dont keep trying you'll make things worse.
View 5 RepliesCaravan/Voyager :: 2005 Dodge Anti-theft Reset Won't Start?
Anti-theft alarm was triggered inadvertently and now won't allow vehicle to start. When ignition is turned there is just a click...does not turn over. Is there a reset???
View 7 RepliesCaravan/Voyager :: 97 Dodge Engine Fuse Blown When Start To Accelerate
I have a 97 dodge caravan engine 3.0. When I start to accelerate my engine fuse 20amp blows. I does not occur every time but yesterday, it did it 6 times and is now getting looked at. I am just curious on what causes this. I did recently have my spark plugs changed so I am thinking something may be arching.
I do have codes that previously came up for my fuel injectors (P0203, p0206). Another code I have is p1294 idle speed performance.
Dodge - Caravan :: 2004 Won't Start - No Crank / Grind / Click And Dash Lights
My friend (yes, really, a friend, not me) parked her 2004 Dodge Caravan in the driveway the evening before. The next morning it would not start. No crank, no grind, no click, and no dash lights, nada, nothing. She took it to the shop she's taken the car to for years for repair and maintenance. She trusts them. They've replaced the battery and run a full diagnostic on it, but are unable to solve the problem. The shop is telling them her it could run into the thousands just to figure out the problem. What could they be missing?
View 4 RepliesIgnition - Dodge - Caravan - Electrical-wiring :: 2000 - No Blower / Power Seats / Blinkers / Power Locks?
Blower, seats, locks, blinkers stopped simultaneously, abs and airbag light came on. The internet suggested it was the ignition switch, I changed it to no avail. The horn, wipers, 4-way flashers, headlights, taillights, and brake lights all work. Is my wife correct in suggesting we replace this 140,000 mile pile of rust?
View 5 RepliesPontiac - Vibe :: Will Not Consistently Start - Engine Just Never Gets To That Final Rumble To Stay On
We have taken our 2006 Pontiac Vibe to two different mechanics numerous times trying to find out what's wrong, but they told us that the car needs to not start for them in order for them to diagnose the problem. The issue with this is that every time we leave it with them, it starts just fine, and they charge us $45 per night to leave it there. We are scared to use the car because we don't want to be stranded somewhere when it randomly doesn't start.
Symptoms:
- Starts sometimes, but not consistently (once every week or two, it just won't start)
- The car sounds like it is almost going to start, as we are hearing more than just clicking, but for some reason the engine just never gets to that final rumble to stay on.
- When the issue occurs, the car will sometimes start if we try again minutes or hours later
- Jumping the battery seems to get it start.
Previous Attempts:
- Already changed the battery
- Already gotten a tune-up and oil change
As I said, we are incredibly frustrated, as this problem is not consistent enough to show up for the mechanic, and therefore renders us with an unreliable and undiagnosable car.
Caravan/Voyager :: 2000 3.3L Won't Start After Transmission Replacement
I just replaced the transmission in my 2000 3.3L Grand Voyager and now it won't start. It started fine when I drove it into the shop. The battery is good, the cables are ok. The starter worked good up to this point. I checked all the connections to make sure they are tight. I replaced the transmission because reverse went out.
When I turn on the key, the shift letters (PND32) appear on the instrument panel, but the little circle that shows what gear it is in does not appear. When you turn the key to the run position, the circle should be around the P to show it is in park.
When I turn the key to start, nothing happens. No clicks or anything. The next thing I am going to do is see if there is power to the starter when the key is in the start position. Where to start looking?
Dodge - Caravan :: 2003 - A/C Is Draining
Sone water from the air conditioner drains on the carpet on the right side of the car. The drain hose is open and water in draining from it. Where could I look to find the problem? It is a 2003 caravan
View 1 RepliesDodge - Caravan :: Oil Light Comes On At Stoplights
We recently had some oil leaks fixed on my wife's 2002 Dodge Caravan. The oil light comes on whenever she stops at a stoplight. It seems like it comes on when the RPM drops to about 600 or 700 RPM and then goes off when RPM increases. Is this something to worry about? If so what needs to be fixed?
View 8 RepliesDodge - Caravan :: Cylinder 4 And 6 Misfiring
I just had all 6 fuel injectors changed as they were rusted. But the 4 and 6 are still miss firing. I am going through gas more than I should. I had the EGR replaced as it was stuck open. I do not want to pour more big money into this thing. What can I do. Sea foam is not working. Could it be another problem. I am starting not to trust the mechanics.
View 12 RepliesDodge - Caravan - Van :: Jingley Noise When Went Over 35 Mph
I have a 2005 Dodge Caravan. I drive very little locally - usually just a couple of miles a week. But every couple of months I drive an hour and a half away to THE BIG CITY. Last week I took such a trip, and coming home I noticed my van was making a "jingley" noise. Just like the sleigh bells in the barn. With the windows open I can't tell where the noise is coming from. And it isn't associated with the a/c, since the a/c was off when the noise started.
Since then when I take my little local trips it only made the noise once - when I went over 35 mph. Usually drive slower locally. So, I don't know whether the problem is associated with length of drive time or speed, but I'm thinking it's associated with a higher speed.
Yes, I have an apt. with a mechanic, but I can't get in to see him until the middle of next week.
Caravan/Voyager :: 03 Dodge - No Crank From Starter
I've been fighting with these vehicle for months, and I've only been able to narrow down the list of possible issues. Tried replacing the ignition switch, battery terminals and cables, starter, and even a PCM since according to the dealership it was bad. I've checked all the fuses and relays, and they're all ok.
I'm getting fuel and spark, but no crank from the starter. The voltage going to the hot post on the starter is 12.7, but the voltage from the igniton wire is only reading around .5-.6, fluctuating a bit. Before I spend the money on taking it to a mechanic I wanted to know what your opinions were on what the next step is. I know a bit about electrical systems in cars but I'm no expert.