Ford Excursion :: Sound Like A Card In Bicycle Spoke Coming From The Right Rear
A couple of weeks ago I heard what sounded like a loose heat shield, coming from under the Ex. It went away, but then came back a few days ago. I got underneath and looked at all the welds on heat shields and for anything that seemed loose, I found nothing. Yesterday it started sounding like a card in bicycle spokes, coming from the right rear. This afternoon I pulled the wheel off along with the brake caliper and disc. What I found was that one of the springs on the parking brake shoes had broke and has been ground up in the drum. I didn't take any pictures, but thought if others hear that sound it's something you may want to check.
View 10 RepliesSubaru - Forester :: Piston Clatter / Sound Like A Playing Card Against Bicycle Wheel In Colder Temps Only
I have a 2003 Subaru Forester XS, bought it new, has almost 100,000 miles. Only take it to the dealer. Regular oil changes, and routine maintenance. Around 65-70,000 miles, I began to hear a sound like a playing card against a bicycle wheel in colder temps only. Dealer called it 'piston clatter' and not to worry about it. So I didn't. Over the years it has become a year around sound, even worse in colder temps. I've been afraid to drive it out of town on the interstate or highways because at times the engine sounds as if it's going to jump out of the car. I wrote to Subaru corporate, only to be referred back to the dealer, who again, will only tell me it's 'piston clatter'. I have used fuel additives, and a tank of premium every now and then. Still makes the same sound.
View 5 RepliesVolvo - Xc70 :: 2003 - Noise Gets Faster And Slower With Acceleration And Deceleration
When driving my 2003 Volvo XC70, it sounds as if I am driving on nobby mud tires. The sound (rrrrrrrrrrrr) gets faster and slower with the cars acceleration and deceleration. I know that the sound isn't caused by the tires because I am running on Micheline Harmony tires which are fairly quite. I am concerned that it may be a gear going bad.
View 5 RepliesVolvo - 240 :: 1993 - Location Of Brake Switch?
We have a late year model '93 240 sedan. Brake lights are not working, we've checked all the usual suspects. We cannot locate the brake switch. It is not in the usual location under the dash. There is a bracket there for one, but it seems that this is a late year model and the switch location may have been moved? Where this is located? Would really like a schematic so we can get to the bottom of this issue! Car is obviously out of commission until brake lights work.
View 1 RepliesVolvo :: 1993 Vehicle Running Hot / Shaking While Braking
First off, vehicle is a 1993 Volvo 240, 5 speed with 131,000 miles
1) Temperature gauge is reading hot, but I believe it's running at a normal temperature. I read a few things discussing this issue. First off, a yellow wire that runs through the firewall becomes corroded (as do all Volvo wires of this age!) What exactly is this wire and what does it lead to? Could I just rerun that wire with possibly a thicker gauge? My dads an electrician so no worries with the wiring. More commonly, however; I read that the temperature compensation board fails and gives erratic readings! is this board expensive and how difficult is it to replace? I have experience with this dashboard because I rebuilt my odometer and installed a tachometer, that gives you my basic level of expertise.
2) My passenger side rear fog light won't work, a new bulb didn't fix the problem, what could it be?
3) My car shakes kind of vigorously while braking, especially at LOW speed!? I replaced front pads and rotors, what else could the problem be?
Volvo.jpg ( 2.19MB )
Volvo - 240 :: 1993 - Unable To Get Manual Transmission Into Gear
I was recently driving my 1993 Volvo 240 wagon over the Bourne Bridge in bumper to bumper traffic (surprise!). Traffic was moving at 3-5 mph as I navigated the rotary and ascended the bridge. Needless to say, I was developing leg cramps as traffic crawled up the steep bridge incline. Once I crested the hill, I shifted to neutral (still 3-5mph to coast down the decline and give my leg a rest. After coasting for a few minutes I attempted to shift into second gear to re-engage the transmission.
I was unable to slip the gear shift stick into any gear! I continued to make sure that I was depressing the clutch all the way to the floor, but still could not muscle the stick into a single gear (by the way, I never smelled that "burning clutch smell"). After about a minute or more of mental disaster planning, I finally coerced the shift into third gear. A minute or so later, I was able to shift into second gear which got me around the accident causing the delay and onto the highway. From that point on, I was able to shift normally for the remainder of the 2 hour trip. What happened and what could I have done to solve the problem? (The car is now at the repair shop where they are equally perplexed).
Volvo - 940 :: 1993 - Stalling At Any Speed Mostly When RPMs Go Up And On Hills
So here's the deal, I bought this 93 Volvo 940 turbo station wagon about a month ago. It was stalling when I got it so I replaced the rotted hoses, fuel filter and cleaned the fuel system. The fuel pump was replaced a little before I got it. 2000 miles later it is stalling again at any speed mostly when the rpms go up and on hills. We are trying to replace the map sensor but can not find it anywhere under the hood. Does this car even have a map sensor and if so where is it located... We are also trying to clean the throttle sensor but cant seem to get it out without taking a bunch of other pieces apart, is there a trick to this. Is there anything else it could be...
View 4 RepliesVolvo - 940 :: 1993 Wagon Won't Start In Humid Conditions
My 1993 Volvo 940 Turbo Wagon starts and runs great in dry weather, but in wet weather, i.e., after/during rain, in very humid conditions, it has trouble starting and often won't start. The engine turns over but doesn't run. I got it started this morning after opening the hood and cranking it, thinking that the airflow might dry out whatever the issue was, but after driving for 3 minutes it stalled at a stop sign and I had to repeat the process.
A wire to the alternator was recently replaced, which I thought should have stopped the problem, but it didn't. The alternator checks good, and the check engine light is not on.
Volvo :: 1993 850 - Shift Light Indicator Flashing / Blinking
Just cleaned out the oil seperator box on my 93 850, put new injector seals in and a new intake gasket. Start up the car ran rough for a little then idles like a champ. The problem-shift up indicator is blinking. Barely put my fut on the gas shifts up a gear then back down then back up, I think I unplugged something by accident.
View 1 RepliesVolvo :: 1993 240 Intermittent Stall On Startup / Engine Revs Low
What's going on with my '93 240. When I first go out to start my car in the morning, it starts up fine. After that, however, is when the trouble begins. If it's hot out, or if I've driven the car that day, there's a 50% I'll have trouble keeping the engine running. The engine will run rich, and chugs on startup, eventually stalling out after a few revolutions. During this time, the engine revs low, don't have a tac so I can't say how low, but definitely below idle.
If hold the accelerator to increase the RPM, the engine will run fine, but once I let off the gas, chances are it will stall out again. Eventually, after doing this a few times, something seems to catch the car as it begins to stall again, as in, just before the car is about to stall, the idle speed kicks up to normal. After that, the car runs fine.
I've had a code for the MAF for a long time. I tested the resistance across the meter, and it indicates the wire is still good. Even at that, I've replaced the MAF, but nothing has changed. Still have the same problem. What could be causing this?
Volvo :: 1993 Idle Goes Up / Down After Changing Fuel Pressure Regulator
Just changed the fuel pressure regulator on 1993 volvo 850 (non turbo), now the idle goes up and down then stalls.
Also changed IAC, but with a used one from a previously working car.
Volvo :: 1993 - Viscous Fluid On Floor Of Driver Side
What could be the cause for a viscous fluid on the floor of the car on the driver's side. "White" smoke comes from the engine and it makes a noise. Car is a 1993 Volvo 850 stick shift.
View 4 RepliesVolvo :: 1993 - White Smoke Coming Out Of The Dipstick Tube
I have a 93 Volvo 850 N/A, there is white smoke coming out of the dipstick tube, not alot but enough, also there's like a white/ yellow foam on the dipstick tube, but the coolant has not changed, so im assuming its not a headgasket. I have cleaned out most of the vacuum lines and flame trap but cant find the pvc valve.
View 3 RepliesPassat (B5) :: 2003 - No Horn After Installing Euro 3 Spoke Wheel?
Just installed a euro wood/leather wheel in my wife's 03 Passat wagon. It had the MFD wheel previously.I've done the install numerous times as far as going from MFD wheels to GTI or R32 wheels and never had this problem.
Ran a jumper from pin 9 to 18 and modified the plug to the clockspring....I got the cruise working no problem and that's the toughest... I've double checked everything and think it has to be with the wheel itself. I see the wheel has TWO tabs for the horn ground. I'm only using one right now as that's how my R wheel is in my 03 Jetta (just pulled the bad and checked it). What could be causing the horn not to work?
Chevrolet - 1500 :: 1993 - Vibration During Acceleration
Car: 1993 Chevy C 1500 (2WD) manual transmission Background: The car sat unused in a garage for 2 weeks (no problems before this) the first drive after its break, the pickup almost felt like it was slipping and power was not getting to the wheels. The vibrating began the next day. The vibrating is very obvious and unpleasant under acceleration at approximately 2000 RPMs in any gear. Grease was injected via grease zerk into the center carrier bearing area and the vibrating was marginally better. Today the back end of the truck was lifted up and put into gear and brought up to 30 MPH. The pickup was then lowered and a test drive revealed that the vibrating was considerably diminished.
An inspection of the drive shaft reveals:no vibrating in neutral the U-joints are not loose or leaking; the drive shaft has 2 small dents which are countered on the opposite side by weights;the drive shaft will move up and down ~1 inch or less if pushed in bench press fashion near the carrier bearing;the drive shaft does not move in the direction of the length of the vehicle;the drive shaft will rotate freely 1/16th to 1/8th of a turn before it is stopped by the back of the transmission or the rear differential; no mud clods in wheel wells;new tires properly inflated.
Ford - Escort :: 1993 - Sputtering During Acceleration
Our '93 Escort, Gilligan, (1.pL, 125K, manual and under our ownership for less than 6 months) has recently developed the shameful habit of chugging and glugging during acceleration, most specifically second and third gears, with the occasional hiccups at cruising speeds. If Gil is driven a little "harder" then there is little issue with sputtering, but then we are killing our MPG and beating the crud out of his motor. Using a careful foot there are better "zones" that can be found via the accelerator than others, but no "safe zone".
He has had several bottles of fuel injector cleaner, new spark plugs (the wires looked fairly new and clean), fuel filter and a replacement ignition coil pack, so these have been ruled out. I thought it might be the Mass Air Flow Sensor, so I drove him around with it unplugged, but that made no difference. If there is a clog in a injector is it possible to "flush" it out or would he require a more in depth cleaning?
Silverado :: 1993 Chevy RWD Lost Power And Acceleration
I have a 1993 Chevy Silverado rwd automatic 350 5.7. It died on me on the way to work this morning. It slowly lost power and acceleration. The lights and radio all worked. When I tried to restart, it tried to start but then just cranked like it had no fuel or spark.
I had it towed home and checked the following things. I removed the fuel filter, it is clear. I verified that the fuel pump was working by turn the key to the on position while the filter was off. Good stream of fuel. I verified that there was fuel to the TBI. Good spray while cranking. I verified that there was spark by pulling a plug out, connecting to the wire and cranking the engine. Spark seemed weak but there was spark. The front plugs were dry, but the rear plugs, especially #8 was very wet. I verified the timing by pulling the #1 plug, removing the distributor cap and checked the rotor position. I bumped the engine to get the #1 piston to the top of the cylinder and the rotor was point directly at the #1 plug wire. The cap, rotor, plugs and wires are only 1 month old.
I also tried to check the ignition coil by disconnecting the coil wire from coil, and slid the boot back to expose the contact. I held it just of the coil while the engine was cranked, but did not actually see a spark at the coil. I did not hear any arcing. I pulled another plug and checked for spark. Again i had spark. Just seems weak to me. I am on my way to the auto parts store to get a new coil.
Ford Aerostar :: 1993 - Bogs Under Acceleration / No Power
My 1993 ford aerostar 3.0 is a great vehicle but recently its been killing me trying to figure out what the cause is. I'll start at the beginning. I had a job over the hill in Westwood Ca. Ran low on gas on the way home. Too low apparently. Since i refueled it has a really rough idle and no power under acceleration. After it gets warmed up i get a bad smell of gas and exhaust in the cab.
Now if i turn it off wait 15 min or 12 hours it will run ok for 2 min then back to hell. I has not stalled and i have replaced the fuel filter and a few months back i cleaned the Mass air flow sensor and replaced the TPS. I would love to take it to a mechanic but as i have been living in this old girl for the passed 6 months money is non-existent.
What to do. I have even tried disconnecting 1 at a time... the TPS, MAF, and the 02 sensor. No difference. There has been no check engine light until I tested by disconnecting TPS etc.
Volvo :: 2014 XC90 - Hesitation And Very Little To No Acceleration
Have 2014 XC-90 w/10k miles. Problem is sporadic (has happened approx 10-15 times over past year).
From standing stop (stop light, etc) -- press on accelerator and VERY LITTLE to no acceleration. Engine continues to run smoothly -- no indication of fuel starvation, no roughness --- just no acceleration. It does NOT appear to be transmission oriented because when it finally "kicks in" there is no feeling of transmission shifting or wild tach movement (to indicate that there was a changing of the gears, etc). I get things back to "normal" by pumping the accelerator (usually a reflex action because the are vehicles behind me wanting to "go"). VERY disconcerting issue.
Local Volvo dealer says "cannot find any error messages", etc. My only complaint with the car -- second XC-90 and 5th Volvo.