Ford 6.0L Power Stroke Diesel :: Intermittent Hesitation After Stopping At Light / Stop-sign
Trying to troubleshoot a very intermittent (has happened on two different occasions during the last 1,000 miles) hesitation from a stop-light. I've been recording engine parameters (Torque application) on both instances as these have been during longer trips after a period of highway driving. 2004 Excursion, 112K miles.
This feels kind of like severe turbo hesitation (4 to 10 seconds trying to start out before it kicks in) but I don't think that's it. The turbo is a new PowerMax turbo replaced 5 months ago. VGT readings seem pretty normal. The EGR valve is new -- the first instance was with the old and the second was with the new. I've also recently replaced the EGR and Oil coolers (before this).
Here's what's interesting in the captured data though... Normally when I coast into a stop-light the indicated engine load stabilizes at about 40-50% and VGT moves to about 65% to 70% at idle. The two different times this happened (actually multiple times at stop-signs/light close to each other over 5 minutes or so for both of these), when I have coasted to the stop, the engine load increases from low values during coast-down (0% during freeway coast-down or 19-30% during other coast) up to 99.6% (or other similar high values) at idle and VGT seems to be full closed at 85%.
There is absolutely no response to the throttle in this situation for 5-10 seconds. I've either been goosing the throttle a bit or putting it neutral and revving it up first to get things going again. When it finally catches and starts accelerating with power, indicated engine load drops to 50-60% again and VGT opens up to 40-60% or so. None of the other parameters I've been capturing seem to read strangely during this that I recognize. No issues observed during cruise and power seems good. No pending DTCs or engine light.
Here's what the data points I'm capturing (once each second):
Boost
Calibration Input Volts
ECT
EOT
Fan RPM
FICM main volts
Fuel Injector pulse width
ICP
ICP Volts
IPR Duty cycle
RPM
Engine Load
MAP
Trans Temp
VGT Duty Cycle
EBP
EGR Commanded
EGR Error
Added today but not captured during these issues yet:
IAT
IAT2
Baro
Accel Pedal Position
Mass Airflow Rate
Mass Fuel Desired
Toyota - Corolla :: 2002 - Flashing Check Engine Light?
I have a 2002 Toyota Corolla CE with about 115,000 miles.While I was traveling on the highway my car started shaking, losing power, and the check engine light started flashing. I drove a mile or two to a rest area because I didn't want to pull over on the highway. I had it towed home. It starts and idles, but I'm afraid to get it out on the road.
View 15 RepliesToyota - Corolla :: 2002 - Check Engine Light Came On After Oil Change
Had the oil changed today; before doing so, I saw that the check engine light had come on. Have been told by 3 professional car maintenance people that there is no connection between needing oil / oil change and check engine, that it would have been the check maintenance light.
Will take it in for diagnostic test by dealer. Also, was told by the oil change guy that he heard pinging which could mean that the car needs to have the valves adjusted, and that the check engine light is due to needing something or other with the gas tank filter which could have a leak/crack, etc.
Sienna :: 2002 Toyota Shutting Off When Stopping
My Toyota Sienna 2002 van has been stalling when I stop off and on for about 2 weeks. Most times it starts up again and continues to run. I can go days and it doesn't happen then yesterday it happened 7 times in the course of 10 minutes. I've had it connected to a computer diagnostic system three times, couldn't find any error messages.
View 2 RepliesToyota - Corolla :: 2001 - Hesitation For Just A Second Within The First Mile Of Driving
In january I took my 2001 Toyota corolla to the mechanic (that had replaced the engine 5 years ago) because it was using oil and gas mileage was very poor. He gave the car and tune up and right afterward I noticed the car hesitated for just a second within the first mile of driving. After the hesitation it had full power.
Then the check engine light came on with a code for O2 sensor; I had that part replaced about 2-3 years ago. So that was replaced. The next day I was driving on the highway when I heard a pop and lights came on everywhere. The car ran, but when I stopped, it was smoking and wouldn't start. AAA towed it and said the water pump broke and took the serpentine belt with it, and I had it repaired there.
Car continued to to the "hesitation" thing, but I learned to live with it, until 4 weeks later it lost power and wouldn't go more than 5 miles an hour. Very dangerous! Also the check engine light came on - O2 sensor again. The original mechanic towed it back to his shop, has had it over a month. Say sometimes it runs fine and sometimes it really hesitates. My son took the plugs out and said they didn't look new and replaced them with best quality new plugs (mechanic said the plugs looked worn due to problems reported).
He's been a mechanic his whole career and still can't find out the problem. He checked the MAF and said it's fine. I can't afford to put more money into it, but it's worth nothing but junk value now after putting over $1000 into it. I didn't have these issues before I took it to him in January. He has a good reputation, but I don't know what gives.
Is this all a coincidence that it happened at once? What could have happened?
Toyota :: 1986 - Engine Always Dying While Slowing Down / Turning / Stopping At Red Light?
Issues with my '86 Toyota MR2... So, I just recently bought this car earlier this year and it's always seemed to be giving me problems. One of the major ones is that the engine is always dying. When it first did this a couple times after I bought it, my dad and I assumed it was the alternator(we figured it couldn't be the battery because the battery that was in it was relatively new, but we took it to Auto Zone to check the volts on it anyways, and it was all good; we did get the alternator checked also and the guy said it was the alternator), so, we bought a new alternator and my dad and I replaced it. About a week or two later, it started back up with the issue. Whether I was stopped at a red light, slowing down, or making a turn, the engine would die. So, whenever I'm at a red light, I'll put the E-brakes on or put the car in neutral and just get the RPMs up, but shortly after I rev it up, it'll stall. And I try pushing the clutch in all the way, majority of the time, it doesn't make a difference and dies anyway.
View 19 RepliesAlero :: 2001 2.4L - Hesitation On Acceleration After Stopping
My 01 alero 2.4l has some hesitation at takeoff, i have changed the plugs, boots, and fuel filter, and used fuel system cleaner. What could be causing this?
View 1 RepliesHonda - Accord :: 2002 - Transmission Slips Intermittently When Start After Stopping At A Red Light
I have a 2002 Honda Accord SE Sedan. 119K miles. The transmission slips sometimes especially when I start after stopping at a red light. My mechanic recommended not to change the transmission fluid as the transmission can go down and might need a new transmission. He also told me that 2002 Honda Accords are known for this issue.
So my question: Is my mechanic right? Or should I go ahead and flush the transmission fluid and replace it?
Toyota - Corolla :: 2010 Toyota - Engine Light On And VSC Off Light Flashing
I own a 2010 Toyota Corolla S the 1.8L 2ZR-FE engine. Today after work I started the car in a sheltered car garage and as soon as I started the car the after the initial start up sequence the check engine light stayed on and the traction control light stayed on and right next to it on the left side the "VSC Off" light kept blinking and flashing. I turned off the car and started it several times to see if that did anything and to no avail nothing happened.
While I was driving those lights stayed on and the VSC off light kept on blinking.
I also checked the brakes and the brake fluid and they all seem to be fine, I even checked the fuel door as well.
I am not sure what is wrong. I was looking at some of the complaint sites and most people say it happens when you drive through a deep puddle or if it is cold and wet outside. But that didn't make sense because I drove in the snow and those lights never turned on. The only time I used the ETS button is during the snow storms and I drive at low speeds.
I need to know why this VSC off light is blinking? Is it a bad sensor or is the ABS/ETS brake system broken or is it an ECU issue or is it because of an alignment. Since I was told to get an alignment soon.
See also: 2010 Toyota Corolla Question: Check engine light on and "VSC off" light blinking with the ETS light on.
Toyota - Corolla :: 2002 - RPM Fluctuations For A Few Seconds
My sister was driving my '02 Corolla (120K miles) this morning when the RPM's started to fluctuate between 1500-2500 for a few seconds. Did it on the highway (60 mph) and then again on a city street (45 MPH). Then back to normal. Had a tune up etc less than 2 months ago.
View 6 RepliesToyota - Camry :: Hesitation And Car Would Not Accelerate When Moving From Stop Light
I have a 1988 Toyota Camry. I was driving to work this morning, the car was driving fine. After about 10 mile or so, I stopped at a red light, when the light changed the car wouldn't accelerate it seemed to have a really bad hesitation. If i let off the gas it would idle fine, none of the warning lights are on. However, when I give it more gas the car doesn't have any power at all. It has plenty of gas in it and the exhaust has no signs of any oil or water in it. I was thinking it may be a bad fuel filter or a tank of bad gas.
View 6 RepliesToyota - Corolla :: 2002 Idles Fine But Bog Down On Acceleration
Just as the title says, 214k great shape just wont get going more you mash the less it goes.... fuel pump already replaced, can undo battery and take a while to reset feels to do fine then goes back to bogging down... TPS ? idle air control?
View 3 RepliesEngines :: CEL On For P0125 Code On 2002 Toyota Corolla
I have a 2002 Toyota Corolla. On a hot day (the first in a while), I got a check engine light for P0125. I'm going to clear it and see if it comes back. I think it is a false alarm for insufficient engine coolant. If the code and check engine light come back, what should I do?
View 10 RepliesToyota - Corolla :: 2002 - Ticking Valves At Past 50 MPH While Motor Is Unloaded?
I have a 2002 Toyota Corolla CE with 160,000 miles on the odometer. While driving at highway speeds (50+ mph), if I let off the gas ever-so-slightly, an audible ticking (like the sound of a sewing machine) begins. It immediately goes away as soon as the motor begins to decelerate or accelerate again. It ticks the loudest while the motor is directly in between accelerating and decelerating, while I am trying to maintain the speed I am traveling at. The sound started 6 months ago and was almost unnoticeable, but has gotten steadily louder the more I drive it. From what I have already researched, I believe it might the valve lifters needing to be changed, but wanted to get a second opinion.
View 2 RepliesCorolla :: 2002 Toyota Wagon - Transmission Fluid Of Automatic Gearbox Overfilled
I've recently bought a 2002 toyota corolla wagon. I noticed the transmission fluid of the automatic gearbox has been overfilled. This measurement was with a cold and switched off engine and on a level ground. Is this something I should be concerned about and can it cause damage? Should I have it drained to the normal level or is it ok to keep it this way? I didn't come with a manual so I'm not sure if i measured correctly.
View 1 RepliesToyota - Corolla :: 2002 - Error Codes P0171 / 0420 / 0441 And Excessive Oil Consumption
Actually I bought a used Corolla 2002 with 120K which seemed fine and the driving is fine. After I bought it, I just found out that the seller has removed the check engine light. When I read the ODB codes, It shows three codes of 0171, 0420, 0441. Also I have recently found out that the engine burns excessive amount of oil. (about a quarter per 200 miles). Actually the driving of the car is fine and as long as I add oil engine it seems fine.I think all of these errors might be just due to a small problem like a broken valve (since it's not high mileage). It seems that there is no vacuum leak from hoses as well.
View 8 RepliesToyota - Corolla :: SRS Light Came On For The Airbags
So I am not sure if this is coincidence or not but... I just got done adding new stuff to my stereo in my 2006 Corolla Xrs. In the process the SRS light came on for the airbags. I took it to the dealer and was told it was the seat belt pretentioner. The dealer told me to check and make sure I did not hit any of the wiring when adding my stuff. I checked no wires or anything were cut that I can see. So, How do I fix this and what exactly does the seat belt pretentioner do?
View 13 RepliesToyota - Corolla :: Getting Check Engine Light?
This is a California car that won't pass smog tests with a lit check engine light. I don't know the specific code, but the description is that the torque converter is staying in the "off" position. Apparently the lock up torque converter is part of the emissions system in that if the torque converter does not lock up then the rpm's are higher and that produces more pollutants.
1st step was to flush out the transmission and the flush made sure all the fluid in the torque converter was removed and replaced. After that was done the trans fluid has stayed nice and clean and pink for about 400 miles. The CEL was turned off after this service but came back on in a few days at about 200 miles. Next, the solenoid that activates the torque converter was replaced. The CEL was turned off again, an this time the CEL came back on after a hour of driving on local errands.
Me and my generally good mechanic are hung up now. We were betting the solenoid change out would solve the problem. It seems that the torque converter is in fact operating properly. The tranny shifts smoothly and the rpm's drop at the proper times indicating the torque converter is locking up.
Toyota - Corolla :: Check Engine Light Came On A Day After Getting Gas
At a service station in NJ, my gas cap flew into the wind and the attendant replaced it. My check engine light came on a day after getting gas (not in NJ) so I took it in to my garage. Ends up that the (new) gas cap has a crack and a new one is getting ordered. Now, whenever I am filling up the gas tank, it keeps shutting itself off (very frequently . . . like every 1/2 gallon or so). This happened when the check engine light was on and after it was initially turned off by the mechanic. I asked a mechanic at the garage because it keeps happening and I can't fill the car fully and he said it happens with some cars and you have to hold it a certain way or something. This can't be fixed and I'll just have to get used to it until I get a new car. My question -- how could this have just started happening? Its a 2002 Corolla and I've had it for years without problems. Is it possible that when I get a new gas cap and the computer gets re-started, it will fix itself?
View 6 Replies