Ford Super Duty (1999-2016) :: Intermittent Stall When Driving / Won't Start For 30 Minutes
I've been having an intermittent stall-out problem with my 2003 F250 5.4L (160k miles). The truck has been retired from DD to farm duty, hauling, and towing only. Over the past 9 months, the truck has stalled-out on me 3x while driving. I will be driving along sometimes at highway speed, sometime slower, and everything will die: no PS, lights go on all over the dashboard. It will not restart right away. I have to wait at least 20-30min to restart it and then everything is fine for several weeks and hundreds of miles.
There are no codes and I have been unable for reproduce it/cause it to happen purposely. My mechanic has changed the Crankshaft Position Sensor, and checked the fuel rail pressures. I also checked all the harnesses and fuses, cleaned the battery terminals, looked for vacuum leaks, and gave it a good look-over. The following are new: battery, IAC valve, fuel filter. After searching the forum I also pulled the fuse box and examined the integral fuel pump relay: it and the board looked perfect, no bulges, cracks, discoloration, etc.
My mechanic thinks this is more likely an ignition problem than a fuel delivery problem.
Golf IV / Jetta IV :: After Driving For 20 Minutes And Sitting In Driveway VR6 Start Running Hot
This only happens once or twice a week. After driving the car for 20+ minutes and sitting in the driveway, it will start running hot. I'd say around 230 degrees and it will stay there until I start driving the car again. I made sure the fans work and I also checked the coolant level and both are fine. What could be causing this issue?
View 2 RepliesGolf IV / Jetta IV :: 2000 GLS Run Fine For 10 Minutes Then Will Stall - ECU Replacement
I took my 2000 Jetta GLS 2.0 5 speed it a certified mechanic shop that I have used before. This scan show a speed sensor (which I already replaced) and the ECU. He said that the ECU is discontinued and that he could not do the repair.
The car will run fine for 10 minutes then will stall, wait 5 minutes and it will run again for 5-10 minutes stall and repeat the process. Question, what is involved with swapping the ECU with an identical numbered one from a junk yard? Also could swapping out my headlight assembly have any effect, this started to happen shortly after the new headlights were installed.
Chevrolet - Aveo :: 2004 - Bog Down And Stall While Driving On Expressway After About 20 Minutes
I have been to 3 mechanics including the dealer and no one can re-create my problem. While driving on the expressway at speeds of 60-70 mph after about 20 minutes the car will start to bog down and then stall. It will start right back up but then you can only go a mile or less and it will do it again. It has to sit for 20-30 minutes before it will go a longer distance. This is a daily event since we drive the car to work on the expressway and, of course, it takes 30 minutes to get there. What I have done: replaced the ignition coils (no change) replaced the fuel pump/filter (no change) replaced the throttle body (this fixed the problem for about a month or two. I had to buy a used throttle body because I could not find a new one) In any case if the problem is the throttle body what is making it go bad?
View 1 RepliesDodge - Omni :: 1988 - Engine Will Stall Out Within The First 10 Minutes Of Driving
I have a 1988 Omni, so a 2.2 non-turbo with TBI. Within the first 10 minutes of driving, regardless of the amount of fuel in the tank, the engine will stall out. Throttle position does not matter - it stalls the same way under full throttle as it does idling. It always starts back up on the 2nd or 3rd try immediately after stalling, and runs perfectly. When it stalls, it's as if someone actually shut the ignition switch off - the motor completely shuts off without sputtering or running rough. All of the other electronics seem to be unaffected (for example, the radio and lights still work during the motor drama).
It may do this 3 or 4 times in the course of 5 minutes. After the engine is up to operating temp, the problem disappears entirely and only resurfaces whenever the car has had a chance to cool back off.
I thought it was the coil, but replaced that with no effect. I also recently did plugs and wires (2 months ago, long before this issue surfaces). I just remove the air intake assembly and watched the fuel injector. It ran perfectly normally for about 10 minutes again and then I saw the injector suddenly stop spraying, and the engine stalled instantly. The injector seemed to be working fine before the stall and worked fine again after I restarted. No weird noises or anything.
What this could be? ECU, maybe? Something specific in the throttle body assembly or fuel system? The little car is in great shape otherwise, and I drive it 100 miles every day to work and back to keep miles down on the newer thirstier car.
Infiniti - Qx56 :: Hard To Accelerate And Car Seems To Stall After About 5 Minutes Of Driving
All of the lights that show up when starting the car are coming on when I am driving. After about 5 minutes of driving, it is hard to accelerate and the car seems to stall (like I am trying to change gears - it is automatic). The first time it happened, I took the car to a repair shop and they told me I had a leaking hose and needed a new alternator. I had them change the hose and took the car to my usual mechanic. After two days of driving my car, he could not reproduce the problem and said he didn't think the alternator needed to be changed. I started driving the car today and it happened again. When I got home and turned the car off, it would not restart.
View 6 RepliesEclipse - Mitsubishi :: 1998 - After About 20 - 30 Minutes Of Driving Fuel Pump Overheat And Car Will Stall
We will start with the history. I recently purchased this car knowing of a long list of issues which have been worked out for the most part. The related piece would be random misfires which I believed were based on a faulty Ignition Coil (common on this 420a [2.0 NA] motor.) I have replace the coil but the issue persists.
Now what is happening is after about 20-30 minutes (or miles) of driving the fuel pump will overheat and the car will stall. I can get it to turn back over most of the time but it will stall out if attempting to drive. I have to leave it sitting for about 15 minutes to be able to move it.
What codes am I getting from the CEL? Nothing. (No CEL)What have I tried so far? - Fuel pump has been replaced- Fuel filter has been replaced- Fuel lines have been verified (no noticeable leaks, unwanted bends, pinches or breaks)(I also verified that this is not an issue with the PCV valve or EGR [electric in this car] valve)
I know... I thought relay or wiring also - but all lines and the relay are cool to the touch so they are not overheating. 1998 Eclipse GS....
Volkswagen - Jetta :: 99.5 - Vehicle Starts But Stalls Within 10 Minutes
So, I recently bought a 99.5 Jetta. (99 with a 00 body), fixes a few things. Alternator, oil pan, head gasket. I recently drove the car just up the road, drove it back. Went to pull in to my spot and it shut off! Wouldn't start but would crank over. Days go by, same problem. Runs for about 10 minutes then just dies. Fuel pump works, fuel filter isn't clogged. And the fuel relay works.
View 1 RepliesVolkswagen - Jetta :: 2013 - Stalls While At Idle After About 5 Minutes
I was at the pump getting gas. Left the engine running. Put in gas. Put the cap back. Checked to make sure it was tight. Got back in the car to find that the engine had stalled. I thought maybe just a fluke. Then it happened again a few days later. Same situation. Last night I was sitting at idle (not at the filling station) and same thing. The engine is not running rough --nor is the idle. I seems to take around 5 minutes or so before stalling. It starts right back up no problem. I had a dealer tune-up about 2 months ago. Replaced spark plugs, plug wires, coil, PCV valve, etc. It cost a small fortune. Why this is happening? 2013 VW Jetta 2.0 ....
View 10 RepliesHonda - Accord :: 1989 - Stalls After A Few Minutes Of Driving
My 1989 Honda Accord LX, with 135,000 miles on it, stalls after a few minutes of driving. Then, after re-starting, it stalls before I even have a chance to put it into drive. My mechanic replaced an electric base plate gasket in the carburetor but warned me that this repair might not fix the problem. If it didn't, I probably would need to replace the carburetor -- if one could be found for a 1989 model. Well, I still have the problem. My question: Is it worth it to invest $1,500, more or less, for a carburetor for a 22-year-old car? I've been using it strictly as a second car for the last 11 or 12 years. It seems to be in good shape otherwise.
View 2 RepliesSebring - Chrysler :: 1998 V6 Stalls After 10 Minutes Of Driving At 30 Mph
I have a 98 Sebring Convertible 2.5L V6 that stalls after 10 minutes of driving at 30mph or even at highway speeds (ouch), but it seems only if the car has been sitting parked for 5 days will the stall occur. If I drive it daily/every other day, she seems to run just fine. Somewhere in between 2 and 5 days, there is sometimes a surge at that distance, but not a complete stall. The stall has been a very specific distance that if I let the car sit for 5 days, I can essentially pull over in anticipation of the stall. When the car stalls, the dash gauges all go to 0 and lose all power steering, but headlights stay on. Otherwise, there's been no noticeable loss of power, rough idle or anything else to indicate a problem. There are no codes on the computer. The stall happens once. I can pull over and immediately restart my car and be on my way without experiencing another problem until I let the car sit for 5 days again.
View 2 RepliesBuick - Regal :: 1996 Stalls After Driving About 10 Minutes
My 96 Buick Regal acts like it is out of gas after driving for about 10 min. Takes awhile to start, then runs rough if at all. After it sits, it runs fine again for about 10 min. I changed fuel filter, fuel pressure sensor and fuel pressure regulator.
View 4 RepliesAccent LC (2000-05) :: 2001 Car Will Start And After 1 - 2 Minutes Violently Shakes Then Stall
My 2001 Accent doesn't give me any power when its cold in fact when I try starting it when its cold, the car will start and then after 1-2 min would violently (may be that's a little too strong a word to describe it) shake and then stall. This happens about 1-2 times and then the car finally starts.
If I drive my car uphill (not a very big), after heating it up, car would just start moving along slowly (or stall) even on the first gear and full gas. And sometimes while driving the car loses all power. It just trudges along no matter how much gas I press,
I no nothing about cars, so I am not sure if I conveyed my problem correctly. I just hope that the problem is fixable and wont cost me my entire salary to fix.
P.S: I always thought that the problem was me and that I couldn't drive a manual. Today a friend of the mine, who has been driving manual for 20 years also had the same trouble.
Ford - Gasoline - Thunderbird :: Stalls And Dies After A Few Minutes Of Driving
I have a "56 thunderbird with a mid-60"s ford 390 engine w/ 4 bbl holley. I just had engine completely rebuilt and everything else is new: carb, distributor, electric fuel pump, fuel tank, etc.
Problem: car stalls and dies after a few minutes of driving. Generally restarts after waiting about a half hour, but not always. I have a fuel filter with clear bowl in fuel line just ahead of carb. The bowl is usually about 2/3 full of fuel, but general appears empty when the car stalls.
After waiting a while, the bowl refills and the car restarts.
Chevrolet - Venture :: 2001 - Stalls After Driving It Approximately 15 Minutes
My 2001 Chevy Venture stalls after driving it approximately 15 minutes and won't start for about 20-30 minutes, then same problem occurs. I've had the following parts replaced to date, with no success.
AIR FILTER
ENGINE CONTROL SYSTEM
IGNITION MODULE
FUEL PUMP AND WIRING
Honda - Accord :: Stalls While Driving Then Takes Couple Of Minutes To Turn Over
1999 Accord, 110k mi., stalls while driving or stopped a few times a week, then takes a couple of minutes to turn over. Mechanic replaced or cleaned main relay, fuel pump, and ignition module. Could sell it but recently rebuilt tranny and replaced timing belt. Mechanic is stumped.
View 7 RepliesOldsmobile - Cutlass :: 1992 Stalls After 20 To 30 Minutes Of Driving When Stopped For A Light
Have a '92 Olds Cutlass Ciera 6 cyl 3300 engine. After 20-30 mins of driving it dies when I have to stop for a light. Depressing the brake kills the engine. Starts right up after but as soon as I put it in drive, it dies. If the car sits for 20 mins or so after problem begins it's okay. If I get to an intersection and have to stop, I put it in neutral. When I have to go again I rev the engine, let it die down some and then put it in drive (hard on the car, I know, but it's only way to get going again. Once I'm moving, I can accelerate and it's okay. What is wrong with my car?
View 3 RepliesFord F-150 (2009-2014) :: 2010 Stalls While Driving And Won't Restart For 5 To 10 Minutes
I have a 2010 F150 SCREW with 4.6l 3v 4wd. Up to 100,000 miles nothing more than tires, brakes, and evap purge valve (50,000 miles). Check engine light came on right around 100,000 miles and had no driving problems other than some crappy fuel mileage. Did the following:
Changed evap purge valve, reset cpu by unplugging. CEL came back on after about 200 miles
Took the truck to a shop to get oil change, change plugs, diff fluids, transfer case fluid and get CEL looked at. Shop recommended changing intake gasket as you could see gummy type fluid on passenger side valve cover. When removing the intake found the intake cracked, changed gasket and intake. They reset the light. 200 to 250 miles later the CEL came back on.
Took it back to the same shop, left it with them for the weekend. they think it could be the O2 sensors. I went out and got the shop all 4 O2 sensors and they installed for free (seeing as I spent $2500 with them for all the previous weekends work) 200 to 250 miles CEL came back on
Determined to find time to have another shop look at the problem and trying to get it to a family friend, wasted about a month. At the end of February stopped at a friends house after being there for 20 minutes tried to start truck, it wouldn't fire. It would crank but no fire. Called for a tow and while waiting tried to crank the truck and it fired up, like nothing was wrong. Cancelled the tow truck and drove right to dealership. They determined it was the MAF sensor. Spent the $500 to have them diagnose and change MAF. All things good for about a month and about 3000 miles...
Now in the past 2 weeks it has done the following: I am a construction manager so i am in and out of my truck all day so the engine is never really a cold start except for the mornings when driving to work, it stalled while leaving work on a Friday at low speed. luckily I was able to pull in to a gas station. Tried to restart and it cranked but no fire. after 5 minutes or so tried again, fired up drove home the 35 miles with no problem, truck had power, smooth idle. No CEL.
Same weekend on Sunday, coming home from church at highway speed truck got sluggish, wrench light came on, no response to throttle. Rolled to a stop and then the oil light came on and chime from dash. Turned the key all the way off waited 10 seconds, again crank but no start. Waited 5 minutes and it fired up no problem. Church is only 3 or 4 miles away, no problem going to church, 2 miles into the trip home is when it stalled.
Drove all week, 500 plus miles without a stall or problem
Coming home on Saturday from my kids soccer game again 4 or 5 miles away (no problem going to game) truck stalled at highway speed. Coast to a stop, wrench comes on and then oil light, chimes from dash. Turn key off, wrench and oil light do not come back on. Try to start, again crank but no fire. waited the 5 minutes or so and it fired up fine. (Earlier in the day i got gas, 87 octane, from a one of my regular gas stations from 1/4 tank to full)
Today coming home from church but running an errant the truck stalls after making a left turn about 3 miles from the church at low speed.
All of this without a CEL. What can solve this problem. Clean a sensor? clean throttle body? Gas tank additives? I am due for an oil change and may ask the dealer to look at it but its going to be time consuming as I cant radially repeat the problem and there is no CEL. As I am thinking about the different times it stalled, other than the first time I was probably around 1900 to 2300 rpm.
Ford Fuel System :: Truck Starts Choking And Stalls After 10 Minutes Or So Of Driving
My truck starts and runs fine cold. after 10 minutes or so of driving, it starts choking and stalls. If you try to start it, it will not. If you wait about 3 minutes, it is fine, starts , and drives ok, for about 3 minutes. I have replaced, plugs, fuel filter, battery, and a ignition module, as well as cleaned the opening of the throttle body
Ford has ordered a fuel pump, I am thinking it could be the
-Throttle position Sensor?
-MAF sensor?
-fuel pump?
It puts out code p0191 for low fuel pressure. Ford is scheduled to install new pump in am, but I don't want to spend a grand if it is just the TPS or MAf?