Mini - Cooper :: 2005 - Transmission Failure / Three Oil Leaks
My 2005 Mini Cooper, manual transmission, has 82K miles. About a month ago, I noticed a loud sound coming from the engine when at speeds above 60mph. Over the next few weeks, the noise started happening at lower speeds as well, 30mph and up. Took it to the dealership and was informed that I needed a new transmission, which came as a great shock to me. Quote to replace is $3,600.
I took it to a transmission specialist for a second opinion. He determined that it likely was the differential causing the issue but that this couldn't be purchased alone as Mini will only sell the entire transmission, not specific parts for it.
Along with the transmission, the dealership also said that I have three oil leaks, need the water pump replaced, air conditioner recharged, control arm bushings and rear breaks replaced. Plus some misc work adding up to $6,500, which includes the new transmission.
Ford 7.3L Power Stroke (1999-2003) :: Code P0670 - GPCM Glow Plug Control Module Control Line Failure
How to fix SES P0670?? I understand there's a whole procedure on checking fault.
P0670:GPCM Glow plug control module control line failure. Open/grounded circuit, open/shorted GPCM, failed PCM
But how did you resolve problem? replaced GPCM, found open circuit, short --if so where?-- or replaced with updated harness.
(4C3Z-12B568-AA connector upgrade kit as in picture)???
Mini - Cooper :: 2004 - Clutch Gone Bad
The clutch went out and the repair people tell me to replace the master cylinder, the slave cylinder and other related components to the tune.
View 12 RepliesMini - Cooper :: RPMs Spike Rapidly From 3K To 4K
In the past month or so I've noticed some weird behavior out of my car. 2006 Mini Cooper 130K miles on it (still going strong!!) Automatic.
Scenario 1 - Driving in D accelerating at a normal pace (read, not gunning it) the RPM's spike rapidly from 3K to 4K and the car almost sounds like it's redlining. Once it hits 59-60 MPH it drops back down to 3K RPM and the rest of the acceleration is normal.
Scenario 2 - Cruising on the highway at about 70+. Normally start taking the foot off the gas to slow down with traffic and when my speed drops to about 60 MPH the RPMs spike again from around 3K to about 4K. When the car gets below 60 MPH the RPMs drop again. If i let the car come to a stop the RPMs decrease normally without any other spikes.
Scenario 3 - Driving in sport mode (yeah buddy) around 20-30MPH it almost feels like the car is not upshifting and the rpms go crazy. jump from 2500 to about 4-4500 and finally the car lurks forward.
Mini - Cooper :: 2009 Started Misfiring
How to repair a 2009 mini cooper that started misfiring? What is the most common cause for misfiring?
View 19 RepliesMini - Cooper :: 2002 - Overheats After Running A Bit
My 2002 Mini Cooper has been a faithful trooper since we bought it in 2002. It has carried me around at track days embarrassing faster cars at the track (pretty much anything else that shows up at a track day) due to its handling, picked up the groceries, and ferried the kids to countless activities in the last 12 years. It has just about 90K miles. Since this spring it has been giving the impression that is overheating after running for as little as 15 minutes. We've changed the thermostat, radiator and had the head off to replace the gasket and check it for warping.
We've also bled the system thinking it could be air trapped somewhere. My mechanic says that it isn't actually overheating - there is no fluid boil and it isn't using any coolant up. There are no leaks. He thinks it could be a bad gauge. I called MiniMania and they agreed that it is not overheating really and suggested that it is an electrical issue. They doubted it is the gauge and suggested running the engine at idle with the radiator cap off so I could check the temperature of the coolant with a thermometer as the temperature gauge did its thing moving into the red.
Mini - Cooper :: 2006 - Shaking In 1st Gear?
We have a 2006 Mini Cooper Cabrio with 55K miles. The car is a lot of fun, but lately I've run into a problem: when starting movement and engaging first gear, as I release the clutch and engage the engine - the car/engine shakes briefly. Sometimes just a little bit, sometimes quite severely, but always noticeable and resonating through the car. This happens when you apply very little gas (less noticeably) and when you give considerably more gas (shakes a lot more and when it engages - gives an abrupt kick).
This also happens in the second gear, but not to the same degree. Today this happened every time i've shifted into first or second and i'm getting worried that we are in for some expensive repair on a fairly low mileage car.
I'm not new to manual transmission and have learned to drive on a car with a stick. I've been behind the wheel for 20 years with driving manual on and off for at least half the time.
Mini - Cooper :: 2005 - SES Light On All The Time
I just bought a 2005 Mini Cooper with the SES light on. Error message said misfired piston, so got a tune up and an ignition coil. Went off for about a day and back on. Put fuel injector cleaner in. Went off for a day and back on. What to do? In this for several hundred bucks thus far.
View 5 RepliesMini - Cooper :: 2006 - Noise While In Gear
I have 26,000 miles on my 2006 Mini convertible manual transmission. It started making noise while in gear. Took in to my mechanic and he says there is metal in the transmission fluid and that the metal around the ball bearings has failed and that, if he can't repair it, I'll need a new transmission for about 6500.00 Is this a common problem and do I have any recourse with Mini? I am the original owner of the car, but, of course, it's no longer in warranty.
View 2 RepliesMini - Cooper :: Smelly Air Conditioner When First Turned On?
Why does the ac smell like dirty feet when I first turn it on?
View 3 RepliesTouareg :: Airbag Fault Code / ABS Control Module
I recently received an airbag fault light so I figured that I would scan the module for error codes. This is what I came up with:
Control Module Part Number: 3D0 909 601 C
Component and/or Version: 05 Airbag 8.4E++H01 0352
Software Coding: 0012341
Work Shop Code: WSC 31414
Additional Info: 7L0959339B BF-Gewichtsens. 005 0006
Additional Info: Geraet 00000
2 Faults Found:
01217 - Side Airbag Igniter: Driver Side (N199)
001 - Upper Limit Exceeded - Intermittent
01316 - ABS Control Module
004 - No Signal/Communication - Intermittent
Has scanned the car while had the airbag fault present and if so, is this the usual harness that needs to be changed?
Golf/GTI VI :: 2010 - Airbag Control Module Coding
Need coding info for 2010 Jetta sedan 2.5 Air bag control module. The part # is 1K0 909 605 AD/004, Component # Airbag VW8R 036 8900. I am using a Vag-Com version 10.6 ....
View 1 RepliesDodge - Grandcaravan :: Repeated Failure Of Transmission Control Module
In 13 months my 1991 Dodge Grand Caravan has managed to kill 4 transmission control modules -- the original plus three factory replacements. The first replacement (by a Dodge garage) failed within weeks, after which they threw up their hands in despair (never recognizing the defective part) and sent me to an electrical specialist. The specialist's first replacement survived until April; their 2nd has just died. I find it hard to accept that all of these TCMs were simply defective.
View 4 RepliesMini - Cooper :: 2008 - Crack In Rear Bumper
I'm in the process of buying a used 2008 Mini Cooper S with 44000 miles in good conditions but I wanted to get an opinion regarding a rear bumper crack. Please take a look at the attached photo and tell me what you think, not sure how serious it is or how much it will cost me to fix so I can negotiate the price.
View 7 RepliesMini - Cooper :: 2011 - Oil Change Warning Light
I am considering buying a 2011 Mini Cooper. One of the issues I'm wondering about is that I have been told that the Oil Change Warning Light has to be re-set by a dealership. I don't need the light because I always change oil at 3 K regardless of what thing says, but I don't want to have to pay the dealer to re-set an annoying light. Right now I'm driving an '06 Civic and I can reset that myself (it's not a light, just shows percentage of usage).
The other issue, b/t/w is what to do about a spare tire since I don't plan to pay for new run-flats.
Mini - Cooper :: Second Gear Synchro Grind Only When Turning Right
Just within the last 1000 miles my MINI has been randomly grinding into second gear (6 Speed Getrag Manual for the Cooper S) when turning right. It is a little notchy when traveling straight and beautifully smooth when turning left. When pulling out of my garage the other morning I went into second but purposely pulled the gear stick towards the right side of the gate and it did the same grinding thing that it does when going around right hand turns. It seems as though something is out of alignment? It feels like the shift linkage is not properly placing the internals of the transmission. It happens mostly when cold and once warm the random harsh grinding stops and it goes to simply really notchy.
View 12 RepliesMini - Cooper :: 2003 - How To Clean Interior Blower Fan
I have a 2003 Mini Cooper, and I'm having issues with the cabin blower fan. When it is cold outside, the fan works, but when it is hot outside, the fan doesn't work. It turns out, if I reach into the cabin airbox and give it a boost, it will start spinning again.
My guess is that the grease is old and junked up in there, and so when it is hot, it gets sticky and seizes up the motor. The main problem is on this year, the interior blower motor is only removable by taking the dash off and it is a big pain.
I want to ask if there are any recommended sprays or cleaners I can use on it without having to remove the dash. From the cabin filter airbox I can reach right into the fan's axle.
Mini - Cooper :: 2002 - Frozen Stick Shift?
My 2002 mini 6-speed stick licks to get stuck in the I park it in when its cold. After driving in that gear for 4 minutes it warms up and let's loose.
View 2 RepliesMini - Cooper :: 2005 - Service Engine Soon Light Came On
OK, so my "Service Engine Soon" light came on recently. I tried the gas cap tightening suggestion. It turned off. A few miles down the road it came on again. I had a recall/service schedule (2005 model) so waited until I took it in, however the light turned off (again) before I went in. They did a whole service and (I believe) diagnostic and nothing came up. That was about a month ago and suddenly the morning the light came on again. I have some repairs/maintenance scheduled for end of July (gasket value leak and the right side the axles). The car is driving fine, no difference in feel/sounds.
View 14 Replies