Ford 7.3L Power Stroke (1999-2003) :: Flasher Relay Constantly Clicking
Had a weird issue come up this weekend. I went to drive my truck for the first time in a couple of weeks and when I got in I noticed a constant clicking from under the dash (whether the truck was on, off or if the indicators / hazard lights were on or off). I investigated and found it was my flasher relay. I have replaced this relay recently (within the past year) to an EP27L to accommodate the LED lighting I installed throughout the truck (hyper flash on the old relay doesn't even describe it properly, it was a constant buzz!) and it has been working perfectly until this point.
I thought it may just be something going on with the relay so I pulled it and replaced with the old EP27 unit I still had. It does the same thing, albeit at a slower rate (every 4-5 seconds). The lights do not blink when it is doing this, but still operate normally when I move my stalk up or down or when I press the hazard / flasher button on top of the steering column.
I am wondering if there is a short somewhere in my multifunction switch that is causing this issue? If so, why would it come up when truck has been sat? I didn't have the time, not the inclination to roll around inside my truck (hotter than hades here in Florida right now) to troubleshoot any further. I pulled the relay altogether until I get some time and cooler weather to look into it further. Otherwise the truck seems to operate as normal, even all the lighting seems to have no ill effects from this?
Mercury - Sable :: 1997 - Speedometer Stopped Working?
my mercury sable had a leak in the lower intake manifold, so I got on it and finished it last saturday, on monday I was on my way home when I stopped to turn on my road and my speedometer just stopped working, it dropped to 0mph, what can I do to fix it?
View 3 RepliesMercury - Sable :: 2003 - AC Stops Then Starts Working
2003 Merc. SABLE. AC works great for 1/2 hour on the highway. Then No cool air. We shut it off. An hour later and 70 miles down the road , it works again. Always cold air.. no matter where you set temp. 4 times to 3 mechanics. No one can solve it.
View 2 RepliesCamry :: 1997 - Relay Control Clicking Constantly?
This relay is clicking about once a second, and the car won't start (it doesn't even turn over). Disconnecting and reconnecting the battery doesn't seem to have an effect, but I did notice that it seems to stop for a few seconds when I open the door. What's going on?
View 3 RepliesMercury - Sable :: Blower For AC / Heater And Defrost Stopped Working
The blower for the a/c and heater, defrost stopped working. would work sometimes, now doesn't work at all.
View 2 RepliesMercury - Sable :: 2001 - Suddenly Lost A Lot Of Power And Won't Go Fast At All - Bad Converter
I have a 2001 Mercury Sable with 114k miles. Just bought it and it ran fine for the most part until one day while coming home from work. It was still running but lost a lot of power and wouldn't go fast at all. I took it to my mechanic and he told me that this car has 3 converters on the exhaust system. First of all, I think having 3 is overkill and secondly, I am wondering why these things are so expensive. The one up front that mounts to my manifold is $350 just for the part. The one in the back can be bypassed (legally) but why did they make this system so complex and what are my options at this point? If I found a Sable that was being parted out, could I use the converters from that? Would it have to be the same year?
View 15 RepliesMercury - Sable :: 2000 - Power Loss / Engine Skipping And Catching Then Die
This first started happening about a year ago. started the car and it seemed fine to put it in gear to drive stepped on the gas and there was no power. the car moved forward slowly and felt like the engine was skipping and catching and then it would die. took it to the shop and it started right up first try for them. they drove it and it was fine. ever since then, it happens at random times on and off. I'm not sure if its bad fuel or something it just doesn't make sense to me.
View 8 RepliesMercury - Sable - Transmissions :: 2004 - Zero Engine Power Reaching To Tires In Any Gear
My wife's 2004 Mercury Sable broke down on the highway last night. We had it towed to the nearest Ford Dealership and are awaiting the official diagnosis. I am 99% sure it is transmission, as the engine didn't die, but zero of engines power is reaching tires in any gear.
View 4 RepliesMercury - Sable :: A/C Only Blows Warm Air
I recently acquired a 2003 Mercury Sable from a friend and there is a problem with the air conditioning. The car has digital controls. I select the Max AC button, turn the temperature all the way down (60) an the fan all the way up, but it only blows warm air. I can hear and see the AC compressor cycling fairly quickly. The clutch (I think) engages for about one second and it will reengage after about 5 seconds, but again, it only says engaged for about one second.
What could be the problem? I've read the AC system might not have enough pressure and needs to be recharged. Or... the orifice tube is clogged, bad AC pressure switch, or the actuator that closes the heater door might be disconnected.
How quickly should a properly functions AC compressor cycle? The car was not driven much over the past year or two as it was my friend's grandfathers. I may end up taking it to a shop but I don't want to get ripped off. How should I approach this?
Mercury :: Sable 2002 Always Stalls Out At Lights
Got a 2002 mercury Sable.. Always stalls out at lights.. Won't idle will stall if you don't give it gas... Also gas pedal cable broke and a spring is broke too.. What might be wrong with engine.
View 2 RepliesMercury - Sable :: 2001 - Won't Start Smoothly
i have a 2001 mercury sable what im getting is its will not start but starts on occasion like today it started fine this morning did errands before work drove it turned it off short period and then started just fine and then drove to work after work it did not want to start tried every thing check engine light is not on and has not come on im am getting stumped i had to leave it in the parking lot at my work so my question is what could make it do this where it starts on occasion and then when sitting for a period of time will not start it cranks but just does not start
View 2 RepliesMercury - Sable :: 1999 V6 Occasionally Will Not Start
I have a '99 Mercury Sable with the 3.0 24 Valve DOHC V6. The car occasionally will not start. It only happens after the car has been driven and warmed up, shut off, and then an attempted restart. This problem has occurred in all sorts of temps. Sometimes it will start within 30 minutes, sometimes it takes overnight. But it will start. I have already replaced the fuel pump relay. Is the fuel pump needing to be replaced (b/c it is failing slowly), or is this problem located somewhere else?
View 12 RepliesMercury - Sable :: 1996 - New Battery But Car Won't Turn Over
Bought this car, drove it home, when I went to restart it nothing happened. Put in a new battery and still nothing. The starter will arc with a screwdriver but not engage. All the lights and and electrical work so I am thinking its either the neutral safety or the ignition. Is there a way to figure out which one it is with out buying both of them?
View 4 RepliesMercury - Sable :: 1992 - Continues To Run After Key Removed?
92 mercury sable 3.8so the car just started this on the 4th. it not able to turn off, switch the key to off pull it out car keeps running, been pulling the battery cable, but was told I'd hurt my alternator if kept doing it that way. just trying to fix it, so I tired switching out the ignition cylinder. that didn't fix it and also checked all my fuses they were all fine. My next idea is to change out the whole ignition switch instead of just the cylinder.
Now the second problem that i was trying to nail down before the other started was a issue with the car stalling at idle. it only happens if the car is up to temperature and it's a hot day. plus 75 Fahrenheit. just trying to go with cheapest parts and work my way up i change the air and fuel filters. then this other issue started and took priority.
Mercury - Sable :: 2000 - Starts But Doesn't Run?
A month ago I was pulling onto Hwy 5 and the car stalled. I pulled over and restarted the car - no prob. But, the check engine light came on. I took it to the shop and they said that the check engine light code said there was a problem with the fuel pump. Unfortunately they couldn't find anything wrong with the pump. They reset the check engine light and it didn't come back on and the car ran fine...until Sunday.
On Sunday, I tried to start the car. It would start but only ran for a second or two and then shut down. I took it back to the shop thinking it was the fuel pump failing but they say the fuel pump seems ok, they've replaced the fuel filter but it still won't start. They seem to flummoxed. What might be going on?
Mercury - Sable :: RPMs Went Up To 3K And Speed Dropped To 15 Mph
I recently purchased a 2004 Mercury Sable with about 112K miles on it. I am having some troubles with my car and I'm not sure where to start first in repairing it. I recently took my car to a mechanic because accelerating on the highway or going up hills made my car sound engine run very hard and loud, my RPMs went up to 3K and my speed dropped to 15 mph (which is a disaster when you're on the highway and hit a steep grade). My car absolutely cannot do any sort of hill so the mechanic suggested that either he or I replace one of the catalytic converters. He showed me which one he thought was throwing the error code. I replaced that catalytic converter and I thought my problems were solved because I could accelerate without difficulty.
However, a day later I tried to drive it up a hill and got the exact same response as before. RPMS jump up and the speed drops down to 15 mph and I've just about got the pedal to the floor. I have friends who repair cars as a hobby and they disagree with each other where I should go from here. One friend says replace the muffler and resonator (possible blockage that cannot bear any stress under a load...like going up a hill). Another friend says replace the third catalytic converter (one was replaced when we bought the car by the dealership, and I just replaced another one). He says when one catalytic converter goes the others are not far behind.
Mercury - Sable :: 2004 - CD Changer Location?
One of the possible locations for the CD changer for my 2004 Mercury Sable in the Owner's Manual said right side cargo area storage compartment. Is that the back of the wagon?
View 2 RepliesMercury - Sable :: 1999 - White Smoke Out Of The Tailpipe
This morning I went to start my car and it wouldn't start. So naturally I had it jumped and it started. When it did there was white smoke coming out of the tailpipe. I do want to mention that 2 days ago it was really low on oil and I added 3qts. It is almost 3,000miles over its oil change but this is the first time since I have had the car that the oil has not been changed when it should be. Do you think it just needs a tune up and oil change? My car is a 99' Mercury Sable with over 100,000 miles.
View 11 RepliesMercury - Sable :: 2001 - Low Coolant Light Comes On After Driven A While
2001 Mercury Sable? I recently have gotten to use a 2001 Sable that is a perfectly great car. Low mileage, (43,000) fully loaded etc. However, it was obviously not driven very much, once a week back and forth to the beauty shop, but it was not garaged... mostly parked under a carport or a tree. What keeps happening is the Low coolant light comes on after it has been driven a while. The car has been checked out, and the coolant levels are fine... that's easy to see... no leaks were found. Recommended repairs were Trans Flush, Belt, and Fuel Injection service. I have noticed that after the light comes on the AC stops working as well on the Max setting and I lose fan speed adjustment ability. The way I know that is because when I turn the AC to AUTO and the fan on high, it blows harder. I have also noticed that after driving it with the light on, when I stop the car I can smell radiator fluid - but I haven't spotted any leaks - but I haven't looked very hard because mostly I just stop driving it. What may be causing the light to come on? Is it actually related to the AC, or is that a separate problem, OR is it a computer problem? Has there been a recall on this? Is it something that I need to worry about?
View 11 Replies