Mercury - Grandmarquis :: Starter Would Click Several Times When Turned The Key Before Engine Crank
The customer brought in her 130,000 mile 2000 Mercury Grand Marquis complaining that the starter would click several times as she turned the key again and again, before it would make the the engine crank like crazy. I saw that the positive battery cable was badly corroded, and replaced the aftermarket end with a new aftermarket end. Everything was nice and clean. No difference. I tested the battery for load voltage with my good old Sun VAT-60. It tested good, sufficient voltage after 15 seconds under a 100 amp load. I removed the fuel pump relay so that the car would not stay running for long, and then would not start when the starter did engage. It drew 120 amps while cranking. That's within spec for a fully warm engine.
I think what she has is a bad solenoid atop the starter, or perhaps a bad spot on the commutator that moves slightly with each click until the brushes are in another position. Then it will turn OK.
I think a new starter is needed. Am I on the right track? I don't want to crawl under it unless I have to, and she doesn't have money for me to make a mistake.
Ford 7.3L Power Stroke (1999-2003) :: Engine Turns Over Just A Couple Of Times Then Sounds Like Starter Disengages
Yesterday my truck began to give me some problems starting. The engine turns over just a couple of times then it sounds like the starter disengages and winds up. it took multiple attempts but it finally fired up. Does this sound like the starter or could it possibly be the starter relay?
2002 F350 CCLB Lariat 7.3
Ford 6.0L Power Stroke Diesel :: 2003 - Starter Won't Crank Over
2003, 6.0,128K, original starter, I was towing a heavy trailer out of state, shut engine off at a gas station 2 miles from my destination. Truck started back up as normal. Continued on my way towing uphill. I backed in the driveway and shut it off for a half hour while unloading the trailer. Went back out, all lights came on with ignition, but no crank. I don't hear a click like a solenoid. I checked fuses, I got hung up on checking what looked like a solenoid on the passenger fender. Its a big relay, but now I;m thinking its for something else. I had to leave the truck out of state and was able to get a ride back. I won't be back there for two weeks. Should I bring a new starter? A 6.4 starter?
View 2 RepliesToyota Corolla :: 2003 - No Crank No Start / Battery And Starter Both Test Ok
Car was fine, then wouldn't start one day, after driving fine a couple of minutes before. Did this a few times previously, just tried a few times then it started again. There is no cranking when I turn the key, just a click. Lights work fine, stereo etc, no dip in power when turn key. I assumed it was starter motor so took it out and tested it - fine. Also tested battery - fine. Looked at a spark plug, fine, oil level fine. Don't see a reason the engine should have seized, as it was driving just fine, then wouldn't start suddenly, but I haven't tried manually turning the crank. I then looked at the switch on the clutch pedal that gets pressed when you push the clutch in, and allows it to start. Looked ok, but pulled the wires and bypassed it with a cable. Still nothing. Can the starter test ok but still be bad? Toyota Corolla 2003 80,000 miles ...
View 19 RepliesFord F-150 - 1997-2003 :: 2002 - Starter Did Not Turn Or Crank The Engine
I have an 02 f150 5.4 4x4, drowned it a while back, thought i had hydro lock, crank can be turned by hand though as far as i can with a wrench, so internals seem to be fine, no bent or broken rods that i could tell, ripped everything apart cleaned it up put it back together, new fuses, new ignition relay, new starter, alternator and battery as well, turned the key to on and got all my electronic stuff back up, turned to start and it all goes dark, which i assume is because at that point its sending power to the starter, but the starter didn't turn or crank the engine...
So question being when i put my new starter on is it possible that i might have crossed a wire or something that would cause it to not crank? and due to the fact that I had water in it, and had hydro locked it, all my plugs are out, now I know that spark is needed for the engine to run, but shouldn't be needed just for the crank to turn right? question being is that once i fix the wires on my starter, I am looking for initial crank before start up, so do i need to put a plug or two back in and hook them up to make it crank? or will it crank without them? and yes I did replace all my fluids as well.
Civic - Honda :: 2008 - When Starting Engine Hassle To Crank Then Would Stop
So I just bought this 08 civic LX (110k miles). After a few days of flawless driving, we noticed a couple wires NOT connected that were coming from the hood opener-sensor thing. Plugged them together and noticed no difference in the car until I let the car sit for about 6 hours then thats when the trouble started. Tried starting the car and the engine had trouble cranking then would stop. Pulled the key out and tried a couple more times and finally the engine started. The next day I had to do the same thing to get the car to start and now 2 days later the car wont even crank. No ticking, no cranking- nothing. Battery date is 10/14 so its coming up on 2 years old. When I turn the car to "On", everything works (stereo, lights, headlights, dashboard lights- everything). You would notice no difference until you tried starting the car.
I haven't gotten to it yet but I haven't tried cleaning the battery connections. Just looking at them I cannot notice any problems or visual corrosion. Im thinking that because I plugged those wires from the hood-sensor-thing, its a bad sensor and drew current from the battery while the car was off.
If this was the case then jumping the car would probably fix it but nope, not my lucky day. Jumping the car didn't work at all and before I start checking fuses and connections, what the problem could be.
Ford F-150 - 1997-2003 :: No Crank / Starts Only When Solenoid Is Jumped - Slow Starter
I am having some weird issues with my 2000 F150. When I turn the key all the dash lights go out and no start. Ran 2 wires from the solenoid to a switch and it will eventually start. The starter will start real slow almost like the battery is almost dead and then speeds up more and more till it eventually starts. After it starts the theft light stays on the whole time. At this point I have no clue what is going on.
View 1 RepliesFord F-150 - 1997-2003 :: 1998 5.4L Engine Won't Start / Starter And Crank Pulley Turns
I just got a 1998 F150 5.4l 4x4 autotragic. Was sold to me as needing trans, wouldn't start. Tossed in a new starter and solenoid, now I can hear the the starter turn crank pulley turns maybe a quarter inch and when I let off the starter it goes back to the same spot.
Fear is motor is locked, but question (i don't know automatics) is there any way that a bad trans could keep a motor from turning over? Truck rolls in neutral or drive, pulled the drain plug no water just oil. Tempted to just buy a running 5.4 with trans but if I can avoid that I'd prefer to.
Saturn - Vue :: 2003 - Backfire After Coming To Stop And Pops About 6 Times?
I have a 2003 Saturn Vue AWD V6 with 108,000 miles that has had an annoying problem with backfiring. The issue mainly occurs in the winter after I come to a stop at the end of a highway exit ramp. The noise isn't very loud, but noticeable as it "pops" about 5 or 6 times before going silent. Over the past year or so, I have replaced the spark plugs and both ignition coils (both of which had small cracks in the housings) and the noise remains.
I don't know if this is another hint or a red herring, but my car has had some issues with rough shifting and hesitation as I let off the throttle on the highway. I love this car but these lingering problems are really getting to me.
Ford 7.3L Power Stroke (1999-2003) :: 2001 F250 - Intermittent Starter / Whirring Sound When Crank
I have a 2001 f250 ext cab long bed 4x4 that I use as a feed pickup. I have had it for about a year now. one of the issues I have noticed since I bought it is the issue I am having with the flywheel/starter. Its very random like maybe I have a missing tooth or something on my fly wheel. but every so often when I would go to crank my truck over it would just make a little whirring sound and nothing happen ( like my starter gear isn't sliding out and engaging my fly wheel.
After looking through my inspection cover I noticed I had a little wear on the sides but no teeth to my knowledge broken or stripped off. I noticed my starter had one bold loose but other two perfectly tight. It was also covered in oil and dirt from my truck sweating horse power I decided to replace my starter and have my original ford starter rebuilt. I replaced it with a NEW oreillys starter. I noticed it cranked about 5 times as fast but again every 10-15 starts I am getting the same no start. any thing I am over looking?????
Honda - Accord - Clutches :: 2003 - Clutch Master Cylinder Changed Six Times In 12 Months?
I have changed the clutch master cylinder on my '03 Honda Accord (6 cyl.) six times in the past 12 months. Either the o ring seal blows out or the bolts holding the plate down breaks off. I bleed the clutch of bubbles until the oil runs through also. What am I doing wrong?, I'm about to send this car packing.
View 9 RepliesFord F-150 - 1997-2003 :: Driver Door Unlocks Multiple Times When Turn Off Key (6 - 10 Times)
2003 F150 Super Crew 5.4
When I turn off the ignition, the drivers door lock unlocks or pushes the arm through the door for up to 30-60 seconds over and over again. I would say like 10 times and it is annoying as hell.
Is the only part in the door that controls this the actuator or is there something else that can be doing this?
Ford F-150 - 1997-2003 :: Airbag Light Flashing 5 Times Then 2 Times - Error Code 52
I had been having battery issues with my 97 ford f150 4.6 liter for the longest time, thought i had a short under dash, i pulled entire dash out, disconnecting bat first of course, and inspected all wiring harness connections and fixing my issues and putting it all back together. now with new bat and all put back together i am now getting the airbag light flashing 5 times then 2 times (error code 52) i know it has some thing to do with power failure or backup battery, but now with the new battery in i cant seem to get it to reset. How to do this?
View 3 RepliesToyota - 4runner :: Starter Eventually Engages And Cranks 2 Or 3 Times But Engine Does Not Turn Over
During the cold snap over the last few months, my 1997 Toyota 4Runner has been having starting problems with the following symptoms in this order:
I turn the key and nothing happens.
I keep turning the key from off to start, and the starter eventually engages and cranks 2 or 3 times, but the engine does not turn over.
I keep trying and the starter engages and keeps cranking even after I turn the key off.
I panic, and turn the key on and off until the starter stops cranking.
I try a few more times and the starter cranks and the engine catches, but lugs until I pump a little gas.
Really weird thing. Occasionally, after the above sequence, the emergency brake light stays on even though the brake handle has been disengaged, and it feels like I have no power, then the light goes out and the car runs just fine.
The problem in intermittent. Cold seems to cause it although it doesn't cause it every time. Rain may be a factor as well. Sometimes, I only have to turn the key a few times, and then the starter will engage. I changed the battery after the trouble began, and it cranks well if and when the starter engages.
Up until this I have not had a day's trouble with this vehicle other than a little belt squeaking.
Honda - Accord :: 2003 - Cannot Stop Shaking
I have a honda accord 2003 ex. I bought the car over a year ago. A couple months in with the car i started to feel that the car vibrates while in idle. I replace the motor mounts and the shaking is still there. When i drive the car at night with the headlights on the shaking gets worse. If i put it in neutral sometimes there is no shaking and sometimes you can feel it a little bit. Also, in the summer when i turn on the ac the shaking gets so much worse, even if i put it in neutral the shaking is still pretty bad. One more thing, when i turn on the heat and put the car in neutral there is not too much shaking. I just don't know what to do anymore.
View 6 RepliesFord Ranger / B-Series :: 2003 - Intermittent Growl On Takeoff
Ok, basic rundown. Stop at a red light, turns green, when i go it gives a strange grindy-growl from the rear. Lasts maybe 2 seconds then its gone. its very uncommon. But it is something i am interested in getting figured out. Doesn't happen any other time, only on complete stops.
View 2 RepliesFord Super Duty (1999-2016) :: 2005 - Died At Stop - Crank But Won't Stop?
I have a 2005 ford f250 6.0 I was driving back home from a interview and my truck died at a stop light it would crank but no start I tried replacing the stc fitting didn't work so the I replaced the ipr still didn't work bought a new hpop still didn't work I'm lost at this point I have low pressure oil pump is working new icp, what is going on?
View 8 RepliesPassat (B5) :: Starter Wouldn't Crank
So months ago, my wife reported the starter wouldn't crank, but after a few tries it did and the car started right up, no issues since then. I figured she didn't push the clutch in far enough.
Two weeks ago, the car threw a code for the Cam position sensor and was making some funky noises (hard to describe, almost like a rattle inside/beneath the engine) and started bouncing at idle. I replaced that within a few days and cleared the code, but the noise persisted as well as the idle (but not all the time).
Then last week it was still ratting around with no codes, but died on the highway and had to get it towed home. It would turn over, but wouldn't start. After fiddling a while and trying to start it a bunch, it would no longer turn over, so I figured the battery didn't have enough juice. Trying to jump it, I got sparks like you wouldn't believe. I actually started a small fire, and I hooked up the cables correctly too! I checked all the cables, made sure I was doing it correctly and tried again, same thing. So then I researched and saw that can be caused by a failing battery. Sure enough, the battery was 7 years old, so I went and replaced it. Still no start.
A few days later, checking more at home, it had spark, I can hear the fuel pump turn on, timing belt is in good shape, and the throttle is opening (electronically controlled). Still confused I bought a HEX+CAN and here's the results for Engine:
3 Faults Found:
16497 - Intake Air Temp. Sensor (G42): Signal too High
P0113 - 35-10 - - - Intermittent
17951 - Angle Sensor 1 for Throttle Actuator (G187): Signal too Small
P1543 - 35-00 - -
17580 - Angle Sensor 2 for Throttle Actuator (G188) Signal too Low
P1172 - 35-00 - -
Readiness: 0110 1101
So after taking apart the throttle to check it to make sure that it indeed was opening like the vag-com said it was, I put it back together and now the car won't crank. Well, I've been testing it for a while, so I figured the new battery was starting to get low, so I went to jump it and I almost started another little fire. The jumper wires heat up like crazy too. Their is no continuity between the negative and positive terminals on the battery, so I'm not sure what's going on.
Dodge - Ram1500 :: Starter Does Not Crank At All
I have a 1996 Dodge Ram 1500. The starter does not crank at all. I put the key in and turn it and nothing, just a click. I have replaced the starter/solenoid with a new one and I have charged the battery and it is good (battery is only 8 months old). It still does not crank, nothing.
View 19 Replies