Ford - Windstar - Gasoline - Filters - Pump :: 2002 SEL - Long Crank Time
I have a 2002 Ford Windstar that only in the fall and winter it has a longer crank time of at least 10 seconds. In the summer it starts as it should within 3-4 seconds. I did notice that the times it did start normally in the colder air is when I turned the key on and listened to the fuel pump prime the system. All other times it doesn't do that and that's when I get the long crank time. Once it is started it runs as normal. Am I looking at a possible fuel filter or pump? I am due to replace the filter as the van has 83,000 miles on it. If this is the possible culprit, is this something that is easily replaced at home?
View 4 RepliesWindstar :: 2000 - Cooling Fan Runs All The Time When Driving
My 2000 Windstar cooling fan on the passenger side is running all the time when I am driving, even in freezing temperature. My gas mileage goes from 18 to 13 now.
View 7 RepliesFord Super Duty (1999-2016) :: 2003 - Clock Spring Has 8 Spring Wire?
Adding cruise control to F350 XL I just bought. I got a steering wheel with the buttons. But I am having problems with the clock spring. Mine has an 8 wire plug with only 6 pins on the big plug and all of the clock springs I have found have only a 6 wire plug for the big one. Without changing my clock spring I have no where to plug in the cruise wiring. All have been for right year model with cruise and even tried different years but none will plug in under the dash.
View 3 RepliesFord Super Duty (1999-2016) :: Conversion Of Leaf Spring To Coil Spring?
Conversion from the dana 50 to the newer dana 60 with coil spring? My Dana 50 has called it quits so while my front end is already off the vehicle already why not make improvements. Ford used the 50 for 1999 to 2002 then upgraded to the 60, I'm guessing it was for a reason!
I've read this article on a similar project but the dana 60 had leaf springs as well: Dana 60 Conversion for F250 years 1986-1996 .: Articles I'd prefer coil spring, nothing more then personal preference with a bit of better ride quality. The donor vehicle is a 06 SRW F250 This is not what I'll be getting but just as an example of the parts I would get.
Ford Fuel System :: Gas Line Spring Lock Coupling - How To Release Garter Spring
I hope i don't give the impression on my very first post that I'm a total retard......but ...I can't figure out for the life of me how to get those spring line coupling apart! I've removed the clips...but it just won't pull apart. Is there a tool to release the garter spring?
View 4 RepliesFord - Windstar :: Oil Light Goes On When Idling At A Stop Light Or Sign
I don't drive (aren't you lucky?) but my wife and I own a '95 Ford Windstar and last summer we had issues with coolant leaking and had to have a few head gaskets replaced. Now, when we're idling at a stop light or sign, the oil light goes on but as soon as we accelerate, it goes off. The manual says the light indicated either low fluids (which isn't the case) or that the pressure within the system is low. The vehicle seems to run fine otherwise but I'm wondering if the oil light gauge has been set too sensitive?
View 7 RepliesGolf/GTI VII :: Spring Binding Popping Noise After Neuspeed Race Spring Install
This noise I have is driving me crazy, installed neuspeed race springs and now I have this weird spring noise, sounds like the springs are binding and then releasing when you turn the wheel, like a clicking dinging noise, it's on both sides and happens when moving slow and turning the wheel and when stationary and turning wheel, it sounds like tug and release not really spring bind I checked install and everything is correct even disassembled bearing assembly and everything is fine, lubed spring seats with silicone paste nothing is working.
When looking at the spring and turning wheel it's almost like the spring is getting stuck on the middle part of the seat then releasing, I know this was a common problem on the mk6 but I haven't heard anything about the mk7 the spring is seated in the lower perch perfectly the upper is were the noise is coming from you can see as you turn the upper bearing by hand it actually somewhat twists the spring and then releases and that's what makes the noise, and it dose not move in a nice circular motion kind of like an egg shaped rotation and it makes the spring flex and pop I think there's a problem with the springs,
Ford - Windstar :: 1999 - Theft Light Blinks Fast And No Start
Ive been in this game 16 years have i never stumbled across this. The theft light blinks fast and no start. Ive change the key , key remote to cpu, and the cpu it self all programed properly still no start ....
View 7 RepliesFord - Windstar :: 2001 - Chugging And Service Engine Light Blinking?
Twice now (and maybe a third time once I start my van again) we've had problems with the van chugging and then the service engine light blinking. Both times it happened in the past, we took it to a mechanic who said it needed a tune-up - new spark plugs, wires, etc. I'm curious as to why this keeps happening. Mileage is around 105K. It first happened last summer, second time was in December. Now it's March. What could cause this problem to repeat?
View 2 RepliesFord - Windstar :: Shaking And Engine Light After Replacement Of Pressure Hose?
we just replaced a pressure hose that broke and now the engine light blinks 30 times and then goes off and then blinks again plus the engine seems to be shaking allot.
View 1 RepliesFord - Windstar :: 1999 - Rapid Blinking Anti Theft Light
My windstar blew fuse #16. replaced soon. blew again, replaced again. now theft light blinks rapidly and won't even crank over. left switch on long enough to get a code reading from the light, it comes up to # 15.
View 12 RepliesFord - Windstar :: 2001 Misfire Occurring - Blinking Check Engine Light While Trying To Accelerate
I have a 2001 Ford Windstar Sports SE with 155K miles. I did a tune-up eight months ago. With the tune up I had to replace the fuel pump because it was defective. Later, I found that there were misfires occurring since I was getting slow acceleration. I had the spark plugs on the guilty cylinders replaced again and the spark plug wires.
Periodically, I have had to return to the shop to have the vehicle checked. I sometimes get a blinking check engine light while trying to accelerate, which now occurs only while it is raining or I am exiting the car wash. The shop is at a loss as to what it is (spark plugs and wires are fine, no lose connections noticed). I am wondering if I should take it to someone else. Of course, taking it somewhere else will cost me $100 to check on someone's else work.
The shop replaced the ignition coil. Distributor cap is fine. They keep saying that the engine is running fine while in the shop and do not get any codes. I had them drive it while it was raining and they discovered that cylinder 4 is misfiring. They worked on the cylinder. The vehicle runs well, until it rains or I wash it.
My questions to the group, "If everything is OK, how come it is misfiring? What are they missing? What is the connection to the moisture?"
Windstar :: 2002 Ford - Meter Shows That Battery Giving Out Enough Volts But Check Engine Light On
2002 Ford Windstar: Whenever I disconnect the battery and then reconnect it, I get this hum that sounds like the CD player preparing to play a CD. There is no CD in the player. It last for about 30 seconds and then stops. Afterwards, my check engine light comes on and stay on until I have the mechanic reset the alarm. The battery is new. My meter shows that the battery is giving out enough volts. It annoys me to have the check engine light on all of the time. I'd rather it be off so it can report if something else goes wrong with the engine.
View 1 RepliesWindstar :: 2002 - After Driving A While ABS And Brake Light Come On
mY 2002 Windstar abs & brake lights come on after driving a while. would it be ABS module?
View 10 RepliesWindstar :: 2000 - ABS Warning Light On And Off Intermittently
I decided to tackle my ABS warning light issue because it's been on and off intermittently since I bought it.
I first suspected bad wheel sensor(s) per many previous threads. I borrowed a scantool with the ABS diagnosis and found that all 4 wheel sensors are reading same speed value, but they indicate wheel speed of about half of the speedometer reading. Another thing I noticed was that the ABS main power relay output is "1bit" when the ABS warning light is OFF and is "0bit" when it is ON.
So it seems like the ABS power relay is bad. My alldata manual for this model says that the part number for the relay is FOAZ14N089A but it also says that "the ABS is not equipped with an external ABS Relay. According to wiring diagrams provided by Ford, the function of the ABS relay is incorporated into the ABS module". Does this mean that I have to replace the whole ABS module or HCU just because the relay is bad?
Why wheel speed is different than speedometer?
1998 Windstar - Warning Light For Air Suspension Came On
My 98 Windstar Limited has air suspension in the back. Lately, it would be sitting low in the back before starting it up in the morning. The compressor would pump it up as soon as you fired up the van. And the rest of the day would be fine. The other day, the warning light for the air suspension came on, and the compressor has not worked since. Fuses and power connections all seem okay. OBD codes C1770, C1790, C1818 and C1850 were in the system.
View 3 RepliesWindstar :: Light Icon On Dash Staying On
I just had a set on HID'S installed in my van but after they were installed i have the burnt out light icon on my dash staying on now is there a way to either pull a fuse to disable it or should i just ignore it and throw a piece on tape over it
Hyperion Bi-Xenon 6000k kit i truly wish i would have done this sooner
Windstar :: Rough Idle - Engine Light Comes On - Misfire?
My windstar 3.8 engine has idle problems and engine light comes on at times. Code po305 (misfire #5). When I add sea-form to tank and drive awhile, the engine light goes out and the engine idle's normal. Is this an eva problem and what should I look for?
View 11 RepliesCaravan/Voyager :: 1997 - Airbag Light Coming On Then Off / Clock Spring?
I have a 97 voyager. recently the airbag light has been coming on then off. now it is on all the time. In addition to the air bag light being on the horn and the steering wheel cruse control does not work. The fuses and relays are all good. I was wondering if the clock spring is the problem?
View 2 Replies