Ford Super Duty (1999-2016) :: 2008 F250 - Lost Power While Driving Uphill At 60 MPH / Shut Off / No Start
While driving up hill at 60mph the truck lost power. Rpm jumped up as to change gears as it hit 55mph. Still losing power until it shut off. I tried to restart and just got a click from the solenoid. No engine codes whatsoever. Battery had 12.1 volts but when turning the key to start in getting 8 volts. Had it towed home. Today I swapped batteries with my other truck and same click noise from solenoid. All lights, radio, ect still work. Where should I start? Alternator, fuses...?? 2008 f250 5.4 ...
View 12 RepliesFord 7.3L Power Stroke (1999-2003) :: All Power Lost / Engine Shut Off
So on my way home today I lost all power, the engine shut of and i coasted to side of the road. Went to try and start, nothing. When key is in the crank position the gauges were jumping all over the place, also accompanied by a lot of clicking from behind the dash. Nothing happened when tried to crank. No power to windows or even emergency flashers.
So i get it towed home, and of course it turns over. But this only lasts about ten seconds, then dies. I could do that a few times and then back to no power at all. Even at times with the keys out of ignition it will still click and make a lot of noise.
Ford 7.3L Power Stroke (1999-2003) :: E350 Lost Power / Shut Down And Won't Restart
My 99 E350 with 7.3 power stroke quickly lost power while on the highway today, bogged down and died. I couldn't get it restarted so had to have it towed home. I tried getting it started at home but it just pumps out white smoke out the exhaust. I got it to fire and run for a minute on a mixture of starting fluid and wd40 but wont stay running. Some background info, I checked oil and it was low but still registered at very tip of dipstick so I topped off oil level and still no start unless I give it a mixture of starting fluid and wd40. Batteries are good and cranking fast. Truck has 355,000 miles but very little blow by and prior to this had plenty of power and didn't have to use the block heater to start it thru the winter even when the temps dropped down to 12 degrees in January.
One thing I did have an issue with this past year was an intermittent cutting out while driving where the engine would instantly shut off but as soon as I tapped accelerator pedal it would start running again like nothing happened, wouldn't even last two seconds and it was running again just like shutting off the key and turning it back on and when it would do that the "Wait to start" light would come on and gauges would drop like key was off but again it all went back normal as soon as I hit a bump or tapped the accelerator pedal and it never lasted more than a second or two and never had to pull over, just tap the pedal or hit a bump and engine would kick in and run fine so not sure if that's related to whats going on now or not.
Ford 7.3L Power Stroke (1999-2003) :: 2001 - Hot No Start / Shut Down
My truck occasionally gets a hot no start issue and it's been happening more frequently. Mostly it happens if I drive it up to operating temp turn it off for a short time, then try to start up again. Usually, if I wait 15min to an hour it will start up. It has died on me while driving too, then I have to wait and periodically try it. I've noticed in this situation that if my glow plugs turn on for only a short time, it won't start. But once the motor has cooled enough that the glow plugs stay on for the longer duration, then it will start right up.
I've replaced the CPS, rebuilt the IPR, did the ICP unplug test, rebuilt the injectors, replaced the fuel filter.
HPOP oil level is good, changed the oil maybe 500mi ago. When it's a no start, the low oil pressure gauge does start to read after some cranking, also the tach does read. It throws no DTCs. My reader isn't able to monitor live sensor data.
There is some oil in the valley, but I can't find the source. I think it's probably the turbo pedestal. What else should I check?
Ford 7.3L Power Stroke (1999-2003) :: 2001 Excursion Shut Off / No Start While Driving
I am a new and very happy 7.3 owner. i have lurking around these forums and decided I didn't want to be a creeper anymore. So onto the fun stuff.
Yesterday my wife was exiting a freeway and the Ex shut off while exiting. once she came to a complete stop she tried turning it on and it would start then immediately shut off. she was able to turn it on and it would run then shut off as she drove across the intersection. once she made it across a good samaritan offered to park it for her. She noticed a little bit of black smoke but she told me that the guy was revving it to keep it running.
Luckily there was family at the mall and she waited for the flat bed to arrive. it sat for about 2 hours and they tried starting it and it would start then die. no more black smoke though. we had it towed to a diesel repair shop and they went to start it today and alas it started right up. they let it idle for 30 minutes and it was good. they test drove it and all good. they ran the codes and got the following:
P1876
B1352
B1483
U1147
One thing I did notice a couple of weeks ago, while driving on the freeway cruising about 65, the Ex surged a little and then ran fine. then another time it surged a little while idling. Some more info on the rig. it has a banks six gun tuner and has a cold air intake and exhaust. And it has a Banks Big Head wastegate. I bought the rig 2 months ago and changed all the filters and fluids.
Ford 7.3L Power Stroke (1999-2003) :: 2001 - Crank And Start Then Idle For Few Seconds And Shut Off?
I've developed a problem, usually when starting, that the truck will crank over, start and idle for a few seconds and then shut off. The few seconds it idles it doesn't get any throttle input. I'll crank it back over taking a little more than usual to get it started. When it does start it seems slightly sluggish but that quickly, like almost immediately goes away and the throttle is working again.
Oh, 2001, 7.3 stock w/200k
Santa Fe (CM - 2007-12) :: Engine Lost Power / Shut Down
I was headed down the highway in my 2007 Santa Fe last night. All of the sudden, I lost engine power. I pushed the gas peddle and nothing. We coasted down to a stop on the side of the road. I attempted to restart, all it did was turn over. I noticed the OIL light was on, so I got out and double checked my oil level. Right up to the full mark. Probably about a year ago, I had a check - engine light. I have a code that indicates that my gas level sender has failed, so my gas gauge does not work. I am sure you are saying.....he just ran out of gas. Well, not the case. I filled up the day before, and figured I had another 100 miles left on this tank.
Over 171000 miles on it and I have no intention of giving it up soon.
Ford - Focus :: 2001 - Stalling / Becoming Harder To Start And Maintaining Steady Idle
My daughter's automatic DOHC SE Focus had suddenly been stalling, becoming harder to start and not maintaining a steady idle. I took it to our semi-trusted repair shop and was told it needed an EGR valve, plugs, coil, and ignition wires. $580! These all seemed like repairs I could do and so I have worked through all of these. I replaced the EGR valve and that seemed to make the problem actually worse. (so I put the old one back in) I put in new plugs and that improved the idle a small amount. Then I put in the new coil and that seemed to steady the idle a bit more. But here is what I have discovered through my many test drives after making these incremental repairs: The car starts now from cold very well and runs great for the first 20 minutes or so but...when it gets hot after 15 minutes or so of 50 mph driving, the idle drops and the engine wants to cut off. At low revs it seems to stumble and lose power. I think this is what my daughter was experiencing originally and none of my early test drives were long enough to surface the original problem. I have read that the Idle Control Valve might be a culprit in this sort of behavior.
View 5 RepliesStarting - Ford - Gasoline - Pump - Focus :: 2001 - Starter Functions But Engine Won't Start
Almost every time I start my 2001 Ford Focus, it won't start. The starter functions but the engine won't start. I have to pump it, give it gas, and once it starts, it's perfectly fine, no stalling, no problems after that. That is until I turn the engine off. When I go to start it again, say after doing an errand or two, it may or may not happen again throughout the day, the problem only occurring when I attempt to start it.
View 1 RepliesFord - Focus :: 2005 ZX4 Won't Start / Losing Power?
I have a 2005 Ford Focus ZX4. It is a stick. For the past month it has been having trouble starting, the example I will turn the key and it will try to start up, but doesn't. Then it will start but it is weak, sputtering, not wanting to really start, but I give it a little gas and it is fine. The last time it happened, It started after about 8 tries. I was driving a little ways and all of a sudden the radio/cd player quit working flashing a message that said low battery. Then all the lights in the car started to dim out. The headlights started dimming out too.
I did make it home, turned it off and when I tried to start it again all I heard was a click, click, click noise. It is at the shop now. I thought for sure it was the alternator, but they said the alternator is testing fine and once they 'recharged' the battery it is fine too. They drove it around for about a half an hour and they said it was running fine. What the what? They said they did have the problem getting it to start that I did, but only once. Now they aren't sure what the problem is. I don't want to get ripped off! I also don't want to have to fix something that isn't broken. I
Ford - Focus :: Electrical Lost - Relay Clicking Faintly But No Attempt By The Starter To Engage
I have a 2005 Ford Focus, we bought it used. On occasion it loses power(electrical) and won't start I hear a relay clicking faintly but no attempt by the starter to engage. when this happens the am/fm radio will lose the presets and will actually come on by itself at a am mode and static. when this has happened I have touched various electrical components (battery posts fuses relays etc) and most times on the next try it will start. Sometimes you turn the key back on a couple of times and it starts immediately .
I have had this happen twice while driving down the road and not noticed any change except the radio comes on by itself and presets and clock needs to be reset. I have pulled all fuses and relays to check for any corrosion and plugged all connection etc in and out all looks ok. This might only happen once a month or if vehicle is left setting for a few days Battery is new and checked at 97% unit starts up immediately if problem is not there and it doesn't seem to matter what you touch or move it just starts when it wants to Ford dealer says it needs a new battery (doesn't comment when told it is new and battery and starter work fine when called on except for this glitch).
Ford - Focus :: 2007 - Cruise Control Kicked Out / RPMs Went High And Then Acceleration Lost
Recently I was driving on the highway, about 70 miles into my trip, when all of a sudden my cruise control kicked out and the rpms went high and then I lost acceleration. I pulled over to the berm and tried to take off. Problem is I could not get the car past 30mph because the accelerator pedal could. not be pushed down more than an inch or two no matter how hard I pushed. What could be wrong???
View 1 RepliesFord 6.0L Power Stroke Diesel :: 2005 F350 - Lost Power And Won't Start
I have 2005 f350 with 365000 km on it I have it for one year and don't have a problem till last week. I was pulling van on dolly uphill and sadden lost pover, so I stopped and check oil leaks ,transmission .... But everything looks ok in couple minutes start engine and go home (10 km). Change fuel filters trans filter, looked good for 50km and star losing power again and doesn't want start. So I skan and its show me next numbers.
Key on engine off
Ipr-15%
Icp-0psi
Icp-.26v
Ficm main power-47.8
Ficm logistics power-14.5
Ficm sync is good
Engine crank
Ipr-85%
Ficm main power-48.0
Ficm logistics-12.5
Icp- 625psi
Icp-.77v-1v
So what I have to do?
Ford 6.0L Power Stroke Diesel :: Lost Power Now Won't Start - Bad Fuel?
This is a new truck to me 03 Excursion, the owner has done a lot, gave me receipts for a lot of work and cosmetically it just seems taken care of. About a year ago hpop, ficm, oem egr and 3 injectors. He wasn't happy with that mechanic and still having problems so went to a different (supposedly better) shop. This time turbo cleaned, all 8 injectors and passenger head was redone and put back on with oem bolts. Apparently it was found that a nut was dropped down valve cover by the first shop! Somewhere along the way the ICP and GP module has been replaced.
I've only driven it a couple times and seems great until last night. It was loosing power and in about 10 seconds died and wouldn't start back up. Pops but doesn't stay running. WIF dash light on and no CEL codes. Not sure where to start/what to do. I've paid for most of it and was planning to pay the rest and transfer title but I'm not comfortable doing that till I'm confident it's good to go.
I drained the separator and seemed to gush out like it should and don't think I saw water. I'm planning to take the sensor off the filter there, inspect and clean it but I don't imagine that's the problem. I do see oil coming on the back of the engine and front of tranny on the drivers side... maybe ICP is all oily and failed? I don't know much about these, just been trying to read. What should I do as some first steps? Do I need some sort of scanner? It seems like it's starving for fuel. It was about 1/4 of fuel when I bought it and filled it up the night I took it home and have put about 80 miles on it since. Is it possible it's got bad fuel or water?
Ford 7.3L Power Stroke (1999-2003) :: Lost Power While Driving And Won't Start Back Up
I have a 2000 f350. Lost power whole driving and won't start back up. I have checked all my fuses and relays several times. Have no power to the fuel pump. Tried running a hot wire straight to the pump and still nothing.checked my emergency cur off switch and there is no power there. Also my WTS light isn't coming on now. Tried checking the heater bowl and no power there.
View 6 RepliesFord - Taurus :: 2001 - As Soon As Ignition Is Turned All Power Is Lost
2001 Ford Taurus 3.0 DOHC. Starting Problem. When the door is opened the interior lights come on, door dings, etc. As soon as the ignition is turned everything goes black all power is lost. Disconnect battery cable and reconnect, the open door again and the interior lights come on, door dings, insert key and turn, everything goes black, the car does not start. This cycle repeats over and over again every time the battery is disconnected and reconnected. I have replaced the battery, ignition switch. The starter was replaced last year. Why does power blackout, and car not start when the key is turned?
View 1 RepliesFord 7.3L Power Stroke (1999-2003) :: 2001 F350 - Power Loss And Almost Shut Down At Random Times
I have a 2001 F350 7.3 the truck will at random times loose power and almost shut down. A while back I had an issue with the uvch plugs and changed that out. Truck ran fine till I got some dirty fuel from a diesel tank at my friends farm. I did the hutch mod cleaned the tank and now have a frame mounted screw on filter before the pump. I cleaned the fuel bowl and changed the filter. Fuel pressure stays at 59psi and drops to 56psi wot. The truck is tuned with an edge programmer. After these mods the truck ran awesome for over 2000 miles. Now it has the above stated problem. I have fuel and hpop guages along with egt and boost. During the problem egts will increase rapidly and it seems like it is starving for fuel.
Hpop gauge reads 3300psi or above during wot and shows good pressure during these mishaps. I have auto Enginuity and I get a different reading at wot of only 2600 psi. The hpop gauge is tapped into the icp sensor per instructions and has been installed this way for a while with no issues. The tune has been on the truck for over 40000 miles. The only thing that I can come up with is it will occasionally throw a p1211 under wot or pulling my Gooseneck Dump Trailer when loaded. However it acts up sometimes and doesn't throw the code. Sometimes you can shut it off and start it back up and it's fine other times it will last for the whole day. My only guess is low pressure from the hpop but I don't reflect this from my gauge only on AE at wot. Wouldn't a bad pump act up all the time? Am I correct to think it is just the ipr?
Ford Aerostar :: Clacking When Try To Start / All Electrical Power Lost
The problem started with me leaving the parking lights on, battery was discharged overnight; jump started it, drove it around to charge the battery, ran fine for two days. Now when I switch Ignition Switch to start I hear a sort of mechanical "clack" and I lose all electrical power, nothing, nada. Removed and took the battery to check it and charge it, tested good and is now fully charged.
Reinstalled battery, same symptom, a "clack" when I try to start it, then dead, all electrical power disappears unless I rock the steering wheel up and down, rock the shifter through the gears, etc. It's been raining in Florida daily, I wonder if water is to blame. Start Lock Relay?? Ignition Switch??
Ford 6.0L Power Stroke Diesel :: 2003 6.0 Just Losing Power And Shut Itself Off / Crank But No Start
2003 crank no start, 196k bone stock truck egr still in truck and stock head bolts. Replaced the icp sensor and ipr sensor, both from ford. What happened is I got fuel then about 15 minutes afterwards my truck acted like it was going up a hill and was just losing power and shut itself off. ficm tested 48.5 volts all 8 injectors tested good and there is oil pressure. Had an egr fault code but I'm at a loss.....
View 7 Replies