Ford Excursion :: Blue Smoke Blowing While Idle
I am only at 141,000 miles and I'm seeing blue smoke while I idle! It started as a small puff of blue smoke when cold starting up...now it is much more consistent. I am also getting a diag trouble code of P0674 (glow plug in cylinder 4) can that be the cause? I'm nervous since I didn't watch my tech put oil in the truck at the last oil change...I think he put four gallons in instead of 15 quarts...is that a prob?
View 1 RepliesFord Ranger / B-Series :: 2001 2.3L - Blue Smoke / Bad PCV?
I picked up a 2001 ford ranger with a 2.3 from a friend of mine for next to nothing. it has a serious oil consumption problem. he just put a head gasket in trying to fix the problem with no luck. he thinks it has a broken oil ring. the truck only has 99xxx miles on it and i find it hard to believe that it broke a ring. I am thinking it has to be something like a bad pcv. If it is rings ill do the job but I don't want to pull the motor down just to find that all the rings are good and it was something that i looked over
View 11 RepliesFord F-150 - 1997-2003 :: Blue Smoke From Tail Pipe
After tooling around town and a complete warm up cycle for the engine I encountered a problem. The situation is this.... Had to go around a slow poke....waited until traffic had cleared and nailed it. My truck belched out a boat-load of blue smoke from the tail pipe. Could not duplicate this on the return trip to the stealer (Dealer). Needles to say, I am worried about the health of the engine....(no codes popped, or anything else as I had a code reader hooked up) My truck did the blue cloud again with a rev up in park after a cool down but wouldn't do it again, but there was a strong smell of unburned fuel at the tail pipe.
4.6L, 2WD, Sport Package....
Ford Excursion :: 2002 - Blue Smoke Cloud When Fires Up?
I have a 02' Limited V10 with 202xxx and have come across new issues recently.
Occasionally when I start up the truck it spits out blue smoke BUT its only when it fires up then it's done.
Ford F-150 - 1997-2003 :: Blue Smoke / Burning Oil / No Low End Power
Alright so In January had head gaskets done on my truck and when I got it back it Dont have any low end power and I noticed it was using oil. If I let it idle 15 min or so and rev it up it blows out a bunch of blue smoke and smells like oil bad. Been trying to figure out whats going on. Ive only put about 800 miles on it since I got it back for the head gaskets And its burned at least 3 quarts of oil. Its going to the shop on Monday gonna start with compression check and go from there I'm Thinking Its valve seals or a bent valve. But machine shop surface and pressured checked the heads. Truck only has 146000 miles on it shouldn't be having these lined of problem. Its an 03 5.4.....
View 7 RepliesFord 6.0L Power Stroke Diesel :: Blue Smoke On Startup?
two days ago i noticed First start in the morning the truck billows out blue smoke. In mean is enough that looks like an old 2 stroke dirt bike. Quite alarming. I've had HHS in for 4300 miles or so. I hope I did not mess the engine up by towing With the HHS in there. The injectors have been getting loud an indication that i need to change the oil again. The truck always gets louder when nearing oil change time. It reminds me of an old chevy with bad valve seals. Would turbo seals just go. The smoke goes away after driving maybe 2 min well i can't see it while driving. Truck runs smooth doesn't stutter or miss. It has been acting like the stiction is happening upon first starting after sitting for 6+ hours.
View 14 RepliesFord 6.0L Power Stroke Diesel :: Blue Smoke At Idle?
I noticed a few puffs of blue smoke a while back as well as oil at the seam of the exhaust tubing. I attributed it to bad turbo oil seals and proceeded to rebuild the turbo. Changed oil at the same time from T6 to T5, 15-40. The blue smoke is quite a bit less, but still shows at idle and not all the time.
First start up of the day, slight haze. I leave the house when the oil temp gets above 100 and drive easy until it gets to 160. I will get a pretty good train of smoke until the oil temp gets above 180 at every stop while I'm idling. When the oil temp gets above 180, it will only smoke every 3rd or 4th stop at idle. If I hold the brake and get the RPM's over 1,000, the smoke dramatically decreases, if not completely dissipates.
I do have the CCV rerouted and am wondering if it is affecting the operation of the engine.
Ford F-150 - 1997-2003 :: Slight Blue Smoke At Idle When Revved Up
97 f150 4.2 ... Got a pickup awhile back and was smoking excessive mostly blue. Pulled the motor and had exhaust valve with hole in it and intake valve not seating on separate cylinders. All new gaskets and put back in truck. Deleted catalytic since they were both destroyed and cleaned muffler as best I could. Now it smokes but mostly white when revved up and maybe slight blue at idle. It's not using coolant or oil but went through five gallons of gas in short time.
Tests I have done : Checked fuel pressure and holds 38 psi all day. Tested maf o2 sensors, one is bad and tested vacuum and compression all good. It seems to be over fueling to the extreme. idles a little rough and will backfire on occasion. No check engine light but had all the o2 sensor issue codes. I'm leaning toward bad PCM... Would that cause the smoke rough idle and super rich condition??
Ford F-150 - 1997-2003 :: 1998 - Puffs Blue Smoke On Start Up
I only see it on start up, after it starts I don't see blue smoke or smell it could this be valve guide seals? If so are they hard to change? This truck has 168000 miles on it and has a 4.6 engine.
View 3 RepliesFord F-150 (2009-2014) :: 2010 / 5.4L - Blue Smoke On Cold Start
Experiencing blue smoke shooting out the tail pipe of your newer F150. Mine has been puffing blue since 12,000kms, still doing it at 55,000kms. Been to 2 Ford dealers (6+X) and they can never seem to repeat it. However it has been getting worse. Shop foreman guessed and said its valve seals.
I took a video, which I will post here, contacted Ford customer relations, and they tell me until it smokes at the dealer they cant go ahead with any repairs.I told Ford my truck will sit on the dealer lot until it smokes again and I am not driving it anymore. Photo is worth a thousand words, video is worth none. This is driving me up the wall!!.
2010 F150 5.4L Engine blue smoke - YouTube
Note the blue puff in the video is my truck, taken last Friday, and this is a small amount. Normally it fills my driveway and garage.
Ford 6.0L Power Stroke Diesel :: Burning Oil - Blue Smoke Under Any Load
2005 F250, 6.0, 60K miles, recently (within last 1K miles) had ARP studs, EGR delete and new oil cooler installed. Shortly after (5-6 weeks later) I noticed blue smoke under any load (taking off from red light, backing up) but not at idle or startup. Was using the "Performance" SCT canned tune after the stud install, but had the "65HP Tow" canned tune installed when I first noticed the smoke and now back to stock after noticed the smoke as a precaution. Everything else original except FICM, filters and batteries and use 5w40 Mobil 1 since new.
View 14 RepliesFord - Crownvictoria :: 1988 - White Smoke Coming From Engine
Ok so basically, driving it around at 50ish mph or less and my car is fine but once I reach I-95 no problems yet. After about 10 miles at Interstate speed (on my way to work), I happen to notice an odd sound coming from my engine. It almost sounded like as though an airline plane was starting up. I checked for any warning lights going off; nothing. After about a mile I happen to smell something odd coming from my air vents (I don't have ac so I have my windows down) and then I started seeing a lot of white smoke coming from my air vents and the hood. Freaking out like a bat out of Hades, I immediately pulled over, shortly thereafter a heavy amount of white smoke was coming out even more from the air vents and from the hood so I pulled open the hood to let it escape and left the doors away from the interstate open.
I saw smoke coming from the engine coolant top or whatever it's called and it was coming out so fast and hard it was like making a whistling noise almost. I also saw white smoke coming from almost near the engine towards the back. However, whenever I am on a normal road going 55 or less it's fine. My grandfather says it has something to do with the cooling system or coolant or whatever it was. He doesn't know what would cause the problem or how to fix it... 1988 Ford LTD Crown Victoria LX ....
Ford 7.3L Power Stroke (1999-2003) :: Excessive Blue Smoke Under Load?
Ok, I have owned my truck for almost a year and it has 151,000 miles. I have noticed on a few occasions puffs of blue smoke and especially at night in the headlights behind me I notice a lot of smoke when I'm getting into the throttle hard. Under normal driving conditions I don't usually see anything.
Today I noticed it when I was backing my camper(8000lbs) up a small hill onto the side of my garage. It was puffing blue pretty good going up the hill while it was under load.
I have no check engine light on, the truck seems to be running fine. My oil consumption is about 2 quarts every 3-4000 miles. I tried the blow by test with the oil cap but besides some smoke out the filler neck no problems... I don't know very much about diesels so for me to try and trouble shoot this is a problem.
Ford 6.0L Power Stroke Diesel :: 2004 F350 - Blue Smoke On Hot Start Up
I have a 04 f350 with 175k on it. At around 160k it had new head gaskets, 2-reman heads, egr delete, new oil cooler and it is studded and tuned with SCT and custom tunes.
Since after the head gasket change it seemed to have started blowing a little smoke on the cold starts mainly. In cold weather the starts seem to be harder or slower also. Now for the last 6k-8k miles there is a little smoke at a cold start. But if the motor is warm and it sits for a bit maybe 10 min or less it blows a nice puff of blue smoke or burnt oil.
The smell of burnt oil is mainly on hot starts not cold starts. It does not burn oil running. It will dump some black smoke under acceleration or load. Could this be an injector problem? Or something else? Can't figure it out.
Ford 6.0L Power Stroke Diesel :: 2004 - Blue Smoke At Start And Until Warm
My 04 6.0h started puffing bluish colored smoke typically only when I was accelerating. After a short amount of time I noticed it was smoking quite a bit when cold and until it had fully warmed up. I took it to the repair shop and they pulled it apart saying the turbo seal had failed and the turbo was full of oil. I purchased a new Garret PowerMax and had it put it in.
I picked up my truck and of course it was still smoking when cold. After it warmed up nothing, just like before. Since I just put a new turbo in I am worried this one will be ruined as well since the same condition exist. My mechanic said I need to run the truck for few days before the oil would get cleared out which had accumulated in the system. Am I mistaken in thinking that if it was residual oil burning that it would be more likely to do smoke when warm as opposed to when cold?
Since the turbo and seal have now been replaced what else should I look for to cure my blue smoke blues?
Ford 6.0L Power Stroke Diesel :: White And Blue Smoke When Spooling Up In 1st / 2nd And 3rd Gear
Replaced stock turbo on my 04 f350 zf6 with a newer stock turbo from an 05 6.0 excursion with a wicked wheel. Truck never smoked before ever for any reason. Now with the new turbo the truck puffs out white and blue smoke when turbo is spooling up in 1st 2nd and 3rd gear but once turbo is spoiled up no smoke at all. 4th and 5th no smoke at all. What could be my issue? Truck runs great no sputtering or missing or anything. I rebuilt injectors about two months ago so those are good.
View 2 RepliesFord 6.0L Power Stroke Diesel :: 2005 - Little Blue Smoke On Cold Startup
05, 170k miles. Studded and egr delete but I don't have paperwork on either. Got a pretty good deal on the truck but I have a few questions..
It runs and starts great, warm and cold, with only a little blue smoke on cold startup. but every now and then when idling (say at a stoplight) the engine gets noticeably rougher, not terrible. No smoke. Goes away after 5-10 seconds.
When I remove the oil cap, there is a "puffing" blow by, not constant, and its not enough to blow the cap off if I set it on backwards. Just puffing.
This may be related, but I pulled the starter wire off the drivers side and touched it to the battery to hear how it cranks, and there is a noticeable blip in the cranking, its not 100% smooth.
Don't think I am losing any coolant. Runs great, getting 15MPG. No CEL. I went and had a relative comp. check done, cylinder 7 is the problem. We both are leaning toward there being a valve problem So I pulled the valve cover, now I have a few questions.
1. When I crank the engine over without starting, I can hear a "pfft....pfft....pfft" chug of air every revolution. I pulled the cover to see if I had a obvious rocker problem, but can't see anything because the oil rail is in the way. I'm guessing this air puff is sign of a valve problem?
2. When the truck is running, there is a small, steady stream of oil running down the rail and dripping onto the valve cover mating surface of the head, I think it was at every injector, definitely 2 of them. Was getting dark, so hard to see. Is this normal, or do I have a leak? Truck has updated dummy plugs.
My next step is probably going to be pull the rail, see if there is a obvious problem, then pull the head. And tips for me? Planning on having the HVAC evacuated then pulling the airbox.
Ford F-150 (2009-2014) :: Trans Occasionally Clunks In And Out Of Gear / Blue Smoke From Tailpipe
I purchased my 2013 Ford F150 3.5L Ecoboost screw in December 28th 2013. I now have 12,000 miles on my truck. My transmission occasionally clunks in and out of gear. Mostly in stop and go rush hour traffic around 20mph. Dealer applied a PCM/TCM software update in July. Still clunks... possible 'slip bump fix' required?
When I 'punch it', I see what looks like blue smoke blowing out of the tailpipe. Tailpipe has soot buildup. I've also noticed a slight drop in MPG. I have NOT noticed a loss of power. Wondering if my truck needs induction cleaning?
Ford 6.0L Power Stroke Diesel :: 2004 - Rough Idle - Blue / White Smoke?
2004 f250 6.0, 173k miles. I just had the head studs done and a new head due to a crack in one head, I got it back 3 days ago and she was running great. I towed my landscape trailer yesterday full of mulch and only went about 5 miles with the load, after the job driving to another one I noticed it sounded like it was missing at idle with a small amount of white smoke. Drove it home let it sit overnight, started it up this morning and a cloud of white/ blue smoke and a horrible rough idle. Smoke does not stop.
View 10 Replies