Dodge - Grandcaravan :: 2002 - Engine Stalls When Turning Left
I have an odd issue. I bought my car used from the dealer. The fuel pump was replaced last December, as well as had an oil change. The fuel pump died right after the oil change but are seemingly unrelated since the pump was bad when i bought it. After the pump was replaced my van stated acting up over the next couple days. The fuel gauge would dance randomly. That has since settled down. Now when i make left turns, the rpms drop and i have to pump the had to get it going again or else it completely stalls out in the middle of an intersection. .. it had been steadily getting more frequent and only on left turns. Right turns runs fine.
View 3 RepliesDodge - Grandcaravan :: 1997 - Slow Leak / Engine Temp Will Go Up When Driving Slowly
Our 1997 Grand Caravan with 170K loses more air conditioning every year. So, I assume I have a slow leak. Is recharging something I can do myself with the new type cans offered by auto parts stores? Also, I think the radiator fan no longer comes on, I never hear it and the engine temp will go up when driving slowly around town.
View 1 RepliesDodge - Grandcaravan :: Power Steering Is Noisy When Engine First Start And Run Few Blocks
I had my car power steering lush at a repair shop! Unfortunately, power steering is too noisy (lot of air trapped). The mechanic fixed right away at the time I picked up my vehicle but still had some noisy, he suggested I drove for few days to get the air out. After a week driving and the air still trapped. I brought my vehicle back to the shop and had the mechanic fixed again! and this time I got power steering leak when I drove home! I returned to the shop and he said he replaced both bad power steering hoses. Noise was gone (engine was at operating temperature).
My power steering is still noisy at a touch of turning steering wheel (not even turn the vehicle), it's noisy when engine first started regardless the temperature outside. I drive my car for few blocks and the noise goes away. I won't bring my car back to the shop anymore, they may make it worse. Logical thinking, I think either the air still trapped deep inside the steering system or the O-rings at hose ends are defective. When engine is cold O-ring is cold and shrink, it does not seal properly and when it reaches operating temperature, O-ring expands and seals properly. That's my thinking, of course, I can be easily wrong. There's no power steering leak to the floor!
Will those after market power steering seal additives like Lucas 10008 and other fix my vehicle power steering issue? is there something I can do at home to fix this?
Dodge - Grandcaravan :: 2011 - Air / Heating System Turning By Itself?
The air/heating system in my Dodge Grand Caravan (2011) has been turning on by itself. Sometimes, it will turn on repeatedly (full blast) three or four times within 10 minutes and sometimes it turns on literally every 5 seconds... I turn it off... 5 seconds later, it comes back on. This can go on for as long as I am in the car.
Also, when it comes on and turn it down, it just turns itself back on full blast again. It seems to start in the back of the van (when it first comes on) and then when I get the rear off, the front stays on. Once I finally get that off, the rear will come again within a matter of moments. It doesn't matter if I have the A/C or the heat on... It does it either way.
Dodge - Grandcaravan :: Won't Start In Hot Weather
I got a great deal on this van, and I love it, with one exception. On hot days (73 degrees and hotter) the van will not start if it has been parked in the sun; until the temperature returns down to around 61 degrees (usually overnight, but I have waited it out in the parking lot at work a few times).
When this happens, the lights and radio work fine; the starter motor will not engage. No click, no chugga-chugga vroom-vroom. Sad Curto.
Note: October through about May in North Carolina, this car is fine.
I have replaced the steering column (after replacing the clock spring); I have replaced the Power Distribution Center.
When the problem first surfaced two years ago, I had a mechanic install a wire directly from the starter motor relay to the solenoid. That was an expensive lesson. I'm not sure what the lesson is, so it was REALLY expensive.
So, I thought maybe the Auto Shutdown Relay. Nope... pull that out, and the starter still turns, so that is not my problem. Now I am starting to thing Powertrain Control Module, or something else that could have a temperature-sensitive component.
Dodge - Grandcaravan :: 1997 - Transmission Fluid Seeping From Outer Seal?
Our 1997 Grand Caravan with 170K has transmission fluid seeping from the outer seal where the left driveshaft connects to the transaxle. Is there a stop leak liquid that can be added to the transmission fluid safely? Is replacing the seal a major expense?
View 2 RepliesDodge - Grandcaravan :: 1993 - No Oil Pressure With First Start Up
I have a 1993 Grand Caravan 3.3L V6. When I leave the van set for a couple a of days (or even overnight) and then start it, I have no oil pressure for a minute or so. After the engine has been running for about a minute or so the oil pressure finally comes up but not to normal. Once the engine has warmed up the oil pressure returns to what could be considered "normal". After the cold start, no oil pressure problem, the engine and the oil pressure is fine for the rest of the day. Let it even set overnight though and I have a repeat no oil pressure with start up.
I am thinking that there is a problem with the pick up tube not sealing properly and allowing the oil to bleed down while the engine is off for an extended period of time. So, in effect, I have to basically prime the oil pump at each start up. I haven't noticed any leaks of engine oil anywhere, so I am thinking that this is an internal problem. Is there a check valve or O-Ring associated with the pick up tube or oil pump that may cause this problem? Is it a fairly easy problem to correct? On this engine the oil pump is located in the front of the engine block behind the timing chain cover. (As best as I could determine from the Haynes Manual).
Dodge - Grandcaravan :: 2003 Keeps On Shutting Off Or Sometimes Will Not Start Up
We have a 2003 Dodge Grand Caravan which keeps on shutting off or sometimes will not start up. When it has problems starting up, there is no turn over of the engine. Just nothing. After awhile, it will start up. During driving, it will just shut off. At first it would start right back up but now it will not start right back up. We have replaced the computer and the crank shaft sensor. We have taken it to two dealerships and they do not have any ideas as to how to fix it beyond what we have done. Our mechanic is baffled. He has checked the wiring and sensors but cannot find the problem.
View 3 RepliesDodge - Grandcaravan :: 1987 - Stalls But Won't Start?
I have an ' 87 Caravan/mini ram van with the Mitsu 2.6 4 cylinder engine. It has 180k miles. Always ran great until now. It'll start right up (the first time) on a cold morning with no problems, but runs a little rougher than usual. Before the engine is warmed up on a cold day, needs to wait a little while before starting to drive it. Recently, I've been starting it and letting it idle for about 5-10 minutes. When I start driving it, normally I don't even get out of my driveway, it stalls and won't restart. It seems like the carb might be flooded, but not sure. Could this simply need a tune up? I haven't replaced the plugs yet since I've owned it, I've had it for only a year so far. The previous owner was very meticulous about maintenance.
View 3 RepliesDodge - Grandcaravan :: 1997 - Electrical Malfunctions / Wipers Work Only In Spray And Wipe Mode
Problem 1: Headlight switch occasionally needs to be jiggled to get headlights on.
Problem 2: Wipers only work in the "spray and wipe" mode.
My Solution: Removed dash, installed new switches, replaced dash.Result: Now the right headlight does not come on at all. Wipers STILL only work in the "Spray and wipe" mode.
Question: Where do I go from here?
Dodge - Grandcaravan :: 2008 - Hard To Start Intermittently
My 2008 Dodge Grand Caravan has intermittent trouble starting. The starter has been replaced twice, and the WIN Module (and key) have been replaced. The same issue has been occuring, but never duplicates for the dealership. Their computer scan brings up no issues. The battery has been tested and is in good condition. It doesn't matter the time of day, or driving circumstances, the van will not always start.
It will have one click (and I can close the windows, turn on radio) but the van will not start. The Chrysler Dodge corporate office is getting me nowhere (big surprise there) and is not standing behind their customers-and Lampe Dodge is no better-so now I'm compiling information on my own to figure out the issue (since they are at a standstill with the van). What should I do now?
Dodge - Grandcaravan :: 2015 - Engine Oil Leaking
I have an appointment next week at the dealer to have this checked out. My 2015 Grand Caravan with just over 30,000 miles, has been leaking a bit. Enough to make a mark on any spot I park in for longer than an hour or so. I placed a white poster board under the front end to see if I could identify where and what it may be. After about 6 hours, I checked and it seemed to have several drops of what certainly looked like engine oil. A dark golden. The leak seems to be located about 3 or 4 inches inside the front driver's side tire.This has been going on for just under a month. I keep checking fluid levels, and the engine oil doesn't seem to be diminishing at all, though it is a bit tough to tell exactly because it is clean and hard to see on the dipstick for this auto novice.
An attempt to crawl under didn't produce any real info, seems there is a bit of the oil anywhere in the area when dabbed with a white rag.Again I am a novice, so I am just asking what I should expect when the van is checked out. The car has had all needed maintenance at the correct intervals, though the last couple changes have admittedly been at a quickie place.My father, a former mechanic till retirement told me in theory there is no way to be leaking oil and not have at least some lowering of the oil level, obviously.Could this just be seeping so slowly to not notice a level difference? I know it is next to impossible to get a diagnosis here without a real inspection, but based on the location of the drips and the color of the liquid, any guesses would be great.I am 6,000 miles away from the end of the warranty, and we have a long road trip planned in a few weeks.
Dodge - Grandcaravan :: 96 - No Fuel Pump Activation / Crank Or Start In Cold Temp
1996 Dodge Grand Caravan, 3.3 L engine. When the outside temp is a good range (50 degrees F & above) there is no problem starting. But when it gets below 40 deg. F and really chilly outside temp, I still have strong battery power, but when I switch on the ignition, I don't hear the normal fuel pump activation swirl sound and does not crank - simply silent click. Then I can wait when the outside temp improves and cranks up no problem.
View 6 RepliesDodge - Grandcaravan :: 2002 - When Left Signal Turn On Then Right Side Start To Flash?
My 2002 Dodge Grand Caravan's most recent problem has baffled 2 garages so far. It is now in a 3rd one that specializes in auto electric issues. When I turn on the left signal it flashes a few times then the RIGHT side starts to flash. When I turn the right signal on you got it the LEFT side flashes! I installed a new multi function switch and NO CHANGE!
View 6 RepliesDodge - Grandcaravan :: 2005 - All Electrical Lost And Engine Dead
In May of this year (2015), it started to die. What I mean is it loses all electrics and it kills the engine. No dash lights, no odometer, no headlights, no radio, no blower, no electric windows, no electric locks, no interior lights, no visable sign that it has power at all except a tiny red light on the dash that blinks every few seconds.Always at low speeds under 30mph, usually while under load from either being on the freeway for a bit or while the AC was running or both. If I wait long enough, it comes back on all by itself but this can take seconds or hours. The radio is not reset, which is the only other indication that the battery terminals are not at fault. I am getting power to the starter, but nothing else.
When it first started happening, we thought it was a fuse or relay and swapped out several, but while it was dead, nothing affected it. It only happened three times until July when it stepped up its game and would die multiple times a day.Under advice of a shadetree mechanic, we replaced the Powertrain control Module (PCM) located behind the front bumper under the driver side headlight. This seemed to solve the problem for almost a month when the water pump decided to fail and we replaced it, the thermostat and radiator fan thermometer, only for it to die exactly as before only the very next day.The shop ran it until it died, took the pcm off and checked to see if it was overheating, but it wasnt. They checked the battery cables, fuses and anything else they could think of.
I got it it back at the beginning of October and on its first night out it died twice. I was driving it and noticed that it was a hot muggy day about 80F and because I was wary of it dying I chose not to run the AC, but the air coming from the vents was still quite cold. First time it died we popped the hood and the Eatx shutdown relay was hot enough to fry an egg. I replaced it with a spare I had, and all the systems in the van sprang back to life. It made it a mile before dying again and this time the new relay was hot, but all I did was wiggle it and back to life it went. Drove it 12 more miles home, then the next day back to the shop without incident.
I went to talk with the shop a couple days ago, because I really need this thing fixed but they are not sure what to do next. I told them about the AC running even while off and so we pulled the fuse for the AC clutch entirely. I ran it around for twenty minutes and even with the temp on the dash at normal hot position center of the gauge and blower at full tilt and set to hot with AC off, I had the coldest air until I hit a bump and suddenly I had hot air. Thinking the AC clutch was seized I took it back to the shop, verified that the compressor wasnt working anymore while engine was running and thought we may have fixed the issue.
Three days later, I have driven it all over with no issue, only for it to now die twice in a mile all within a mile of home. On the way home, the heater wasn't blowing as hot as it could be, until I almost made it to my freeway exit, by then I was worried that it was going to die after I had slowed down to the side road speed which it did happen.
I opened the driver door to get out and that was all the jarring it took to turn everything back on, the second time I had popped the hood and was reaching for the clips to the fuse cover to check the eatx shutdown relay when it all came back on. The relay was no warmer than the relay for the fuel pump. Between the first and second event, I could feel it hesitating every few seconds like it was about to lose power. After the second event I was so close to home I may have been a little lead-footed and did not notice.
Addendum: The bellows in the interior heater broke back on Valentine's day, so no matter what the dial it set to, it only blows out the upper body vents on the dash. The radio has an issue that it can no longer play tapes and one of the speakers is mostly silent. I wondered if either of these were shorting out and causing issue.
Dodge - Grandcaravan :: 2010 - Engine Quits While Vehicle Is Moving
I have a 2010 Grand Caravan, and the engine just stops while moving down the road. Once you shift to neutral, the engine starts again easily. The only common thing we've found is that the skid control light goes on. It doesn't seem to happen when going more than 30 mph, and does seem to happen more when the temps outside are changing, but both when we get a warm spell or a cold snap. The recall work on the key assembly has been done, and the key always seem to be in the on position, so it's not that known issue. The local garage couldn't find anything or even replicate the problem. The dealership replaced the spark plugs and did a fuel system cleaning. Those were probably due, but they didn't seem to work much.
View 5 RepliesDodge - Grandcaravan :: Jerky Acceleration And Check Engine Light
2010 Dodge Grand Caravan. On the way to work I was trying to accelerate from about 40mph to 50 mph and my van started to jerk a few times and then the check engine light immediately turned on. I only had a few more miles to work and it was fine the rest of the way.
View 1 RepliesDodge - Grandcaravan :: 2002 - Engine Heat Transfer To Inside And Outside By Doors?
2002 dodge grand caravan. We feel the heat from engine block inside the two front seats (driver and front passenger). We also feel heated wind (blowing strong) and smell coolant when standing outside the vehicle by the driver and front passenger door with the engine idling.
There's visual small leak, once the vehicle is parked. I wonder where the leak is (not on radiator and the radiator coolant level remains full). I bought Preston Radiator Complete Care and Stop Leaks. I haven't put it in yet, just wonder if this will work.
Dodge - Grandcaravan :: Whine Type Of Noise That Increases In Pitch As Engine Is Accelerated
I recently had to replace my drive belt on a 97' dodge grand caravan sport 3.3 engine. The belt shredded and this is how i knew i had to replace it. Since i replaced it i notice a whine type of noise that increases in pitch as the engine is accelerated. The other thing I've noticed is that all electrically related operations work better as it is accelerated. For example, the air blows harder, the wipers move faster, and the lights brighten. Now i honestly can't say that it didn't do this before i changed the belt. I wonder if a bearing is going out on a pulley. I have noticed the same behavior on my daughters 98 sable. Also note that i did get all of the pieces of the old belt out from the pulleys and i did spin each of them to make sure the were moving without any resistance.
View 8 Replies