Golf IV / Jetta IV :: 2001 - Antifreeze Boiling Out Of Overflow Tank
OK, my '01 GTI VR6 has been giving me overheating problems - I've had to replace the crack pipe, and I've been having problems with the plastic fittings (coolant lines around throttle, heater core) all breaking. Turns out the electric fans were bad, I replaced them yesterday. I did check them, neither one was coming on with the AC on, and with 12V jumpered directly to them, still no go, so it wasn't the fan controller.
I was looking forward driving my car without overheating, but that doesn't seem to be in the cards. Looks like the fans weren't the only thing wrong. The sympton I see is that the coolant overflows the coolant overflow tank, but the temp gauge, while it comes up to temp (190 degrees) it doesn't go beyond that - but I'm having coolant boiling out of the overflow tank?!
I really don't want to say out loud - but maybe a bad head gasket? I've heard there's something that's like litmus paper you can use to see if exhaust gasses are blowing into your coolant - where can I get it?
What may be wrong? Almost anything would be better than a bad head gasket! While I've been having these problems, I've not seen the temp gauge ever go beyond the center 190 degrees, what's happened is that while driving the low coolant warning will come on, I pull over, and coolant is bubbling and overflowing the tank.
Ford F-150 - 1997-2003 :: Radiator Seems To Be Leaking But Not Taking Fluid From Overflow Tank
I have a 97 F-150 and my Radiator fluid has been leaking very bad but hasn't been taking the fluid from overflow tank. Actually the new fluid that I put in the overflow has now turned a rusty color....
View 3 RepliesFord 6.7L Power Stroke Diesel :: Fuel Tank Leaking After Shutoff Valve Closed - Overflow?
I am scheduled to leave on a trip in the morning. I have installed an 85 gallon in bed auxillary fuel tank. I plumbed it in as per the instructions and the same as the last two I had in other trucks. After install I pumped 25 gallons in the aux to see how it worked. Every thing worked right. So yesterday I filled both tanks to the top and left the shutoff between them open.
This morning I noticed a puddle of diesel on the shop floor. Wiped it up and left for the golf course. Got home and found another puddle. I have closed the shut-off valve but it still seems to be leaking. It is not the plumbing I installed. It's hard to tell because I have a protector around the tank but it seems the leak is coming from the top. I just took a short run down the highway and reparked it. I have a can't miss appointment so when I get back I'll see how much has leaked.
Is there some kind of overflow on top the tank? Everything is dry where the aux tank is plumbed in and the air pipe seems to be fine. If the leak stops with the shutoff closed then I'm just gonna head out but if not then I'm gonna take down the shield and see what I can find, but I'd sure rather not.
Silverado :: 2005 - Losing Antifreeze From Overflow Jug
My truck is losing antifreeze. It seems to push it out over flow jug. I have changed thermostats. This work for temp but not problem. From what I have found this engine is reliable. 2005 Chevy Duramax....
View 2 RepliesThermostats :: Buick Lesabre - Overflow Reservoir Cap / Air, Antifreeze Got Displaced
My Buick's 03 lesabre overflow reservoir cap is screwed on and has a gasket in it so it cant possibly leak air. I'm still wondering how does air or antifreeze get displaced in a overflow reservoir container that has no outlet to breath unless its forced through only one hose at the bottom in- and there is always a little pressure in the container to push the antifreeze back into the radiator when it cools off at the radiator metal cap?
View 19 RepliesIsuzu :: Coolant Overflow Empty / Antifreeze Puddle On The Ground
Have a 2007 Isuzu I290 four cylinder with 5 speed manual transmission with 116000 miles on it. have used Mobile One oil from day one and replace it and the filter about every 8000 miles. Twice in the last 20,000 miles the coolant overflow tank has been empty and an antifreeze puddle on the ground. Both times it was just before an oil change so the truck had gone roughly 8K and the engine oil was down about a half quart to a quart. Engine temperature gauge stayed normal, midway on the gauge, or very slightly above normal, never got hot. Can’t find a leak in the coolant overflow tank or hoses. thought it might be tied to the low oil so was going to check it on a more regular basis and keep it topped up. other than the coolant puddle twice, nothing leaks on it and thus far has been a nice, reliable, maintenance free truck.
View 12 RepliesNissan :: Overheating / Radiator Overflow Tank Low
My 1992 Nissan Primera 2.0 slx is overheating, probably on its last legs. First time this happened the radiator overflow tank seemed low so I topped it up with glycerol and added some leak plugger to the radiator for good measure. The car drove just fine for 20-30km then it happened again. At the same time, and I don't know if this is relevant, the windscreen defroster, which should bleed warm engine air, now only gives cold.
View 3 RepliesSonata NF (2006-10) :: Gas Tank Overflow Stop
Having a problem with the 2008 Sonata GLS. When filling gas tank, pump nozzle clicks off, but gas flow continues, creating a significant spillage.
View 7 RepliesPlymouth - Breeze :: Possible To Replace Overflow Tube For Gas Tank
I was wondering if I can replace my overflow tube for my gas tank without replacing the whole gas tank. I know I will have to drop the tank and get new straps to install it, but would I need a completely new tank or can I buy an overflow tube separately?
View 3 RepliesPassat (B5) :: Gas Tank Overflow At Fill-up / Venting System?
When filling the gas tank, the pump shuts-off (as it should) unless the tank filled very-very slowly. It has overflowed/spilled before the pump even shut-off in some cases.
CEL is not on. DTC 16826 stored: "EVAP Emission Contrl.Sys (small leak) Leak Detected". I just got a VAG-COM cable but haven't got the software going
yet.
Bentley has some diagrams for the fuel vapor recovery system but that's about it. Seems like there's something with the fuel vapor recovery / venting system going on. How to further diagnose?
'01 Passat 1.8T ....
Eclipse - Mitsubishi :: Air Bubbling Into Overflow Tank From Radiator
1998 Mitsubishi Eclipse. 2.0L 5-speed. 195,000. When I complete my 33 mile trip home and shut off engine, I can hear air bubbling into the overflow tank from radiator. Temp gauge shows normal. Just had new water pump, thermostat, radiator flush and refill and new 16 lb radiator cap installed. Overflow tank fills up to near top (not running over) and when engine cools, the tank is back down to half way. I've checked water level in radiator when cool and it is full. Question: Is this normal? Don't think I've ever noticed or heard the bubbling sound before. The engine runs great and smoothly.
View 5 RepliesCelica :: 1993 5sfe - Coolant Overflow Tank Hoses On Cap?
Just finished a timing belt job on my 93 celica 5sfe. Filled the coolant up and burped engine. All seems to be well. My question is related to the coolant overflow tank. The cap has a hose attached on one end coming from the radiator and another coming out the other side that is short and L shaped. The L shaped hose isn't attached to anything and is open allowing air to either vent out or vent in to the overflow tank. There isn't any place nearby where the hose might attach to. Is this hose supposed to be "unattached" as it is now or should it be closed to create vacuum for the overflow tank to allow coolant back in to the radiator?
View 4 RepliesPrius (2004-09) :: Reservoir / Overflow Inverter Tank Leak?
Aside from other issues I am having with my prius, this was one lurking. I originally thought the prius was "using" the coolant insufficiently. Anyhow, I bought this prius from a private dealer....(know how that goes)......
View 15 RepliesFord F-150 - 1997-2003 :: Rear Fuel Tank Overflow
1996 F-150 5.0... So I bought this truck a couple months ago for a really good price and its my regular vehicle that I use daily. While driving I switched tanks from the front to rear and when i reached my destination i noticed that fuel spilled from the cap, I opened the cap and fuel overflowed. I've read in forums saying that its the Fuel Pressure Regulator or the Fuel Tank Selector Valve . It still drives and runs fine, but I would like to know which part its specifically causing the problem?
View 1 RepliesFord Ranger / B-Series :: Very Slow Leak In Overflow Tank
My overflow tank seems to be going empty slowly. The last time I filled it was in March and I filled it to the Full line. Now, the overflow is almost empty. I did 425 KM last night almost non-stop and the level stayed the same since that night and today. So, I am not burning any thru the gaskets. Exhaust is not white neither.
I did see one suspect thought. I have this really small rad at the bottom of the bumper and it seems a little wet around the tubes that enter it. Could it be that? I have no spots on the driveway or road when I park. Specs of my truck:
190 000 KM.
Oil changed on Saturday.
Runs well, no loss of power.
Temps are good.
Ford A/C :: 1964 F100 - Coolant Overflow Tank Installation?
I got a 64 F100 with a 292 that I am thinking of installing a coolant overflow tank on to aliviate having to fill the radiator frequently.
The question being............Is it a sealed system or do I need to provide an air bleed to adjust for the presure change within the cylinder I intend to use?
I realise that thermal syphoning will return the coolant to the radiator but am unsure as to weather or not I need to allow the airspace to remain at atmospheric pressure.
Jeep - Cherokee :: 2001 - Overflow Tank Is Boiling Over But Engine Is Not Overheating
2001 Jeep Cherokee sport ... Just bought this Jeep with 145K miles. Had radiator and all hoses replaced. The overflow tank is boiling over but the engine is not overheating. Safe to drive? What should I be checking for?
View 13 RepliesCamry :: 2006 - Coolant Residue On Radiator / Overflow Tank Caps
While I was looking at my coolant level in the overflow tank yesterday I noticed pinkish coolant residue on the overflow tank cap and then looked at the radiator cap and it was covered in the same pinkish coolant residue.
2006 Cam LE 4 Cylinder, 52,000. Already done 2 coolant drain and fills--the Head bolt issue scares me.....
Ford Excursion :: Coolant Puking And Overflow Tank Smells Like Exhaust
I have owned my 2005 v10 ex since 60000 miles. Have had many dependable family road trips and love my truck.
Recently it has started puking coolant and the overflow tank smells like exhaust. The oil cap has some coolant sludge on it. But there is no coolant mixed with the oil. Or oil in the coolant.
I am pretty certain these are the signs of failing head gaskets. The truck has 193000 miles on it now.
Want to keep it on course. But keep it reliable. So do I buy new engine or do I just replace head gaskets?