Yaris/Scion & Vitz :: Clutch Judder Before Engaging / First And Second Gear Stiff To Select
I have a 2003 1.3 Yaris T Spirit VVTi.
I am told I need a new clutch. First and second gear can be stiff to select, especially in cold weather, and the pedal has to be floored to change gear. The bite point is very high, and the clutch can judder before engaging but we are so used to it this only occurs occasionally at slow speeds.
However, the clutch does not slip in any gear and as I say it doesn't cause us any real problems because we are so used to it. The car has done 107,000 miles and has the original clutch (as far as I know).
Should the clutch be replaced?
Yaris/Scion & Vitz :: 2002 - No Cold Air But The Fan Still Blows
When I turn the a/c on, sometimes the compressor engages and sometimes it does not. When it does, I feel the engine's idle change and out comes very cold air. After a few minutes or longer, no more cold air but the fan is still blowing. If I quickly turn the a/c off and then back on again this seems to jump start the compressor and poof, out comes the cool air again. Sometimes it will begin producing cool air again on its own but most of the time I have to resort to turning it off, then back on. I don't believe I have a leak because otherwise no cool air would be emitted at all or the quality of the cool air would be poor.
View 2 RepliesYaris/Scion & Vitz :: 2002 - Sputtering At Acceleration At 40 Mph
I have a 2002 echo with 168K miles. My car was doing fine but I decided to change the air filter and spark plugs because I had a feeling the person I bought it from hadn't done it. All spark plugs needed to be changed (first 2 were hand loose also). I put in autolite platinum ( I believe bosch platinum were in there). All was fine until 5 days later the car started sputtering at acceleration at 40 mph. Then a few days later it would sputter at first pressing gas then again at 30mph and at 40mph. I let it go and read to clean air flow sensor but haven't yet.
About 2 weeks later it finally produced a code that cylinder 2 misfired. I noticed at that point the sputtering would only be when warmed up. I was going to put in bosch's to see if that would fix it but instead just had time to inspect plugs and coils. Nothing seemed wrong so I put them back in for now. This was Saturday.Echo ran fine until this morning. Now it is sputtering at 40mph. I assume if i let it go it will do the same thing. Can it be the spark plugs are bad and I should be using bosch's or is there another problem i should be looking at?
Yaris/Scion & Vitz :: How To Remove Headlights From 2002 Echo
how to remove the headlights from an '02 echo? I'm trying to paint the headlight bezel, and can't seem to get the headlights out.
View 2 RepliesYaris/Scion & Vitz :: 2002 Echo Misfire That Goes Away During Idle
Mother in laws car had a bad misfire that goes away during idle. It seems to misfire during take off or slowing to a stop and Intermittently during cruise.
Came in with codes p0300 - random misfire and p0304 misfire cylinder 4
What I have done so far.
-Checked the oil
-Checked the plugs - they were bad so replaced them with ngk plugs
-part number - BKR5EGP
Misfire was showing in cylinder 4 on live data still
-Swapped coil 4 and 1
-Misfire moved to cylinder 1
-Swapped cylinder 1 with 3 to be extra sure and mis stayed on 1
-Swapped back to 4 and even 2 mis stayed in 1. Weird
-Pulled all plugs and checked compression getting 170psi
-Swapped plugs around in case 1 is faulty no luck
-Swapped number 1 and 2 injectors with no change.
So my thoughts now are leaning towards an ecm or a valve thing but would those not be on or off fails? It idles great and cruises great it's only bad we coming to and leaving stop.
Yaris/Scion & Vitz :: 2002 Echo Losing Power On Hills
My 2002 Echo Sportivo is losing power on hills,which is bad news as live in a hilly district. If I don't get a run up i.e lights change it's 40km/h all the way with my foot to the floor and lots of angry drivers behind me. Apart from this runs well?
View 1 RepliesYaris/Scion & Vitz :: 2002 Echo Started Popping Out Of Reverse
My car started popping out of reverse a little while ago and its started happening more often. I asked my mechanic uncle about it and he said its probably the synchronous. From my understanding, that means a rebuild of the tranny. I just got this car in Nov after writing off my Corolla in Oct. Is there anything else minor I could check?
View 3 RepliesYaris/Scion & Vitz :: Small Exhaust Leak On 2002 Echo
First car is an '02 echo and has some things that need to be done. Small exhaust leak, but i don't know where the leak is, how to find it, new one? Where to get replacement taillights, hole in mine.
View 3 RepliesYaris/Scion & Vitz :: 2002 Echo Dying At Idle / Sometimes Restarts
My Echo died on me this morning and would not restart. I was at a light at the time. I pushed it aside, waited a bit and it restarted. I made it to work and it died again after several hiccups along the way. It then died in my parking spot but would restart. It has 192k miles on it.
It was acting weird earlier this week in that it would lose power (not electricity) while moving and then continue on. It seemed to work if I gave it more throttle. I feel like its fuel related but I don't have a lot of spare money to guess at the problem unsuccessfully.
Yaris/Scion & Vitz :: 2002 Echo - Beeping From Under Bonnet Then Engine Stopped
I have a 2002 echo 1.3 vvti - will it has been running great and has 200000km on clock . However today i started it it ran for about 1 min then i heard a beeping from under the bonnet, the engine then stopped. The car will start and run for less than a sec then die. will not run no matter how much i play with the throttle .
View 2 RepliesYaris/Scion & Vitz :: 2002 Echo Started Smoking Blue - Low Compression
I just bought a 2002 echo recently and it started smoking blue. The car has 135000 miles which seems low to me to be blowing smoke so soon. I grew up around cars since my dad was a mechanic so I checked the compression on a cold engine. Cyl. 1 was 117psi, cyl. 2 was 134, cyl.3 was 127 and cyl. 4 was 117. I realize they are low but the car is blowing a pretty good amount. The car drives pretty good overall and seems to have power, i drove it on the freeway a few times and did 80mph fairly easy. I was wondering if this could possibly be valve stem seals gone bad? I will check the pcv valve as well. I really like the car and have read a lot of good things about the echo.
View 14 RepliesYaris/Scion & Vitz :: 2002 Echo - How To Remove Rear Seats For More Storage
I have a 2002 Echo sedan. I'd like to remove the rear seats completely for more storage (I am a musician). I was able to get the bottom foam off, but the seat "backs" are more stubborn. I see there are two bolts on the floor frame in the middle of the seat backs, and one bolt on each side of the seats where they meet the doors/frame. I tried to remove the bolts on the metal floor, but they do not budge... One socket wrench sheared right off while trying to spin it loose, and when I used a socket bit on my drill with an impact wrench attachment, it still wont budge... Are they locktitied in?
View 1 RepliesYaris/Scion & Vitz :: 2002 Echo Horn Doesn't Work Consistently
My horn doesn't work consistently. Problem started about 6 months ago. Airbag never been deployed. Never wrecked the car. No liquids ever spilled on steering wheel. There is nothing that could be identified as a precipitating event.
View 8 RepliesYaris/Scion & Vitz :: Toyota Echo 2002 Noise When Driving In Reverse
I have an automatic 2002 Echo. Like 2 or 3 days ago I started hearing a noise when I drive in reverse. Is a mix of friction and vibration and it gets louder the faster I drive, only in reverse. I read that this could be the symptom of a bad engine mount but I haven't been able to pinpoint it.
View 1 RepliesYaris/Scion & Vitz :: 2002 Echo Misfire And Lose Power When Accelerating
Driving on friday night, started to hear at idle the car rpms wavering. Drove home fine with no issues other than at idle. Then Sunday, drove the vehicle, and sometimes had issues when accelerating, seemed to misfire and lose power. Then when driving that day it died completely and wouldn't start. It turns, but no firing.
Got it towed to my place, ran the codes, showed 1300, 1305, 1310, and 1315. All to do with ignition coils. Did a quick spark check, and no spark at any cylinders. I figured it would be weird that all 4 would go at the same time, so i replaced the ECM instead. Still no spark. Where to go next? Also the car does have an immobilizer in it...that could be causing it to malfunction?
Yaris/Scion & Vitz :: 2002 - Coolant And Check Engine Light Came On, No Spark
I just purchased a manual 02 echo coupe with 140k, It has been sitting for over 4 years as it has some type of wiring issue, I replaced the ECM thinking it was that and has the same symptoms. With key "off" the check engine light is on (about half bright) and the blue coolant light (full brightness) Forgot to mention another big problem, When I plug in the scanner there is no communication.
From what the old owner told me, He had a clutch put in it and the battery was installed backwards and it burnt the ECM. I'm thinking he bought the car as is and never got it running.
I read that the power goes through the instrument cluster. I'm going to pick one up from the junkyard tomorrow (off a 2000 manual echo).
Symptoms:
No communication to ECM
Coolant and check engine light stay on when switch is off
No spark at any of the four coils.
Replacement ECU did not fix anything.
I cleaned the three ground points in the engine bay.
I sprayed starting fluid hoping it was a fuel problem.
Yaris/Scion & Vitz :: 2002 - Cold Temperatures Outside And No Heat Inside Echo
My 2002 Echo doesn't seem to be producing much heat. I have a scangauge installed, and it shows my temperatures around 75-80 C while our current temperatures here are around -20 C. I'm getting a bit of heat out of the vents but hardly enough to keep me warm.
I noticed that the coolant temperature will also drop a bit when I'm sitting idle listening to the radio before heading into our building at work. From about 85C to 70C, and the vents blow cold air.
My Radiator & Expansion tank are filled to proper level. I have just installed some cardboard inside the grille to try and block some of the cold air from entering. I haven't tested this out yet though.
Yaris/Scion & Vitz :: 2002 - Popping Noise And AC Immediately Stopped Being Cold
The other day I was leaving work and I switched on the ac. I heard an audible popping noise and the air immediately stopped being cold. I pulled over and popped the hood, it smelled like freon and I'm sure it was mixed with compressor oil as there is oil stains all around the compressor now. Did I blow my compressor? Is there a blow off valve that could have been tripped? The compressor is not kicking on now, I don't know if it is blown or this is due to all the freon spraying out? It had been squealing on startup for a little while, I assumed it was a belt.... 2002 echo....
View 4 RepliesYaris/Scion & Vitz :: 2002 Echo - Testing Ignition Coils With A Volt / OHM Meter
I need to know what the resistance should be on my 2002 Echo's coils. I have an intermittent sputtering problem and it's driving me nuts! I put E3 spark plugs in the car about a year ago to improve the power and economy (it was on the original plugs at 160k miles!!) and they did work a lot but not long after that the sputtering problem started.
The car does have a code for the pre-converter O2 sensor but I replaced it, cleared the code and it keeps coming back. I have not pulled the codes recently but will in the next few days.
I've also read that the fuel filter is inside the gas tank but there is an access port under the back seat. I doubt that would cause the intermittent problem but I could be wrong.