Ford 7.3L Power Stroke (1999-2003) :: Oil Leaking From Turbo Area?
So my understanding is that if your turbo is leaking oil, you either need to rebuild it or get a new turbo cause the one you have is shot.
I have some oil leaking, but it's not a ton. One one of my buddies was telling me that it's possible that the amount that is leaking is normal due to the PCV (Pressure Control Valve) system, or something like that. Here are a few shots of the turbo, as well as the boots that are leading up to the turbo.
Passat (B5) :: Turbo Leaking Cause White Smoke To Blow Out Of Exhaust
What are the repercussions of my turbo leaking, and how do I fix it? Could this cause white smoke to blow out of my exhaust when i take off after the car idles for about 10 minutes, the smoke goes away, but if I let it idle again for about 10 minutes it blows out more smoke. Also the oil consumption is really high, obviously due to the oil leak, is the turbo bad, do I need to change it?
View 2 RepliesFord 6.0L Power Stroke Diesel :: High Pitch Whistle Noise From Turbo / Exhaust Area
For a while now, I have been hearing a very high pitch whistle noise from the turbo/exhaust area. Everybody told me it was an exhaust leak, but I never could pin point the leak. While I was under the truck last weekend I found the flex joint on the passenger side up pipe was broken a leaking.
I ordered a Dorman replacement pipe that comes with a new gasket and hardware.
I will be the first to admit, I am not a fan of Dorman parts... BUT, this pipe is really nice. It looks identical to the pipe being sold on Dieselsite.com, it doesn't have the scoop inside to direct exhaust gas to the EGR cooler and it comes with all the mounting hardware.
[URL] ....
Once I got the turbo down pipe out of the way and soaked the bolts with penetrating oil, I had the broken up pipe off in 30 minutes.
Volvo :: Crank Pulley Timing Position For Volvo 940 Turbo?
What are the correct timing marks and positions for a Volvo 940 Turbo? I especially need the position of the crankshaft pulley. I have read the timing mark is on the cover, but unfortunately mine has dry rotted and crumbled away.
View 1 RepliesFord Exhaust System :: Exhaust Manifold Leaking / Louder Than Normal Knock When Accelerating
Leaking exhaust manifold? The truck has a much louder than normal "knock" when accelerating. At first I thought and had some bad fuel in the tank. I eliminated that with a full take of good fuel and some STP but the "knocking" continued. Then I thought that perhaps it wasn't firing on all cylinders but it felt like it had full power. I took it to my mechanic and he said it as a exhaust manifold leak. He said that he has never replaced the exhaust manifold but that it was a "nightmare" and expensive. He also said that it's not a safety issue but on the long run the leak would cause the truck not to pass its emission test. He said the problem was with rusted bolts that would be difficult to remove.
View 12 RepliesPassat (B6) :: Oil Dripping From The Turbo Area
I took the wagon to the dealer for servicing due to an oil leak. However, before taking it in, I put the car up on ramps and took a peek to see what was the culprit. I noticed that oil was dripping from the turbo area. Nine days ago they performed the following repair:
--> Cause:Gasket for the turbocharger pipe leaking.
--> Fix: Installed a new gasket, added engine dye to check for any other leaks and no more leaks were found after repair.
However, today I noticed oil in my garage floor again from the same spot.
Volvo :: What Causes 1991 Turbo 740 To Run / Not Start / Run Again
I recently purchased a 1991 Volvo Turbo 740 with 186,000 miles on it. It runs perfect for a few days and then when parked will not start. Attempt to start 1/2 hour later it starts and runs perfect again. It has done that for several days now. I have driven it to locations approximately 40 miles round trip with frequent stops for a period of time and then start up again. This AM it started up perfect as I moved it from a driveway to part in front of my house on the street. Several hours later I went to start it but it would not start. 1/2 hour later I decided to try one more time before calling the tow truck to take to a mechanics and it started up perfect again. I drove it to the library and bank later and ran perfect after the two stops. This is driving me nuts since I had taken it to a mechanic when it did this Monday and it ran great at the mechanics and he could not determine what was wrong. He told me WHEN it stops again to have it towed in and he could determine at that time when it was not running.
View 7 RepliesVolvo :: 94 850 Turbo - Car Randomly Filling With Smoke
94 850 turbo will randomly smoke like crazy at which time it fills the car with smoke completely fogs whatever street you're on.
View 1 RepliesVolvo :: 1987 / 740 Turbo Has No Power On Boost
It starts and idles fine and drives fine until the turbo spools and gets past atmospheric.. at this point the acceleration gets worse even though you can clearly hear the turbo blowing (gauge well into the yellow).. checked the ground connections on the head and intake, seemed good, replaced tps, replaced knock sensor, replaced hall sensor, tried another ecu, checked cam timing. Had a volvo mechanic friend looking at it prior to my fiddling with it and he seemed to think the ignition timing was retarded too much.. but I've done everything i can think of to tackle that problem.
View 3 RepliesVolvo :: 760 Turbo Will Not Idle Properly - Rough Between 55 And 70
760 turbo intercooler 2.3 4-speed auto. It will not idle properly but when you run it around town it is fine, smooth and powerful. If you take it out on the motorway it will be ok for speeds up to 55 (lumpy going uphill) if you push it over 70 it is ok, but between 55 and 70 it is rough and sort of misses without backfiring. Also a cloud of black smoke comes out of the exhaust. If you kick it down to 3rd it will go like a rocket and not miss at all!! It has been seen by the RAC and been in the garage and they say everything is working, but can't check the air flowmeter as it would cost too much to buy one and it works fine.
View 3 RepliesVolvo :: 740 Turbo Drop Every Few Seconds When Idling
I have a problem with my 1988 740 Turbo. It starts and runs fine, but when cold it experiences a drop every few seconds when idling. In other words, when idling cold, it will act as though the key was turned off but just before stopping completely it catches and continues to run.
I guess I'm trying to describe something other than rough running, or a poor idle - this is more like an ignition short where the engine completely stops (but never does). The tach needle shows this also. It continues doing this while accelerating around the neighborhood but once the car is at operating temp it smooths out. I live in San Diego so it never gets cold here.
The car was tuned up last year and the distributor was replaced at the same time. New cap, wires, plugs. Car has close to 290K and still runs great except for this issue.
Volvo - S80 :: 1999 Turbo 2.8L - Cooling Fan Relay Bad
My 1999 Volvo has been diagnosed by a Volvo dealer to have a bad "cooling fan relay". Another shop analysis states the "cooling motor fan assembly module" is the problem. Are these one in the same? Can I replace it with one from the salvage yard? Are there any bad omens with messing up other electronic components If I make the repair myself?
View 9 RepliesVolvo - 850 :: 1994 Turbo Car Cranks But Does Not Start
My 1994 850 turbo will crank but will not start. it started when the car was having trouble accelerating past 40 mph and felt like it was kicking back then it died on the freeway and now will not start. i ran the error codes and got these back, from A2 452, 455, 543, 544, 545, 552, 555 and from A7 122. I'm not sure what to do?
View 4 RepliesVolvo :: 1994 / 940 Non-turbo Over Heated - Head Lights Won't Go Off
The past summer my 1994 Volvo 940 non-turbo over heated and we worked on the coolant system and got it working god again. However just after we fixed it the headlights blew out and we replaced them and then they blew out again. The battery was also going dead when the car was turned off and all electric things were turned off. Now the head lights don't blow but once they are turned on with the switch in the car they cant be turned off unless the battery is disconnected.
Also as of now none of the dash board instruments are working. With the car on and the lights turned on we pulled the connector to the switch that turns on the lights, that is on the dashboard, and the lights still stayed on. We can only think that some water may be causing the problem but it may or may not. I need to know how to fix the headlight problem and the instrument panel.
Volvo :: 850 Turbo 1997 Heat Up - Engine Off After 5 Minutes?
My Volvo 850 turbo 1997 heat up after i change head gasket every thing is OK after 5 minutes off automatically. Any sensor problem.
View 1 RepliesVolvo :: 1998 740gl Turbo Stalling And Not Starting?
i have just bought a 1988 740gl turbo and i was driving it the other day and when i came to a set of lights just as i stopped the car stalled on me then wouldn't start...
i left it for a hour or so came back and it started and i drove away and only went a few kms home.... what would this be i haven't driven it since!!
Volvo :: 1996 850 Turbo Wagon Engine Knock?
I just got my 1996 volvo 850 turbo wagon running, after I replaced a valve, lapped all the valves and replaced all valve stem seals/full stage zero(timing belt, plugs, wires, cap, rotor, thermostat). Boy was she a strong runner, for the whole day it was running. I do admit to abusing it quite a bit. But what else would you expect from an 18 year old kid who just rebuilt his first volvo engine ? Now, i will note that the car had horrid previous owners, that took no care of the car(ran it low on oil and who knows what else). I know I ran it out of oil once, on the way home from buying it.....the guy did not put the oil filter on tight enough, and it blew the oil filter seal out. Luckily volvo's have low oil sensors. after i rebuilt the top end my engine was throwing out blue smoke for a while, but i thought it was just a bad turbo bearing.
Anyways, to cut to the chase; My engine sounds like this one. [URL]......
I did a compression check, all cylinders at 180 psi. all my lifters look good. I had a few plugged oil passages in the cam cover, but none that go to the lifters. i pushed on all valve springs, they look good. i used a screwdriver and hammer to check if the valve guides pulled out, and the valves are solid in place. I was still making boost even though the engine was knocking like this, so i know its not a rod bearing, because the knock sensors would have picked up on it and dropped the boost.
Volvo :: 1991 Turbo 740 - Changing Timing Belt?
I am acquiring a 1991 Volvo 740 Turbo and am concerned about the need to change the timing belt. The seller does not have record of it being changed since he had the car for two years. He had only put about 10,000 miles on it since he had acquired it. It now has 186,000 miles and runs perfect and basically in good shape for its age. If the belt breaks does it ruin the engine?
View 2 RepliesVolvo :: 1994 940 Turbo Won't Rev Up Past 2500 Rpm In Drive
I have a 1994 volvo 940 turbo, the transmission has been fine, but today out of nowhere the car will not rev past 2500rpm. But only when its in drive, if i drop it to 1st or 2nd it will rev fine?
View 1 Replies