Volvo :: 1996 850 Turbo Wagon Engine Knock?
I just got my 1996 volvo 850 turbo wagon running, after I replaced a valve, lapped all the valves and replaced all valve stem seals/full stage zero(timing belt, plugs, wires, cap, rotor, thermostat). Boy was she a strong runner, for the whole day it was running. I do admit to abusing it quite a bit. But what else would you expect from an 18 year old kid who just rebuilt his first volvo engine ? Now, i will note that the car had horrid previous owners, that took no care of the car(ran it low on oil and who knows what else). I know I ran it out of oil once, on the way home from buying it.....the guy did not put the oil filter on tight enough, and it blew the oil filter seal out. Luckily volvo's have low oil sensors. after i rebuilt the top end my engine was throwing out blue smoke for a while, but i thought it was just a bad turbo bearing.
Anyways, to cut to the chase; My engine sounds like this one. [URL]......
I did a compression check, all cylinders at 180 psi. all my lifters look good. I had a few plugged oil passages in the cam cover, but none that go to the lifters. i pushed on all valve springs, they look good. i used a screwdriver and hammer to check if the valve guides pulled out, and the valves are solid in place. I was still making boost even though the engine was knocking like this, so i know its not a rod bearing, because the knock sensors would have picked up on it and dropped the boost.
Volvo :: 1982 Turbo Wagon Hesitation And Stumbling When Hot
I'm a newbie who just took ownership of a 1982 turbo wagon. It's been sitting a while but started right up and ran well for about 20 miles until it began stumbling on acceleration.
The car starts easily and runs smoothly until it gets hot and then it suffers severe hesitation and stumbling. Occasionally it will stall but starts right up again. It has never failed to restart immediately.
On a cool day, it will run smoothly for thirty minutes or more before the problem begins. On a hot day, the problem begins in five minutes.
Volvo :: 1994 / 940 Non Turbo Wagon - Taillights Won't Come On When Lights Switch Is On
I have a 1994 Volvo 940 non turbo wagon. I just started having issues with the brakes lights and taillights not working. I have checked all the fuses visually and also did a continuity test on each one found all the fuses were good. I have replaced the all the relays, I have replaced the large red relay ( bulb failure relay ) and even did a continuity check on the bulb failure relay pins that are specifically for the rear brake light, everything checked out fine. I hesitate to change the brake light switch because the third brake light is working fine. I have considered replacing the headlight switch due to the taillights won't come on when the lights switch is on. My headlights do work though. There is no light on the dash indicating a bulb is out now since I replaced the third brake light bulb.
1994 Volvo 940 wagon
Non turbo
Volvo :: 1994 850 Turbo Wagon Starts Rough And Idles Very High
My 94 850 turbo wagon starts rough and idles very high. the rpms dont come down. After turning car off, wont restart again unless I let in sit for a while.
View 11 RepliesVolvo :: 1989 740 Turbo Wagon Won't Start - No Noise From Fuel Pump
I recently bought this car in its current no start condition after sitting 3 years. Initially I jumped it off and it just cranked, no attempt to start and no noise from either fuel pump.
I checked the fuses and the fuel pump relay behind/under the radio and it clicked and was dated 2006 so it had been replaced. I assumed it was replaced when the under car fuel pump was replaced at it was a replacement.
I sprayed a little starting fluid and it fired right up and ran until used up.
I ordered both pumps and strainer and installed the under car pump earlier this week. The in tank pump and strainer looked horrible and original. There was a small issue with the return line on the in tank fuel pump sending unit when I removed it that required brazing which I got back from the shop today.
This afternoon I installed the in tank pump & strainer on the sending unit and installed all that stuff. I spliced in a quick disconnect in the wiring harness for easy separation/installation next time.
Jumped the car again [yeah needs a battery] after everything was hooked back up and no in tank pump heard with key on to prime several times and no start although I hear the under car pump quit after attempting to start and they turned off.
Is there any other fuse/relay to check? If the under car fuel pump is evidently working, wouldn't it pull fuel without the in tank pump coming on? There's about 3 gallons in the tank. I'm going to test if there's current to the in tank pump tomorrow.
Volvo :: 1995 Turbo Wagon - Engine Holding High RPMs Between Shifts
I am new to my car. It is an '95 turbo wagon with a 5 speed conversion and a ARP orange ECU. The issue is the car is holding shift rpm for 4-5 seconds after I take my foot off the gas. Since I am taking the load off the motor when I clutch in, it actually climbs higher before it drops off. Needless to say it is not really drivable in traffic that way! The idle rpm is ok and the car pulls really well when accelerating. I have checked for vacuum leaks and I am heading for the Idle Air Control valve. I don't think the engine has any other mods and it is pretty high milage (188k).
View 1 RepliesVolvo :: 740 Turbo Wagon Cuts Out While Driving When Engine Reaches Its Normal Temperature
My 1989 740 Turbo wagon cuts out while I'm driving. It only ever does it at about the point when the engine first reaches its normal operating temperature. It can cut out while idling or when driving at normal speed. I'm not sure if it's related to temperature or time (it usually cuts out at about the 5-8 minute mark), or if this is simply coincidental. It does it nearly every day.
It's definitely caused by the fuel pump relay cutting out. I've replaced this already, with no improvement. Something is causing the relay to suddenly lose an input.
Once cut, it takes a few quick flicks of the key to the START position for the fuel pump relay to receive power again. It will then drive faultlessly for the rest of the day. Although, if allowed to sit and cool for many hours, it will sometimes do this again.
Volvo :: 1989 740 Wagon Fires But Will Not Start / Engine Instantly Died
I have an '89 740 wagon, Bosch ignition. It will not start. If I spray starter fluid, it will fire, then immediately die. I have replaced already both fuel pumps, noise suppressor/fuel injector relay, fuel pump relays.
I installed a fuse in the fuse box, which was empty when I purchased the car. And the engine instantly died. It did start up when the fuse was removed, and I drove it back across country. The idle got worse until it died and would not start back home.
Volvo :: 1996 850r Wagon Transmission Cranks Over Fine But Won't Light
I purchased a 1996 850r wagon about a year ago, she has some minor issues and most have been fixed but on my way home the shift arrow started flashing as well as the winter drive light, shut the car off at the store with the intention of looking at it when I got home... car will not start now... cranks over fine but wont light... I dont have access to a reader until next week when it gets returned to me...
View 7 RepliesPrius (2004-09) :: 2006 - Master Warning Light Came On / Car Died On Freeway
My master warnIng lIght came on In my car.I took my car into Hooman Toyota in Long Beach, California. They did a diagnostic test and performed their MPI WORLD CLASS INSPECTION. While I was getting it tested they said the invert water pump was under recall. No biggie. Nothing was found in the diagnostic and the recall was fixed.
Two days later I took my car to Palms Springs. While I was driving out there the master warning light came on. I started to lose power but it seemed like the computer would reset and it would be ok for about 15 minutes. I even lost power in the engine. I finally made it out there and figured it just needed to rest. 6 hours later I took off for home. 10 minutes into it the lights on the dashboard came on. The car lost all power and I was stranded off the freeway. My battery was down to 1 bar. I left it there overnight and had it towed to the nearest Toyota dealer. They said I need a new battery and that theirs bad gas. They wanted to replace the fuel tank. I replaced the battery.
The next day they said that wasn't it and was going to continue searching. I ended up towing it to my mechanic. He said there was no coolant and the headers are blown. He said I was better off getting a new engine. Let me take you back two days when that WORLD CLASS MPI INSPECTION was done. There was an 8 page report specifying what was passed on the inspection. The battery, coolant levels along with other fluids passed. Not to mention hoses and clamps and about 30 other things. I feel something was missed in that WORLD CLASS INSPECTION. I feel they are responsible for the car ending up the way it was.
Volvo :: 1996 850 Turbo Sedan - Fuel Gauge Needle Not Going Up All The Way
Have 1996 850 Turbo sedan. When tank is full the gas gauge needle will only go up 2/3 of the way, when nearing empty, needle is below red line. Gas light does work. Can I just remove instrum. Cluster and manually turn needle to top (after a fill up)? If not can I just replace the gauge/motor behind panel or do I have to replace instrument cluster?
View 2 RepliesVolvo :: 1996 850 Turbo Misfires When Warmed Up After Cold Start
This 1996 (220KM) car will run fine (perfect)for about ten minutes from cold (I'm talking -5 C)then starts to misfire when warmed up. Difficult to pull away (automatic) from a stop. Sound like its missing on two cylinders. Really chunters.
Installed new plugs, wires, cap, rotor, coil,filter. Don't know what to check next. Car will work at speed but I can feel it missing. Gun it and it will go. Doesn't appear to be a fuel problem.
Volvo :: 1991 - Died Again - Warning Lights Came On
I was driving my 91 Volvo 940 Turbo Wagon yesterday morning when, out of the blue, the warning lights came on and the engine shut down. I was still able to utilize the wipers and radio as I sat there for an hour waiting for a tow, but whenever I attempted to start the engine, I got a few rumbles but the engine would not turn over. All belts seem to be in place. I just had the water pump replaced. I replaced the alternator 2 years ago when I first bought the car and installed a new battery about 1 year ago.
Any thoughts on what could be the root problem here?
Subaru - Legacy :: 1996 Died Without Any Warning When Going About 30 Mph
I own a 1996 Subaru Legacy (2.2L), and when I was almost home, my car died. I was going about 30 mph, and without any warning, I lost power to my headlights, my gauges, my power steering - everything. I lost all power to my car. When trying to start it again, nothing happens when I turn the key - no lights, no fuel pump...nothing. It has to be something electrical (obviously), but I would like to know what it is before I send it off to the mechanic.
View 9 RepliesPrius (2001-03) :: Suddenly Dies In The Middle Of Freeway
I'm at a loss here, I bought a salvaged 2001 Prius at an insurance auction and fixed it up. After driving it for about a year the car suddenly dies on me in the middle of the freeway and i had to pull it over. the car hasn't started since. I can get it to turn on but the engine won't turn, and whenever I turn the steering wheel more than 45 degrees it makes this electrical sound the wheels jerks back to the original position and the PS message beeps on. I brought it to a dealership and they said it was a problem with the transaxle but they weren't sure.
View 8 RepliesVolvo :: Crank Pulley Timing Position For Volvo 940 Turbo?
What are the correct timing marks and positions for a Volvo 940 Turbo? I especially need the position of the crankshaft pulley. I have read the timing mark is on the cover, but unfortunately mine has dry rotted and crumbled away.
View 1 RepliesPassat (B5) :: 1999 GLS Wagon Died At A Stop Light And Won't Start
My 1999 GLS Wagon died on me at a stop light. The motor turns but won't start. Replaced fuel pump, filter, fuse, and relay on advice from a few friends. Still no go. Another friend recommended I check the crank sensor.
View 1 RepliesToyota - Camry :: 1989 - Died Now Station Wagon Won't Start?
I have a 1989 Toyota Camry station wagon. I was driving it tonight on a slow neighborhood street and it just died. When I tried to start it back up, it won't start. I have power, all lights and things at full strength. When trying to start it it makes a high-pitched whirring screeching sound. I don't know where the starter is located, but the sound seems to be coming from around the spark plugs or behind/under them.
View 2 RepliesVolvo - 960 :: New Battery In Station Wagon Still Won't Start
I have a 1997 Volvo 960 station wagon. It has been sitting in the driveway for 5 months. I went to drive it and it wouldn't start. We jumped it and it ran but wouldn't hold a charge. The battery was about 7 years old so we went and bought a new battery. We took the old battery out and replaced it and now it does nothing. It won't start and there is no sign of power to the car at all.
View 5 Replies