Trans Sport :: 1994 - Oil Puddle Underneath The Car
I replaced my '94 TS intake plenum and upper and lower intake gaskets last year, and as part of the procedure I replaced the badly-degraded rubber gaskets that go at both ends of the manifold (at both ends of the "V", one under the throttle body, one under the PCV valve or so).
A little more than one month ago I realized the oil puddle underneath the car contained -besides power steering fluid from a known leak- motor oil. When I investigated the origin of the leak, I discovered the <> rubber gaskets have disintegrated AGAIN.
I don't see how this gaskets could be installed incorrectly, so I have to conclude the gaskets that came with the kit I used (Felpro?) did not withstand the oil as they should. Either way, I need to replace those <> pieces of rubber again
Now: since I don't want to be doing the same thing every 5 k miles, any good brand for these gaskets? Is there a material (neoprene?) that would last longer in contact with the oil?
Trans Sport :: 1994 TP 3.8 - Overheating In 2 Minutes From Cold
I've replaced the drain plug, filled up the radiator with proper coolant/antifreeze, turned on the engine then closed the cap to see the needle going fast to near the red mark. I turned off the engine and touched the cap with my finger but it was cold so I did the same with a hose, not hot.
Well, it seems the problem was not all circuit was filled. I did add more after a while running and now it is working normally (knock wood).
Trans Sport :: 1993 - Transmission Fluid Leakage / Hose Broken?
Tranny fluid spews out pretty good underneath. Is it likely a broken hose? Where do I start?
View 3 RepliesTrans Sport :: 1992 Pontiac - Huge Vacuum Leak And MPG Loss
One of the '92 Pontiac Trans Sports (3.1L V6 engine) had developed a huge thirst - the fuel consumption had doubled along with a serious loss of power. All ignition components - distributor cap, rotor, spark plug wires and oxygen sensor are new ACDelco's.
ECM is not throwing-up any fault codes but we suspect a vacuum leak since this engine runs better with the air intake covered-up almost completely.
Is there any way to trace and fix this kind of issue? Any vacuum diagram for this car - I couldn't seem to find it in the GM Service Manual... How would you suggest we proceed?
Ford Super Duty (1999-2016) :: 2001 - Trans Fluid In Radiator?
I have a 2001 Ford F250 V10 crew cab, I am getting trans fluid in radiator. i have had radiator replaced. it was good for about 3 months.
View 6 RepliesFord 7.3L Power Stroke (1999-2003) :: ELC Coolant And Water Mixed In Trans Fluid - Bad Radiator?
I've got a 7.3 tranny that has had ELC Coolant and water mixed in with tranny fluid because of a bad radiator. I drained the fluid from the tranny a week ago and when I pulled off the pan today there is still junk in there. I'm planning on putting in a new filter, gasket and Mercon V but how do I clean the old stuff out of there? Picture.....
View 14 RepliesFord 6.7L Power Stroke Diesel :: Fluid Leak On Top Of Trans
I was spraying undercoating yesterday and noticed a trans leak, it looks like its coming from the top of the trans. Not a lot of fluid just enough to coat the trans on top. I tried using an inspection mirror but i still cant see the leak.
View 4 RepliesPlymouth - Sundance :: 1994 - Power Steering Fluid Leak Every Now And Then
1994 Plymouth Sundance Duster (4 door, automatic transmission) with 97K miles.The power steering fluid leaks every now and then, and sometimes I have to fill it twice in a week. There is some fluid leaked onto the ground.1. What possible causes could these be? (How to diagnose the problems?) and how much might it cost to repair? 2. I need to drive the car ~2,000 miles from Chicago to LA in August. What major checks do I need to do before the roadtrip to ensure a worry-free ride? (I need to fix the A/C for sure). Also, is this car able to haul a U-Haul trailer (5' x 8' in size) with household goods worth a small studio apartment?
View 6 RepliesLexus RX 2004-09 :: Coolant Leak - Small Amount Of Red Fluid Leaked Out Of Radiator
I have a 04' RX 330 with 92k. It has small radiator leak. If you are standing in front of the car and look below the fan on the left side of the radiator you can see a small amount of red fluid that has leaked out of the radiator. However, the leak isn't big enough that I ever have to add coolant I just top it off when I get the oil changed. Also it doesn't puddle on the pavement when parked.
The only thing I really notice is that my windows tend fog abit easier now so I assuming the moisture must be making its way into the ventalation somehow. My mechanic said its about a $700 repair. My question should I fix it and is $700 reasonable. Also I've never had the timing belt replaced would it make since do have this done at the same time as the radiator. How long will it take before it becomes a major problem instead of a minor annoyance?
Golf IV R32 :: Trans Fluid Leak / Big Puddle Under Driver Side Front
I walked out to my car and there was a big puddle of tran fluid under driver side front. I think it might be from the drain plug.
View 3 RepliesTrans Sport :: 3t40 - Trans Slips When In Reverse Under Load?
If I press the gas a little hard in drive, my tires squeal but if I'm in reverse I can feel a slipping in the trans. If I try to back a trailer up an inclined driveway, it won't go, the trans slips. I have no crud in the pan. I've replaced the reverse boost valve. I installed a Trans-Go kit which is suppose to eliminate the reverse slip but it hasn't worked. Everything else works just fine and my fluid is red. I have engine braking in 2nd and 1st. The van backs up fine, it just does this in reverse under load.
View 2 RepliesGolf IV / Jetta IV :: Small Leak On Automatic Trans After Fluid And Filter Change?
I had a small leak on the side cover of my trans so I decided to replace the gasket and take the opportunity to drop the pan and change the fluid and filter. However now I seem to have a pretty significant leak from the trans pan itself. The side cover seems ok.
The filter and gasket kit I purchased was a Wix brand. I don't have a torque wrench, so I just tightened to Germain torque spec (gutentight). However now I worry that maybe it's not the right spec, either too tight or too loose. The kit came with new spacers for the gasket and I cleaned the pan, especially around the lip where it interfaces with the rubber.
Ford Super Duty (1999-2016) :: Trans Fluid Leak After Pulling Heavy Load
I have a 2000 SD F250, gasser, auto. Last week I pulled a heavy load and developed a tranny fluid leak. The fluid appears to be coming from what looks like a freeze plug on the bottom of the casing forward of the (torque converter?) pan . Is that plug easily replaced by a DYIer. Small leak. 150K on the motor. First time it has leaked. Heaviest load I've pulled.
View 2 RepliesTrans Sport :: ELC Exhausts Air When Key Is Off?
My Haynes manual indicates that the ELC exhausts air when the key is off. Is it intended to exhaust all air from the shocks every time I stop? It doesn't make sense to lower the vehicle every time I stop for fuel etc. With over 200k miles on this can it's amazing that the compressor still works.
View 9 RepliesTrans Sport :: 92 TS 3.8L - Car Is Overheating / Fan Won't Come On
I am working on my daughter's TS, it has been overheating. Water pump is fine and the thermostat is working fine also. I did notice that the temp gauge on the dash isn't. I have noticed that the fan isn't coming on either. I don't have a book on this car or a owners manual. So I am unsure of which fuses to check. I did try turning on the AC to MAX to see if that would start a fan, and that didn't work either.
View 13 RepliesFord F-150 - 1997-2003 :: 4R70W Trans Fluid Leaking - Puddle Of Fluid Under The Truck
I have a 1997 Ford F-150 XLT 4x4 with the 4.6W and a 4R70W trans. For the past year is has been leaking trans fluid and has slowly got worse and worse. At first the truck would only leak at high speeds (when driving on the interstate for extended periods of time) and now It has gotten to the point where I am adding close to a quart of fluid a week. ( roughly about a quart every 300 miles!). I thought that it was the pan gasket leaking at first, so I flushed the trans fluid (dropped the pan and drained the TC and put on a new filter) put a new gasket on and torqued it all down and added some new Valvoline max life fluid. The first trip in the truck I noticed a puddle of fluid under the truck again.
The pan looked like it could have been a little warped, so I ordered a new pan and a new FoMoCo gasket (the one the came with the new filter was the cheap felt type). I thought I for sure had fixed the truck this time, but I drove it and once again it was still leaking. I checked all that I could before replacing the pan and gasket. I checked the trans cooler lines and fittings (no leaks) I pulled the inspection plug and it was dry (so I ruled out the front pump or TC leaking). The whole underside of the truck is covered with fluid so it is hard to pin point the leak, but most of the fluid drips down on the transmission cross member.
Lexus IS 2014+ :: Lost All Smart Keys Fob For 250 F-sport?
I lost my all smart keys, what's my next step?
I go to lucksmith but they say I have to change the smart key Assay computer.
Trans Sport :: 95 TS 3.8L Misfire When Reverse Is Applied
My 95 TS 3.8L is misfiring on #4cyl ONLY when reverse is applied. When car is in reverse with parking brake applied, consistently misfires on #4. In drive with brake applied and engine load no miss. Neutral no miss.
Car drive ability is great in drive no misfires. 100% misfires on #4 only when in reverse. Is there any vacuum change or assist utilized with this trans? Possibly vacuum leak? I do not have a vacuum gauge. I changed to a different plug wire and same problem. New plugs installed. Have not swapped coils yet.
I am not familiar with this trans, other than the vacuum servo for upshifting I replaced when it was sucking up trans fluid like my old Powerglide in the OLD days.
Trans Sport :: No More Front Ventilation When Engine Is Hot
These super-hot days our TS had started to develop a very strange problem:
- when you first start the engine the A/C works normally and cold air blows from the front vents on A/C or MAX as usual
- if we shut-down the engine and try to engage A/C or MAX again the cold air would only come-out through the top (windshield) and low vents - no more front ventilation
- all solenoids appear to be working (moving)