Ford Super Duty (1999-2016) :: 2002 - Gas Engine Won't Start After Replacing Fuel Filter / Pump Relay / Air Filter?
After replacing fuel filter, pump relay, and air filter for good measure my 2002 f250 v10 gas engine still wont start. What to do?
View 13 RepliesFord 7.3L Power Stroke (1999-2003) :: Remove Old Fuel Filter Cap?
just bought this truck and it has a brittle cap and i cant get the cap to turn, its been on there awhile . 99 f250, anyway might have to destroy this cap to be able to remove it. Doing this without damaging the filter housing?
View 14 RepliesFord Wiring/Electrical :: 2003 Expedition 4.6L - Fuel Pump Relay Burnt
My vehicle would not turn over and we could tell it was fuel related. The fiel pump relay has burnt through the motherboard of the fusebox. It is my understanding that this cannot be fixedand another fusebox must be installed. I have been to many junkyards in my are looking for it to avoid the dealer prices..all of the expeditions that we have found locally have already had the fusebox pulled. Any other vehicles that this might be interchangable with? My friend has an 01 expedition..would this work?
View 1 RepliesFord 7.3L Power Stroke (1999-2003) :: Tips To Remove Stuck Fuel Filter Lid
I am attempting to change my fuel filter - have a new Napa unit complete with new lid.
I can not get the old one off (this alone tells me it's been on there too long). The hex is 26mm and all I have is a 26mm box end. It just rounds the corners of the plastic hex off.
As the new filter has a new lid, I am using a steel chisel and hammer (in a CCW direction) at several places on the top flange. I have also smacked the top flange liberally to get it to let go of whatever is holding it.
I'm about to get out my map torch out and warm up the plastic but would rather not produce a flame on something with fuel directly behind it.
Ford Excursion :: Bad Fuel Pump Relay / Fuse Panel Replacement?
- Fuse Box - Part # 3C7T-14A067-DC Engineering Number on white label.
- Ford Dealer Part # 3C7Z-14A068-DB
I have a 2004 Ford Excursion 6.8L 4x4 that has a bad fuel pump relay. I am looking for a used replacement fuse panel.
Of all these number and letters which of them tells me the real part number? Does the last two letters mean anything "DC" or "DB"?
So I don't get one for a diesel, what is the prefix for the diesel? I am assuming the 3C7T is gas and the year model?
Also, will this fuse panel interchange with a F250/F350 6.8L or do I need to stick with a fuse panel from an Excursion?
Camry :: Gen 5 Fuel Filter Replacement Interval?
My fuel filter is fine as far as I am aware. Car has 200k miles, and car does feel lower on power due to age and mileage.
I am curious if it is wise to change the fuel filter. Did a search on some threads and it seems like most recommend against it.
Sonata I45 (YF - 2011+) :: 2012 GLS Fuel Filter Location And Replacement?
Where its located? Can't seem to pull...
View 3 RepliesFord Ranger / B-Series :: Fuel Filter Removal / Replacement
I know where the filter is, i know how to bleed off the pressure. Im wondering if those clips are easy to slide off to remove the filter from the lines?
View 7 RepliesFord Super Duty (1999-2016) :: Fuel And Air Filter Replacement?
How often in miles (mostly highway and city) would you change the following:
1.Baldwin spin on fuel filter added with hutch mod
2. Napa diy 6637 air filter mod with no sleeve over it, just the paper element
3. Stock fuel bowl filter after having added a pre-filter (previously mentioned in #1)
Town Car :: Remove Steering Wheel
My neighbor asked me to look at her "car". The car is around a '92. After taking the column apart, I found the problem. The PLASTIC piece connecting the ignition switch to the ignition box broke. I would like to know the name of that part, and anywhere one can be found(new). I know I probably have to remove the steering wheel, and of course, the ignition switch.
View 1 RepliesPrius (Gen 2) Fuel :: Gas Mileage 48 Mpg Around Town And 55 Mpg On Highway
My 2006 Prius used to get GREAt gas mileage - 48 mpg around town and 55 mpg on the highway. Recently and all of a sudden, my mpg's have taken a nose dive. I now get 35 mpg! When I'm on the highway, I barely get 44 mpg. I took it to the dealer and they couldn't find anything so they are insistant that it's my driving, oxygenated gas and/or my tire pressure (even though they didn't check the tire pressure).
My driving hasn't changed; my friend with a 2004 Prius buys her gas at the same station and she's still getting ~48 mpg so I'm thinking it's not the gas; and I am OCD about keeping my pressure constant. (I own a compressor and check the tire pressure A LOT.) I drive 5 miles to work - about 15-20 minutes - on relatively level paved roads. About 2-3 times a week I travel longer distances at highway speed. I wash and wax the car fairly regularly to reduce wind drag. I have noticed periodically when I'm coasting downhill, my mpg's are less than 20 mpg so I'm thinking something's terribly wrong.
Town Car :: 1997 Town Car - Reset Actuator?
My 1997 Town Car has had the sound from the dash related to the blend door actuator in other posts. Noise would last for 5 - 10 minutes and go away. Today I noticed when driving I was getting a wild fluctuation in heat when set to automatic on the climate control so I decided to run the diagnostic to verify the blend door problem. I got code 024 so I know it is the actuator. My problem since I ran the diagnostic(exited by pushing defrost) the actuator noise is now constant and I have no heat, only cool air is blowing. Is there a reset I can do for the actuator? It's as if it is stuck in test mode.
View 8 RepliesFord Fuel System :: F250 Not Getting Voltage To Fuel Pump Relay
My F250 heavy duty isnt getting voltage to the fuel pump relay.....
View 2 RepliesPhaeton :: How To Remove Passenger Air Box To Change Oil Filter
I am a new V8 Phaeton owner. I have had the car since December and have only put about 2,000 on the car. I have always been the kind of person who takes great pride in doing much of their own maintenance on cars. Plus. How do you get the passenger side air box out to access the oil filter? I can get the upper section apart but can't get the lower section of the airbox out and I am scared to break it.
View 4 RepliesLexus RX 2010-15 :: 2011 - How To Remove Cabin Air Filter
I am having a problem in changing the cabin air filter in a 2011 RX450h. I can remove the shelve in the glove compartment, but can not remove the L shaped cover plate to the filter. What is the correct procedure to remove the cover plate without breaking it?
View 1 RepliesFord 6.7L Power Stroke Diesel :: Loud Electrical Pop With Air Compressor Relay
Every time my air compressor would shut off I got a loud annoying pop through the radio. Even if the radio was off I would still get the pop. I knew it couldn't be good for all the electronics in the truck so I tried a mod.
Diodes across the relay signal terminals need to be installed in performance carts to protect the electronics. I put one of these diodes on my truck this week. 100% of the pop is gone.
I used this one : ACC-KIT-CSD-1
Ford Fuel System :: 1995 - Stalls - Now Stop Moving - Fuel Filter?
I have a 95 F150 4x4 reg cab long box with a 302 V8 and dual tanks... I was driving around yesterday when my truck started to lung and then the motor stalled... when I stopped moving I tried starting the truck and it started with no problem, so as i kept on my way, about 5 minutes later the same thing happened and it stalled again, (I have an automatic by the way). but this time before it stopped moving i pump the gas a few times and it fired back up and then stalled again... i switched from my front take to by back maybe thinking it could me my fuel pump in the tank but it did the same thing again about same time later... Would it be my fuel filter on the frame (like in line fuel filter) or why is it doing that? its EFI by the way.
View 14 RepliesFord Fuel System :: Changed Fuel Filter Now Just Cranks But Won't Fire / Start
2002 E-250 with the 4.6 V-6. Pulled the 30 amp fuse, replaced the fuel filter, replaced the fuse, now the truck wont start. Checked the fuse and the kill switch under the passenger kick cover, all ok. Cranks and cranks but wont fire. No problem prior to changing the filter. Even swithed out the relay with another, no luck.
View 4 RepliesFord Fuel System :: Fuel Filter Is Clogged When Turn Over The Engine
Is it fair to assume that my filter is clogged when I turn over the engine and fuel does NOT come out of the filter with the uphill line disconnected. I was able to disconnect the rear line from filter and fuel DID pump out of line when I cranked it over. Been dealing with a crank no start, I'm in the process of trying to test my CPS properly but not sure if I'm testing it right.
2000 f 150 4.2 v6 232,000 miles....