Santa FE SM (2001-06) :: Engine Making Loud Ticking Noise - Crank Pulley Gone
Oh where do I start. 2003 Santa Fe, V6 Auto, FWD.
The engine has been making a loud ticking noise lately, starting right after an oil change it seemed. It actually sounded a lot like a stuck lifter, so I had an engine flush done, but this did not remedy the problem. Popping the hood one day it was particularly noisy, I noticed that it sounded like it was coming from the serpentine belt tensioner (or there abouts).
Anyway, tonight, *something* finally gave. All of a sudden I heard a squealing noise, then smelled burning rubber, and my battery light came on, and I lost my power steering. I figured that the tensioner finally gave out.
I turned off the vehicle to see what I could see. A bit of melted S-belt was it. I restarted it, and the belt was turning fine again, but while it was idling, I noticed that the crank pulley was shifting in and out now and then. When it moved inward, the S-belt shifted in as well, and started to rub on the timing cover, wearing a hole right through it! Have a look at the attached photo, showing the grove worn right through.
So I'm assuming that my tensioner was fine, and it was my crank pulley all a long. I'm figuring that 3 thing will need replacing:
1. Crank Pulley (the source of the problem)
2. Serpentine Belt (since it's probably half melted)
3. Timing Cover (can't see that water getting in there would be good)
Does this sound accurate?
Santa Fe (CM - 2007-12) :: Strut / Shock Failure - Knocking Sound From Front
My 2008 Santa Fe (3.3 2WD) produces a knocking sound from the front every time I go on a bump while the wheel is turned. I can pretty much reproduce it at will. Occasionally, I hear the same sort knock from the rear as well, but I cannot confirm that it is consistent.
I do suspect that something is wrong with the struts. The only issue is that the car has 67k KM (41k miles), and to me, that seems a little early for that sort of thing to happen. My driving is pretty standard on standard roads, although winters up here tend to produce potholes that I sometimes cannot avoid.
I've had my struts fail on my last car (2000 Mazda Protege), but that was 9+ years old and with almost 3 times as much mileage on it.
Camry :: Spring Clunking Noise Coming Out Of Driver Side Strut Tower
So I installed my H&R lowering springs about 2 months ago and I am very happy about the stance, ride, and handling up until about 2 weeks ago. The car always had a bit of a spring clunk coming out of the driver's side strut tower, but it has become more apparent and pronounced over the last few days. I already tightened the strut nut and shock tower bolts, what else is there to check out?
View 14 RepliesSanta FE SM (2001-06) :: Clutch On AC Compressor Went Out And Making A Loud Racket
I have a '03 V6 3.5 Santa Fe. The clutch on the AC compressor went out and was making a loud racket. When I was pulling the compressor off I noticed the wire harness connection to the compressor was damaged. Either by me or previous change.
So the end of the harness on the car side is damaged. Can a new one be purchased and spliced? I cannot see where it goes to see if it can be replaced.
Prius (2001-03) :: Stuck On Highway - Car Making A Loud Thud Noise
So... My car started making a loud thud noise... Thought I blew a tire...sounded similar... But I see nothing wrong... Not sure where to tow it to....
View 19 RepliesSanta FE SM (2001-06) :: AC Fan Started Making A Rattling Noise
2004 Santa Fe AC fan has started making a rattling noise. It gets louder when the fan is turned up. How can I check it? Noise seems to be under the glove box.
View 3 RepliesAccent RB (2012+) :: Suspension Spring Making Noise?
Having problem with accent suspension spring making noise? I had 5 people inside the car with some stuff in the trunk. As soon as I drove I could hear the squeak coming from the spring. I doubt that I went over the load limit. Any car should hold up 5 people with some weight in the trunk... right?
View 10 RepliesCamry :: Strut And Spring Assembly Replacement On 2007 LE
Looking to replace my strut and spring assembly on my 2007 Camry LE with 130,000 miles. What is the best China units out there. The list is many Prime Choice, Detriot Axle, Unity, FCS, AST, Sensen, ect.... Maybe they all are made at the same factory. FYI Monroe and Gabriel could be made in China. KYB complete units are assembled in USA, I called them up.
View 13 RepliesLexus RX 2010-15 :: Spring Popping Noise When Making A Slight Right Turn Up On Driveway
My 2015 is making a strange noise most noticeable when making a slight right turn up a driveway. It sounds like a spring popping.
View 3 RepliesSanta FE SM (2001-06) :: Loud Ticking Noise Under The Hood
2.7L V6 here. It's got a loud ticking noise under the hood that sounds like it is coming from about the middle of the head closest to the front. It's been doing this for a long time now and is finally bugging me. The noise is related to RPMs meaning that as you rev the motor it gets faster (but not really louder). When I pulled the valve cover about a year ago both heads had lots of gunked up old burned oil which I cleaned up as much as possible. It doesn't throw any codes and runs just fine.
I'm about 99.9% sure I've got a collapsed lash adjuster(s). Is there a way to test it without pulling it? Can I pull the valve cover and have someone turn the engine over a few times to check for oil pumping from the lash adjusters? Is there a way to press it and see if it moves without pulling the cams? Any options to try and clean them while still in the motor?
Santa FE SM (2001-06) :: Loud Grinding Noise Seems To Be Coming From Behind Glove Box
I have a 2002 Hyundai Santa Fe v6. I've had problems with the air conditioning in that it blows hot. Paid around 900 bucks to have a new compressor installed because the mechanic said that would fix it but it didn't. That was about 8 months ago. Still blowing strong but no cold air. About two weeks ago I took the car to a different mechanic who told me it needs a new compressor which would be 900 bucks. I declined that but had the guy do a little work on the breaks. He put new rotors and pads on the front brakes two weeks ago. Now within the past couple days when I start the car up it makes an extremely loud nasty grinding type of sound for a couple seconds then stops. Oil is fine and new. It happened this morning long enough for me to look under the hood and see the fans looked like they were fine, and the loud grinding noise seems to be coming from behind the glove box. It hasn't broke down on me yet, it's just really obnoxious and embarrassing with all the noise every morning.
View 8 RepliesSanta FE SM (2001-06) :: 2002 - Loud Noise From Engine When In Drive
2002 hyundai santa fe GL2 4 Cyl Automatic ... I noticed that there is a super heavy motorcycle-ish loud noise from my engine when I put it in drive. When it's idle or in reverse or neutral the problem does not occur. but then when I switch it to drive, uber loud noise...which gets louder when I step on the gas.
What has been done so far - replaced spark plugs, ignition coils and plug wires so far...also changed the oil, no fix.
No check engine light at all.....however the battery did die due to someone leaving a light on for days So I am unable to get any code readings.
Santa FE SM (2001-06) :: Loud Buzzing Noise Coming From DRL Module
I am having a strange issue with this vehicle that the dealership can't figure out but it doesn't surprise since here they are a bunch of idiots there anyways....well here it goes....when i start the vehicle there is a fairly loud "buzzing" noise coming from the drl module mounted on the front right side fender, the module feels like the relay inside is clicking extremely fast but not actually staying on, the drl's do not come on however the high beam indicator on the dash is illuminated. This will go away when i turn on the low beams, but i still have no high beams. There is a slight flicker within all the interior lights and headlights which leads me to believe there is a ground issue. I am unable to obtain any schematics for this part of the electrical system to be able to back probe and try to isolate the issue.... The vehicle seems to be fine as long as you turn the low beams on as soon as you start it other then the slight flicker in the lighting inside and out.....
View 3 RepliesSanta Fe (CM - 2007-12) :: Noise From Strut When Hatch Closed
Experienced a noise from the strut when you close the hatch. I tried wd40 on the rod but it really didn't work. Not sure if its the cold weather that's causing this.
View 10 RepliesSanta FE SM (2001-06) :: 2004 - Front Driver Side Coil Spring Broken
The driver's side coil spring broke, but here's the story.
When I found out there was a recall on my 2004, I called the dealership. They told me that they were not replacing the coils springs, they were only going to attach a brace or bracket in case the coil springs would fail.
Well, last night the coil broke and it was in the parking lot and not at 50mph on the road.
What about bracket fix? It was told to me that it would only prevent the coil from cutting into the tire, not fix it.
I am going to call Hyundai HQ this morning, but what should I expect? Is it unreasonable to expect to get a set of springs and have someone local do the work?
Lexus ES 2013+ :: Battery Failure If Not Driven A Day Or Two
I purchased a new 350ES in October 2013. A few months later when I went to start the car after having it sit in garage a day or two, it would not start. Called Lexis Roadside. They jumped it and all is well. I thought perhaps I had left the trunk or a door ajar. There was no evidence I had done so. The dealer gave a multitude of reasons this could have happened. I considered it a fluke and moved on.
Approximately a yr later, same thing. Dealer replaced battery and indicated they don't know why it failed again. About nine mos. later, August 2015, same thing! They again replaced battery but were admittedly very unsure the problem was solved.
Car performed fine since then but it was driven every day. Last week, it sat in my garage exactly 36 hrs. Would not start. Lexus Roadside guy said it has a bad cell. Keep in mind this battery is now about 10 months old!
It is at the Lexus dealer now. First (believe it or not) the service guy told me this is normal and I should get a trickler (sp?) and plug it in at night. What??? When I argued with him, he back pedaled and agreed to allow it to sit on their lot for a few days and see what happens when they try to start it.
The alarming thing is that they seem stymied as to what is causing this electrical failure or how to fix it.
Golf/GTI VII :: Spring Binding Popping Noise After Neuspeed Race Spring Install
This noise I have is driving me crazy, installed neuspeed race springs and now I have this weird spring noise, sounds like the springs are binding and then releasing when you turn the wheel, like a clicking dinging noise, it's on both sides and happens when moving slow and turning the wheel and when stationary and turning wheel, it sounds like tug and release not really spring bind I checked install and everything is correct even disassembled bearing assembly and everything is fine, lubed spring seats with silicone paste nothing is working.
When looking at the spring and turning wheel it's almost like the spring is getting stuck on the middle part of the seat then releasing, I know this was a common problem on the mk6 but I haven't heard anything about the mk7 the spring is seated in the lower perch perfectly the upper is were the noise is coming from you can see as you turn the upper bearing by hand it actually somewhat twists the spring and then releases and that's what makes the noise, and it dose not move in a nice circular motion kind of like an egg shaped rotation and it makes the spring flex and pop I think there's a problem with the springs,
Volvo - 850 :: Upper Strut Mount Failure
My upper strut mounts have been failing after a year (about 12,000 miles, typical highway and local street driving, no off-road!). This seems to have started when I replaced shocks with Bilstein slightly stiffer variety. I also put a stabilizer bar on it at that time. Do you think the shocks are the fault? What else might I look for?
View 1 RepliesPrius (2001-03) :: Rattling Noise From The Left Front Strut
Recently I have noticed a rattling noise from the left front strut. Looking up parts online I can see the strut, as well as an upper strut mount, either of which might be the culprit.
View 2 Replies