Santa FE SM (2001-06) :: Engine Making Loud Ticking Noise - Crank Pulley Gone
Oh where do I start. 2003 Santa Fe, V6 Auto, FWD.
The engine has been making a loud ticking noise lately, starting right after an oil change it seemed. It actually sounded a lot like a stuck lifter, so I had an engine flush done, but this did not remedy the problem. Popping the hood one day it was particularly noisy, I noticed that it sounded like it was coming from the serpentine belt tensioner (or there abouts).
Anyway, tonight, *something* finally gave. All of a sudden I heard a squealing noise, then smelled burning rubber, and my battery light came on, and I lost my power steering. I figured that the tensioner finally gave out.
I turned off the vehicle to see what I could see. A bit of melted S-belt was it. I restarted it, and the belt was turning fine again, but while it was idling, I noticed that the crank pulley was shifting in and out now and then. When it moved inward, the S-belt shifted in as well, and started to rub on the timing cover, wearing a hole right through it! Have a look at the attached photo, showing the grove worn right through.
So I'm assuming that my tensioner was fine, and it was my crank pulley all a long. I'm figuring that 3 thing will need replacing:
1. Crank Pulley (the source of the problem)
2. Serpentine Belt (since it's probably half melted)
3. Timing Cover (can't see that water getting in there would be good)
Does this sound accurate?
Ford F-150 - 1997-2003 :: 2001 V8 - Ticking Noise From Engine On Acceleration
I have a 2001 5.4 V8 with 55K miles and the tow package. On acceleration the engine makes a ticking noise. Engine seems to run fine, no misfire.
View 14 RepliesSanta FE SM (2001-06) :: Loud Ticking Noise Under The Hood
2.7L V6 here. It's got a loud ticking noise under the hood that sounds like it is coming from about the middle of the head closest to the front. It's been doing this for a long time now and is finally bugging me. The noise is related to RPMs meaning that as you rev the motor it gets faster (but not really louder). When I pulled the valve cover about a year ago both heads had lots of gunked up old burned oil which I cleaned up as much as possible. It doesn't throw any codes and runs just fine.
I'm about 99.9% sure I've got a collapsed lash adjuster(s). Is there a way to test it without pulling it? Can I pull the valve cover and have someone turn the engine over a few times to check for oil pumping from the lash adjusters? Is there a way to press it and see if it moves without pulling the cams? Any options to try and clean them while still in the motor?
Santa FE SM (2001-06) :: Ticking Noise Coming From The Front When Starting
I Have a ticking noise coming from the front when I first start up the vehicle and only lasts for 5-10 secs maybe 15 secs tops.. I assume I think its from the engine..
View 15 RepliesSanta FE SM (2001-06) :: At Cold Startup Ticking Noise - Change The Oil?
Its been getting quite cold here lately at night and in the morning when i go to the santa fe it makes a ticking noise for about 2-3 seconds and everything is fine again. I was thinking of dropping a quart of transmission fluid in the crankcase run it for a bit and change the oil?
View 14 RepliesSanta FE SM (2001-06) :: V6 2.7l Engine Ticking Or Tapping When Cold Started
My engine in my 2002 Santa Fe 2.7 v6 has been making a ticking sound that was especially pronounced when cold starting. It would quiet down somewhat when warmed up but still a slight ticking would be there. I thought it was the hydraulic lash adjusters. I know Hyundai's service site sates that a ticking can be heard if the factory filter is not used. I tried using the factory oil filter which did not make a difference. The car had about 85,000 miles on it and I always maintained it well as well as keeping up with oil changes. I took it to the dealer to have a repair performed related to corrosion of the rear trailing arms and had the tech check the engine noise.
It was determined that the cam chains have developed slack and were slapping on the cam chain guides which prevent the cam chains from popping off in case of slack developing which was the case here. The chain guides are made of some type of plastic material and according to the tech showed significant wear. This was all covered under the powertrain warranty. For those that are not under warranty any longer and are capable of doing their own repairs this is the list of parts that was ordered by the dealer. The parts in red are the culprits. The rest are gaskets and seals. I don't think this is an easy job.
Santa FE SM (2001-06) :: 2005 - Ticking Noise / Blue Spark Occurring At Random Intervals On The Balancer
2005, 2.7l. FWD automatic, with 180,000+ miles.
A week ago it started making a random ticking noise I've never heard before. Today was the first chance I got to try and find it and I'm stumped on what could cause this.
The sound is a static or low voltage electrical discharge coming off the harmonic balancer. I can actually see the blue spark occurring at random intervals and locations on the balancer as the car is running.
Do i need to be looking for a bad engine ground? I'm having no other electrical problems. The car runs like a champ other than a minor oil and power steering fluid leak.
Santa Fe (CM - 2007-12) :: 2009 - Ticking Noise In Engine When Warmed Up
I have a 2009 Santa Fe that when the engine has warmed up, the engine starts making a ticking/clicking noise. The dealership told me not to worry all cars make that noise and it was probably just a purge valve. Does this sound right?
View 2 RepliesBmw - X5 :: 2001 - Engine Ticking / Clicking Noise
I have a 2001 BMW X5 with some ticking/clicking noises coming from around the engine area and I would like to know what those may be due to. Here are the two videos that I have posted: [URL] .... I have done my homework to look at a bunch of vids online about cars with similar noises and possibilities for the noise are valves, belt, rods, bearings, spark plugs, etc.
View 5 RepliesMontana :: 2003 Engine Making Ticking Noise - Low On Oil
My mom has a 2003 pontiac montana thats making a ticking noise says its low on oil but i just changed the oil 2 and half weeks ago. Why it would be ticking?
View 3 RepliesToyota - Tacoma :: 2001 - Engine Makes Knocking / Ticking Noise In Cold Weather
I have a 2001 Toyota Tacoma that has a knock or ticking in cold weather. The problem starts sometimes immediately after I start and other times it is only when I press on the gas in the cold mornings after a few min warm up. The noise goes away after 10 min. The question I am wondering is this:
1: could it be worn piston rings and the pistons are slapping the cylinder wall
2: is it an oil pump problem or a oil restriction issue
3: is it a valve guide issue
4: with the history of the 2.7 having exhaust manifold issues (poor manufacturing) could a cracked manifold be the issue
I change the oil myself, the oil filters have been OEM toyota, the noise has been going on since 60,000 miles, the truck is at 230,000 miles.
Toyota - Corolla :: 2003 - Loud Ticking Noise In Engine / Oil Light On And Off Intermittently
Here's a bit of background on the car itself:
It's a 2003 corolla, 180k miles, and was sitting an entire year. About a month ago, I replaced my battery, and did an oil change. After the oil change, I started getting a few random symptoms:
loud ticking sound in my engine
check engine light with code P1349, VVT System (but it's disappeared since)
oil light on and off, intermittently.
With a bit of research on the error code, people have said to replace the VVT-i actuator. Do you think this solenoid has a large potential as the source of the issue? I purchased one for around $100 from Autozone, but am having a tough time removing it from the engine.
If you think this is the issue, how can I remove the solenoid? Do I just unbolt the one bolt I see on there and yank? Or is there something else I'm missing?
Ford F-150 - 1997-2003 :: 1998 - Engine Ticking Noise Very Noticeable At Startup
I have a 98 F150 Supercab 4x4 with 4.6 and an auto trans. I have 107,000 miles on the truck. Recently developed a engine "tick". Upon start up the "tick" is very noticeable. Seems to go away after its been driven a few miles and everything comes up to operating temp. I have checked the exhaust manifolds, all studs and nuts are still there. There are no noticeable holes that I could feel in the manifolds. Read some other posts here that have the "tick under load". Mine goes away once everything warms up. What to look at or for?
View 8 RepliesFord 7.3L Power Stroke (1999-2003) :: Ticking Noise Coming From Driver Side Of The Engine
So I have a ticking sound that has me puzzled. I thought it could be coming from the drivers side of the engine. This weekend, actually on Monday I decided to do the hot re-torque on the diver side. I warm up the engine for about 15min and have at it. I had put this off for weeks because it has been way too hot. Dam it was still too hot, I was sweating buckets. I had to stop several times to clear the sweat off my head my eyes my shades .I torqued everything to spec and nothing moved.
I went to 125 inch lbs and I got movement on the rear two injectors. I gave them about 1/2 a turn and stopped. I put everything back together, I used hair spray form the 99 ct store. It seemed OK. Fast forward to Tue. I needed to be sure so I went for the boost leak test. Here is my concern. I was going to test to about 30 PSIG, but I ended up at about 40 psig and I forgot to disconnect the MAP sensor! How likely is it that I damaged the sensor, and how can I tell? She is pretty stock and does not have a boost fooler to protect the sensor. Nothing popped and I did not leave the the HP on very long.
Ford F-150 - 1997-2003 :: Engine Ticking Noise / Slight Clatter For 2 - 3 Seconds Upon Cold Startup
I've got a 2003 f150 with the 5.4 and 128,000 miles with an engine tick. Its not an exhaust leak I know that for sure. It has came up in the last 20,000 miles. I've used motorcraft 5 20 w/ motorcraft filter. I've tried a kreen engine treatment with no change. Heres the description/syptoms:
-Slight clatter for 2-3 seconds upon cold startup (happens very rarely)
-top end ticking that is loudest and most noticable when warm (quieter when motors cold)
-not timing chains/tensioners etc because the noise is coming from the top end and most noticeable on the passenger side.
-at idle the tick is present-when you rev at idle, the noise goes away.
-Driving (or having the engine under any load for that matter) the noise gets louder.
-Anytime I accelerate, tow/haul, go up an incline the noise gets worse
-Sounds like a "whirring" sound from within the dash.
With all that said I am thinking the lash adjusters are getting noisy. I had a certified gm tech that has 40 yrs mechanic experience under his belt and builds prostreet muscle cars on the side look at it. He listened to it to it and that was his diagnosis as well as its not that bad so just live with it. The noise at idle doesn't bother me, its when im driving with the windows down. The noise drives me crazy and is a little annoying to me.
Heres a link to a video of the sound and keep in mind it is much louder now : Triton engine noise/tick - YouTube
Santa FE SM (2001-06) :: 2003 4WD V6 2.7L Engine Won't Start
We recently changed the timing belt & serpentine belt & new alternator. Drove great for 2 days. Then car would stall out when idling, had rough idle. We replaced the Crankshaft position sensor (got one from the dealer) & the electrical connector. The engine cranks but won't start. The only code we're getting is P0335. We've checked all the fuses. Fuel pump starts when turning on the key. We've been a week without a car and trying to come up with something.
View 6 RepliesSanta FE SM (2001-06) :: Intermittent Ticking Sound Coming From Glove Compartment Area
For the last two days I've had a very intermittent (tck, tck, tck) sound coming from what sounds like the glove compartment area. It has a rep rate of around three times a second and is very regular. It sounds like a relay to me. It has only lasted less than 20 seconds on each occurrence so don't have time to troubleshoot. I took that area apart and I see two 12volt 25 amp what look like relays just to the right of the glove compartment. I've left that area torn apart so if it happens again I can feel the relays and get it down to one-and or eliminate them as the cause of the noise.
View 1 RepliesSanta FE SM (2001-06) :: Knocking Noise In The Engine After Oil Change
2004 Santa Fe, 2.7 L V6. The oil was changed approx 5-7k miles ago (not really sure as I bought it from someone else) and I just changed it today. There's a new knocking noise in the engine. I used normal castrol GTX oil, 5w-30.
I drove it about 20 miles and the noise is still being made, so it's not a circulation problem.
Santa FE SM (2001-06) :: 2003 - Noise Form Compressor Clutch
Recently I began hearing noise such as a rattle on the right front of the vehicle. It is a 2003 SF 2.7L front wheel drive with almost 180k mi. At first I thought the noise was from the Serp belt tensioner. Now I believe it originates from the compressor clutch.
Does the a/c clutch have a history with its bearings ? Is the clutch replaceable on the compressor or is this a single unit replacement ?