Prius (2004-09) :: Transaxle Disengaging / Hybrid System And ABS Warning Lights
I have a 2005, I purchased new in 2005. I now have around 120,000 miles and have had no problems - just oil changes and new tires.
I was driving on the interstate in MS and all of a sudden all these lights come on on my dash including the triangle that means take it to your dealer immediately. The car sounded funny acted funny and accelerated funny. I was closer to home so I came home and called the dealer. They said to drive it in but if it started acting up to pull over and they would come get me.
When I cranked it, it sounded like I was pushing the accelerator but I wasn't so I cut it off then cranked it again. I drove it very slowly cause it was acting weird.
I drove it home to discuss it with my husband and to do some on-line research here. So 2 - 3 weeks later my husband decides to look at it and by now the little battery is dead - it is the original battery too -btw. So I bought a new toyota battery (the little one). My husband hooked it up to see if the car would crank. It did but all the lights on the dash lite up again including a couple new ones!
Prius (2010-12) :: Replaced Transaxle And Inverter - Check Hybrid System Message
I have a 2010 Prius, currently at around 69,000 miles. Back in Feb 2015 (when it was just under 60,000) I was driving on a city street and hit the accelerator once a stoplight turned green - immediately as I took off (at a normal rate of acceleration) my 2010 Prius made a loud noise and I got the red triangle of death, with a "Check Hybrid System" message. The car quickly shifted into "limp home" mode and I was able to make it back home as I was only about a mile away.
Got towed to the nearest dealer the next morning and after tons of testing and going back and forth, they replaced the transmission and inverter (was able to get it covered under powertrain warranty), and I was on my merry way. No issues until last night.
Yesterday evening, I am on a city street and get a warning beep. I look at my dashboard and this time I have a yellow exclamation mark with the "Check Hybrid System" message yet AGAIN. Towed the car to the nearest dealer and am now waiting on next steps. Only update I've gotten so far is that they are still trying to diagnose the issue, and are getting 4 error codes in this process, 2 of which are new. I am waiting on the technician to tell me what the actual codes are - hopefully should get them tomorrow.
I would hope if it's another issue with transmission or inverter, it's covered under warranty given I replaced both less than a year ago. However I'm not sure and am worried that it's going to be $$$ in case it's something else that failed. Plus I'm getting serious doubts as to the safety of my car - what if I had been moving at a high speed on the highway during either of these situations?
Prius (2010-12) :: Check Hybrid System Message - Transaxle Temp Sensor Giving Erratic Readings?
The "Check Hybrid System" message came up on my dashboard. I took it to the dealer, and they said the temperature sensor on the transaxle was giving erratic readings. Unfortunately, they said that the only way to fix it is to replace the entire transaxle. They said I could keep driving it and that it would probably go into disabled mode before it caused any more damage. What I should do? It's a rebuilt 2012 Prius with 25k miles.
View 19 RepliesPrius (2004-09) :: 2008 Stalled Downhill - No Acceleration Like Hybrid Disengaged From ICE
Yesterday was driving my 2008 Prius (75K) down a paved road from a ski-hill (no snow/rain, perfect weather and completely dry road). Not hard driving, 20-30 mph some curves, very smooth road with no potholes, etc. Battery turned all green, its fan initiated and I also rolled back window during this 75 degF day (not unusual to have battery fan turn on in this condition, it's occured plenty of time before). Wasn't braking hard either. Out of know where, I first noticed upon slightly accelerating that I had no acceleration, like the hybrid had disengaged from the ICE, and then check engine, (!), red triangle, VSC light!! At this point, couldn't tell if car was on or off, the wheels disappeared from the main display, although the ICE/electric motors continued to show although there was a red warning top left corner.
It did scare the hell out of me going downhill with curves wondering if I was really still in control of the car. I pulled over as soon as I could maybe 1/2 mile downhill. I then shut car off, waiting maybe 1 minute, turned back on. The VSC cleared I believe, but all other lights continued on. Next, I only knew to drive it to the Toyota dealership. It was odd, as the Prius was now in some sort of weird, pseudo on-state. It had virtually no acceleration, maybe 40 mph after 1 mile and that was it. Drove it maybe 8 miles like this thru town in this pseudo on-state. Pulled into dealership. They pulled codes and found P0A1D-HYBRID POWERTRAIN CONTROL MODULE INFO 1 AND P3000-BATTERY CONTROL SYSTEM. They stated vehicle was found with problem with hybrid control ECU. They cleared the codes and test drove with no issue repeated. That's it. If it comes back I'm told I will need to replace hybrid control ECU.
Prius (2004-09) :: Hybrid System Isn't Working Properly
I have a 2004 bought in 2003. It recently logged its first 100k miles. My problem with it is not easy to describe. It is actually running more like a non-hybrid car. I can feel and tell the hybrid system is operational, and I can hear the electric motor whine when coasting, down, etc. However, I don't think it is running as it should or as it used to. It happened on highway while cruising about 70 mph. I hit the accelerator to pass someone, and I felt that something changed. I'll try to describe it: think of a half-clogged pipe. The water can barely gets past the obstruction. You keep applying pressure, and suddenly the clog dissolves under pressure, and water begins to flow freely, and the pressure goes down. So it felt like that. Now the accelerator pedal is lighter, car is faster to respond, yet I think something is wrong because the car isn't itself anymore.
I don't like problems like these because they are very difficult to diagnose, let alone fix. For a while I also have not heard the inverter pump whine after shutting the car off as I did in the past, but the last time I got out of the car today I heard it. I believe it was replaced five years ago after a collision with a Trailblazer wiped out half of the front end ( but with no power train damage). I checked the VIN for the inverter pump campaign, but my VIN was not in the range.
Right now my problem is that the car feels a lot faster than it has ever been. When I lift off the accelerator, it doesn't begin to coast as it used to. No warning light of any kind out of the ordinary is present on the dash, although it did have the red triangle on during start up with a message about the parking gear not being engaged properly. That warning went away after the change in performance occurred. Related?
I guess I will take it to the dealer to see if there are any codes stored. After my 30 mile commute this morning, no whining, buzzing or any kind of noise was present after I shut off the car and I got out. There is still no warning light.
Prius (2004-09) :: Getting Hybrid System Warning Light?
My wife just called and said this light came on. She said when it came on the car turned off its cruise control but kept running. Now she says it seems to be running fine but the light is coming on.
The car has around 110k miles and I just replaced the spark plugs, air filter and engine oil about 1k miles ago. What it could be? I'm going to have her pull codes at the auto parts store but she needs to do about 20-30 miles of driving today for work. Is it safe for her to do so?
Prius (2004-09) :: Hybrid System Warning Light And Running Out Of Gas
My hybrid system warning light came on last night in my 2005 Prius with about 89,000 miles. The car may have run out of gas (I wasn't driving). This car will only take about 8.5 gallons when the fuel light starts flashing. I started it this morning, light was still on, only 2 bars on battery, my car usually runs near the green, and the gas engine stalled after about 30 seconds. The gas indicator was flashing, so I added a 1/2 gallon I had at the house, and unplugged the 12v for about 10 minutes to clear the system. Upon restarting, fuel light was still flashing, but no hybrid warning light. Drove a few miles, filled up with gas, and drove another mile.
So my question, could running out of gas and driving a very short distance (light came on as my wife turned into our driveway), cause this warning light to come on? If so, will there be any lasting effects? Did unplugging the 12v battery clear the computer codes, or can I still get these read to learn more about what happened?
Prius (2004-09) :: Red Exclamation And Hybrid System Warning Light Came On
I have a 2005 Prius with 135k miles. Yesterday the red exclamation light came on and also the hybrid system warning light. I shut the car off and it came on again. The third time the car started normally and it is driving normally today with no warnings. Does this sound like the 12 volt battery? It is original.
View 6 RepliesPrius (2004-09) :: Red Triangle, Dash Lights And Hybrid System Icon On MFD
I have been having some hybrid battery issues. My prius is a 2006 with 198,000 miles. The original battery was replaced at around 120,000 with a junkyard battery. About a year later that battery gave up the ghost and I decided to rebuild that battery. So far that has worked quite well until recently.
My troubles started a couple weeks ago when I got the Red triangle and all the dash lights and the hybrid system icon on the MFD. Naturally I thought it was the battery again. Took it out and checked the voltages of the modules. All the modules where within tolerances. I grabbed a OBDII scanner and checked the code. It was telling me that the Hybrid current sensor was bad. I changed that out with the wiring harness from the old battery.
That lasted for a few days before the red triangle came back. I checked the code and it was indicating one of the blocks was bad. I think P3019. So I took the battery back out and replaced that block with other modules. Almost instantaneously the red triangle came back with two more bad blocks. I think it was P3012 and P3022. So I took the battery out once more and tested all the voltages of all the modules. Everything was 7.86-7.9v. So I decided to start the rebalance of the existing modules in hopes to find some bad modules.
I also bought a new 12v battery and installed that. I got everything back together and took it for a road test. It took about 30 mins before the triangle came back. I grabbed the codes and it was still indicating bad blocks. P3011 and P3018. I am a little at a loss.
Prius (2004-09) :: Loss Of Power / Red Triangle And Hybrid System Warning
During a highway trip three months ago, my 2004 Prius suddenly lost engine power, the red triangle Master Warning light came on accompanied by a warning sound, and then the Hybrid System Warning sign appeared on the Multifunction Display. I pulled off to the side of the road and stopped. I turned the car off and then tried turning it on again. Engine power was restored although the warning lights remained. We took a chance and carried on with our trip. The same sequence of events reoccurred about 10 times on our 1,300 km journey. I took the car to a Toyota dealer where they found a C2318 DTC. They checked the battery and the HEV fuse but could not locate the problem.
We returned home and on the way the same thing happened a few more times. My service manual noted that the description for C2318 is Low Voltage Error (Power Supply Malfunction) and the trouble areas are HEV fuse, IGCT relay, Wire harness or connector, or Auxiliary battery. Since the car was nearly 7 years old I thought I had nothing to lose by replacing the battery, which I did. However, on a short 150 km trip last week the problem appeared again, once while approaching our destination and once when we were almost home. There seems to be a pattern in that the problem appears every 150 km or so of highway driving. It has never done it while driving in the city.
Prius (2004-09) :: Hybrid System Malfunction Indicator And Gas Engine Won't Stay On
I have a 2008 Prius with 106,000+ miles on it. It was running fine till 2 days ago, I didn't start it yesterday and today when i went to start it, I get the Hybrid System Malfunction light, along with check engine, the red triangle and TPMS light. The gas engine tries to start up, then 1 second later makes a grinding noise and turns off.
I am in Toronto and its cold, but not THAT cold yet. So I am doubtful its temperature related. I checked the fluids and they all seem to be sufficient (engine oil, radiator fluid, power steering fluid). I didn't notice any leaks under the vehicle either.
Prius (2004-09) :: Hybrid System Warning And Triangle Of Death Light On
A few days ago I was driving my 2005 Prius aggressively up a mountain road and all at once the hybrid system warning light, the triangle with the exclamation point, and the regenerative brake system warning lights came on.
After about 2 minutes parked, I restarted the car and the regenerative brake system warning light went off, but the other two were still on. I still drove it twenty miles home, over another substantial mountain gap (about 1000 ft up and another 1500 down), without any problems.
I checked the voltage of the 12v battery, which seemed to be on the low end, but OK. (I think the lowest reading was 11.9). There seemed also to be some turbulence in the inverter coolant reservoir.
I brought it into the electronic vehicle specialist in town here today, who pulled my codes and said that the hybrid battery was dead.
Prius (2004-09) :: 2008 - Hybrid System Warning Again Even After Replacing 12V Battery
I haven’t been on these boards very often since getting my used 2008 Prius because until now it has been very kind to me in terms of not needing mechanical repairs. Unfortunately that good streak seems to have come to an end. Driving home Monday evening (after ~30min freeway driving), my master system warning light came on, accompanied by the hybrid system warning light. I didn’t know what the latter was – had to look it up – but I immediately pulled to the shoulder. The car was driving normally, however. Since shops and dealers were closed for the evening, after much debate I ended up having the car towed to a family friend’s body shop; they were still there and had a scanner to check the error codes for me. My car was on the side of the freeway for well over an hour with hazard lights on and the dome light on and off occasionally as we got in and out of the car. By the time the tow truck arrived, I discovered that the 12V battery seemed dead; car wouldn’t boot up all the way, wouldn’t shift to neutral and didn’t want to power down – I had to try turning it off upwards of 10 times. I was surprised, given just the hazard light and limited dome light usage. We jumped it, got it in neutral and on the truck.
At the body shop, they said there were no error codes related to the hybrid battery; something about transmission that wasn’t clarified, and errors for low voltage on the 12V battery. With everything off, it measured 10-something V; something higher when turned on, but they believed the problem was a dead 12V battery. I was surprised that it would suddenly give out in the middle of driving, but we went ahead and replaced it the next day. I picked up the car Tues evening, and had no problems driving it home, to work the next morning. Unfortunately, during my drive home – strangely at almost exactly the same location as the first time – the same hybrid system warning light came back on. I’d driving about 70 miles with it off at this point before the reappearance. This time I didn’t pull over to the side (had enough of that before) but rather drove a few more miles to a parking lot where the car has now stayed overnight. I note that the car seemed to drive perfectly normally during that time; no loss of power.
Prius (2004-09) :: Yellow Brake, Malfunction, Hybrid System, Master Lights Came On
I have a 2006 prius I got used and in good condition about 3-4 years ago. I never had any problems until a cop pulled me over and it turned out my parents had decided not to notify me they hadn't renewed my registration and my insurance they've been paying had ran out. I've since learned my lesson on keeping up with the dates.
I "luckily" got to go home with just some tickets. It sat about 2-3 months until I could get the money to line everything out. I ran it at least once a week but apparently that wasn't enough? Now that everything's up to date I started driving it and the yellow circle with the (!) in it is on. The Master system light, the check malfunction light, and the hybrid system light is on.
It seems like it applies the brake when I'm driving constantly now. It stalls when I first try to speed up. And the fan? on the passenger side of the back seat is always running for some reason. I tested my battery volt and it's at 9.2.
I took it to an auto shop today in town. I live in WV in the backwoods. And they wouldn't hook it up to check for codes and referred me to a dealer about 30 min. away... I've never had any problems with this car before.
Prius (2004-09) :: 2006 - Hybrid System Overheats With Codes P3190 And P3191
Something in my Gen II 2006 Prius is causing a type of overheating condition in the hybrid system. The fault/error codes coming up are P3190 and P3191. If I turn the car off for 30 minutes and restart it, it runs fine for a period of time (but usually not more than a week).
I first noticed the problem a couple of months ago during my 45 mile (mostly highway) commute. While driving on the highway, I noticed that the Prius wouldn't accelerate when I stepped on the gas pedal. A couple of minutes later, my dash warning lights come on and the car started slowing down (no response to the gas pedal at this point). For a minute or so, I was able to change gears (reverse or drive) and move a little in either direction but the transmission stops responding altogether very quickly.
Dash lights that light up
Hybrid system error symbol lit up and I noticed that the hybrid battery charge level was at one purple bar.
The first time it happened, I had my car towed to the nearest Toyota dealership. The flatbed tow truck driver (to my surprise) was able to start the Prius and back it into a spot at the dealership. Some of the dash lights were no longer lit.
The dealer couldn't find anything wrong with the car except for the fact that my water pump was leaking. They replaced the water pump, cleared the error codes and drove the car around for about 45 minutes but couldn't reproduce the problem. I drove my car home.
note: this dealership replaced my hybrid battery and 'computer' (I'm sure it has a specific part name - I don't have the info) right before my warranty ran out over a year ago. I didn't have any warning lights lit up on the dash at the time but I told the master mechanic working on my car that it didn't have much power going to the wheels when I put it in reverse (I couldn't back into my driveway). After the hybrid battery and computer were replaced, I had no issues with backing into my driveway.
The same issue happened a week later. I turned the car off for 20-30 minutes, started the car and noticed that the bulk of the dash warning lights turned off so I drove it home. I took it to my local mechanic the following day. He cleaned the intake manifold, changed the spark plugs, cleared the P3190 and P3191 codes indicating that they were generic codes indicating a misfire and said that it was now running fine.
A week later the same thing happened. I did some research and brought the car back to my local mechanic and asked him to change the transmission fluid & to use the Toyota ATF WS fluid. He changed the transmission fluid (and noted that it was dirty), cleared the codes and I brought the car home. I unfortunately didn't get a sample.
We had a power failure that night so I plugged my pond aerator into the cigarette lighter to keep my koi alive and less than 2 hours later I came out to find the pondmaster ap-20 (20 watt) air pump (blows bubbles through 1/2" tubing) wasn't running and my car had shut off with the dash warning lights illuminated. I have run this little aerator for 4 days on a single tank of gas without issues in the past.
Prius (2004-09) :: Red Triangle / Yellow Circled Exclamation - Hybrid System Failure
My wife was driving our 2009 prius this morning. she said the red triangle, this other yellow circled, light with an ! came on plus in the display window the car icon with the ! came on. Manual states that this is a hybrid system failure.
On very cold mornings the car smells very hot for a period of time. She said this happened again.
I tried to do a reset (turning it off and on atleast 4 times) did not work. So I had it towed to a dealer tonight and I started it again and this time very hot smelling and a whole lot more lights were on, ( brakes lights, almost all of the lights I would say.)
Prius (2004-09) :: 2006 - Loud Beeping Sound / Hybrid System Warning Light
I have had no issues with this car of 120K miles until today, although my MPG has decreased to 35 MPG. The following lights came on with a loud beeping sound : Brake warning lights, malfunction indicator light, master warning light and the hybrid system warning light. These stayed on for 25 minutes and then went off. I drove 12 miles without any issues with all the lights and sounds beeping.
View 4 RepliesPrius (2004-09) :: Water Pump Replaced Due To Failure / Change Coolant For Hybrid System?
Actually 2 very similar questions about my Prius 2007.
1. My water pump was replaced by a dealer due to failure some half a year ago at 95,000 miles. Yesterday, after oil change (98,000), I was told it is recommended to replace engine coolant. Does this sound right? Don't they change coolant when replacing the pump?!
2. Identical question about HV pump. It was replaced at 80,000. Now they recommend do change the coolant for hybrid system. Don't they have to do it when replacing the pump?
I want to do everything necessary to maintain the car. But don't want to spend money for something that is not needed.
Prius (2004-09) :: Hybrid Auto Charger Not Working
Finally got around to installing my new Hybrid battery charger from Hybrid Automotive in my 2007. Pretty easy & straight forward wiring install.
After installation I did the first test just hook up the charger to its dongle and no interlock and it looks ok shows 250 volts and 0 amps on there charger display but I have no battery fan. The fan is on in the charger but no hybrid battery fan..
No 12 volts from there charger to there fan control box input.
Install directions say all the fans should be running from the get go. Then I installed the interlock to see if it will charge and it does. Shows 222 volts and .337 Ma's which is correct but still no battery fan. No 12 volts form the charger.