Prius (2004-09) :: Inverter Coolant Pump Failure / Warning Lights Came On
My 2007 Prius with 162k miles had an Inverter Coolant Pump Failure Monday 6.5 hours from home when my wife was driving it home from a trip. Red Triangle, (!), vsc, and check engine light. She was able to make it about 20 minutes to a dealer where it was diagnosed. Luckily no further damage was done to vehicle. Yes, she should have stopped but continued on since car was driving OK.
View 7 RepliesPrius (2004-09) :: Inverter Coolant Pump Failure - P0A93 Code
I own a 2006 JDM prius with 323,000 km. The inverter coolant pump failed recently (got P0A93 code and no agitation in coolant reservoir). I ordered a replacement on eBay and am awaiting arrival. I may need to do some light driving in the in the interim and am thinking about installing a 10 inch fan in the space between the inverter/transmission and radiator to keep things cool. Is this wise or should I just let the car sit until the new pump gets here?
Also, I am burning oil...I usually have to top up 1 to 2 quarts in between changes. Is there anything I can do without tearing down the engine? A friend of mine suggested using Lucas oil stabilizer the next time I change oil...could this have any negative implications?
Prius (2004-09) :: Sudden Rush Of Failed Inverter Coolant Pump
We seem to be getting reports of failed inverter coolant pumps here on just about a daily basis. I'm wondering if they're all just failing now or if this is something of a "backlog" of failures that started in Winter but are only really being detected now.
View 14 RepliesPrius (2004-09) Fuel :: How To Determine If Inverter Pump / Coolant Reservoir Is Not Working Properly
How do you know if the inverter coolant pump/reservoir is bad after the recall was performed?Since it doesn't produce any codes but can reduce the electric-drive if getting too hot, how do you convince Toyota to give it a second look?
View 5 RepliesPrius (Gen 2) :: Inverter Pump Failure - Code P0A93
While driving home last night the Red Triangle, CEL and the Hybrid Warning lamp, (on the MFD) all lit up. The cruise control also shut down. We stopped and checked the manual to identify what the symbols meant. We were approximately 90 miles from home, drizzling rain and it was about 60 degrees.
View 18 RepliesGen 2 Prius :: Inverter Coolant Pump Failures
Having seen the rather catastrophic outcomes that are possible with inverter coolant pump failure, I've thought a bit about adding a flow sensor in the coolant path. I even went so far as to buy a flow sensor, which would probably do the job. However, it's somewhat heavy, and then there's the plumbing job to take care of. Seemed somewhat challenging to pull off.
Since this aborted endeavor, I began thinking about ways to detect surface turbulence at the top of the coolant tank, and am now thinking that might be easier to pull off, even if it requires programming a PIC to do the monitoring. My current thought is to install an LED and optical sensor in the cap, and measure light intensity received.
Prius (Gen 2) :: 2008 / Inverter Coolant Pump Leak?
I'm a new owner of a used 2008 Prius. Car only has 67K miles and other than the leak, appears to be in good shape.
I noticed the coolant was low in both reservoirs, filled it up (with the proper SLLC), but a day or so later the check engine light came on. Took it to mechanic (dealer is 2 hours away), he read and cleared the codes, then found the leak. Appears to be leaking where the lower hose attaches to the pump, so not sure if it's the pump or the hose that's the problem. I've also noticed that the pump seems a bit noisy for a few minutes after shutting off the car (of course, I'm new to the Prius so not totally sure what "normal" sounds like).
Prius (2004-09) :: 2008 - ICE Water Pump Failure / Engine Coolant Losing
I bought my 2008 JDM Prius a couple of weeks ago, at 84,500km. After a week, it started losing engine coolant. (Great start! Hope it's not a sign of things to come...) Fortunately, covered by a 3 month Dealer Warranty - hopefully. Yet to make the claim.
Anyway, went to the local Toyota Dealer to get some of the proper Toyota SSL (Super Long Life) Coolant to top it up. Got chatting with the Service Agent about Prius Service and what HSD Adjustments are possible (not many) and showed him my symptoms.
Prius (2004-09) :: Water Pump Replaced Due To Failure / Change Coolant For Hybrid System?
Actually 2 very similar questions about my Prius 2007.
1. My water pump was replaced by a dealer due to failure some half a year ago at 95,000 miles. Yesterday, after oil change (98,000), I was told it is recommended to replace engine coolant. Does this sound right? Don't they change coolant when replacing the pump?!
2. Identical question about HV pump. It was replaced at 80,000. Now they recommend do change the coolant for hybrid system. Don't they have to do it when replacing the pump?
I want to do everything necessary to maintain the car. But don't want to spend money for something that is not needed.
Prius (Gen 2) :: Check Engine Light Is On - Inverter Coolant Pump Shot
My check engine light is on and I think the inverter pump is shot. I have a some questions about how and when the pump is on. I have a mini vic on order and as soon as I get it hooked up I'll run for some codes. That is if I get it installed????
1- With the car in "ready mode" and at start up (car cold) should the inverter coolant pump be running.
2- With the car in "ready mode" Should I always see a water moving in the water reservoir.
Prius (2004-09) :: Power Inverter Failure While Driving
What happens when a power inverter fails while driving?
View 2 RepliesPrius (Gen 1) :: Triangle Lit Up With CEL, Could Be Coolant Pump Failure?
It's been over 90 degrees. Triangle lit up with check engine and I know the inverter coolant pump is a common failure, so hoping that is the culprit. I could take to O'Reillys and scan it to see if I get related codes...but don't want to drive until fixed. On my previous gen 1 prius the pump failed and it drove poorly...lacked power (from what I remember). Maybe even cut off once or twice.
View 8 RepliesPrius (2004-09) :: Panel Alarm Lights Go On And Power Lost - Inverter Failure?
My 2008 Prius (111,000 miles) had all the panel alarm lights go on and lost power while I was driving on the freeway. After turning off the vehicle and letting it “rest” for 10 minutes, it restarted with only the red triangle alert light remaining on and was able to drive to my dealer service (about 40 miles) with no incident. The diagnostic code indicates that the inverter has failed, but the technicians are not able to confirm that this is the problem, since the system is now running. I was able to drive it home with no problems or warning lights. As this is a $4,000 part, I would like to know if this is a likely, or even possible, scenario for an inverter failing, or could it be another problem? Note: 3 months ago the auxiliary battery was replaced following the same circumstances.
View 13 RepliesPrius (2004-09) :: Inverter Pump Noise - No Circulation
I have a big red triangle on the pump is making noises not loud noises sounds like it's operating correctly there is no turbulence in reservoir and when I squeeze the hose the level in the reservoir goes up-and-down which leads me to believe there is no blockage in the pipe coming out of out of the pump.
My handheld scanner and torque on my android tablet only gave me my oxygen sensor code which I know about and I'm going to replace when the weather gets hot I am wondering if the coolant pump would throw a code that these devices would be able to pick up or do I need to go to the dealer or find a shop which is capable of reading the HYbrid codes?
Prius (2004-09) :: Seems Like Inverter Coolant Leaking
So, the sideways coolant tank in the engine compartment, not the one next to the grill, but the one that is sort of between the air filter box and that shiny metal square
I have always thought that tank was slightly low, but it has a seam just about where the full line is, so I was never sure....finally about three weeks ago, I worked up my courage and put a few ounces of coolant in that tank. THEN it was up to the full line.
So, a few weeks after adding the coolant, I had the water pump recall done. Now the coolant level is back down to where it was before I added....so I am assuming that the correct level is just below that seam that seals the top of the plastic tank to the bottom part of the tank.
Prius (2004-09) :: Coolant Drip From Inverter?
I am getting a slow coolant drip from my inverter . The very slow leak appears on the left side of inverter when facing the front of car with hood open . The connection point alum tube to coolant resevoir black rubber tube. The inverter coolant connection reservoir tube side is damp to the touch and has visible red goop buildup.......
View 7 RepliesPrius (2004-09) :: Inverter Pump Noise Constant After Recall?
I recently had the inverter pump replaced under recall. it now makes a the pump noise even when I am driving. I hear it when car is not fully warmed. Back when it had the original inverter pump, it only made noise at startup and shut off.
View 2 RepliesPrius (2004-09) :: Drain Leaking Even After Recall On Inverter Pump
I posted a few months that after replacing my inverter coolant that the drain plug leaked. I tried to tighten it but that did not work. New Aluminum washer was installed. I took it in about 1 month ago for the steering shaft and inverter coolant pump replacement. After they drained the system and refilled post inverter pump replacement It still leaks.
View 3 RepliesPrius (2004-09) :: Inverter Coolant Reservoir Empty
Back in February, received a light and discovered that the inverter coolant reservoir was empty. I refilled the reservoir and cleared the code. Today, only 3 months later, the same thing happened. I don't see any wet hoses, puddles, or obvious signs of leakage. Where all my coolant is going? What steps should I use to properly troubleshoot...
View 8 Replies