Passat (B5) :: 2004 - Passenger Side Trunk Hinge Is Broken
I have a 2004 Passat GLX. the passenger's side trunk hinge is broken and will likely need to be replaced. looks like part of it rusted out and broke clean off. Also -- is it possible to just change the hinge without changing the strut?
View 2 RepliesGolf VI R :: Fuel Door Is Starting To Crack At Connection To Hinge
My fuel door is starting to crack at the connection to the hinge? It looks like from the assembly drawing that I'll have to remove the wheel and the wheel well liner to get to it but the drawing is not super clear.
View 1 RepliesVenture :: 2001 - Broken Glove Box Hinge Removal?
How to remove broken glove box hinge 2001 Ghevy Venture van?
View 3 RepliesPrius (2004-09) :: Rear Driver Side Door Lock Actuator Broken
I have a 2007 Prius and recently both my driver side front door and driver side rear door lock actuator failed. I browsed and found part number to replace the driver side front door lock assembly. I wasn't very confident in my ability to replace the assembly, but I decided to give it a shot, so I ordered the part. The part arrived today and my wife and I just finished successfully replacing the assembly. It was a little challenging, but now that we know how to do it we could probably do it again in half the time.
View 3 RepliesPrius (2010-12) :: Squeak In Driver Side Front Door Upon Opening / Closing - Hinge Replacement?
We have been tolerating a bad squeak in the driver's side front door upon opening, closing (any type of swinging of the door). Dealer tried lubricating it with no success. They told us that they would order a new hinge and "hope" that resolves it. I am a little worried about this. Would you trust your dealer to remove and re-install the door or just live with the squeak?
View 5 RepliesFord F-150 (2009-2014) :: Fuel Door Broken?
My fuel door took a dump last week and won't stay closed now. The truck is out of warranty, so I'll have to try to fix it myself, but I don't really know how to get to the broken part. Looking at it from underneath, it appears to have some kind of a spring set up, but I'm not sure how to remove it and then if I have to replace the whole housing, how does the actual door detach?
View 6 RepliesFord F-150 (2009-2014) :: Fuel Door Would Not Pull Itself Closed / Broken
On a roadtrip, went to fuel up and when I was done... the fuel door would not pull itself closed. I pushed on it, whatever spring or band was there pulling it closed is no longer functioning. 37500 miles on an '09. This really bothers me because of the no fuel cap design. Will have to take it to the dealer when I get home and find out what's the solution.
View 14 RepliesGolf IV R32 :: Changing Door Hinge?
Replacing the top door hinge on a mk4 r32 if so what size spline is it?? also has to remove the hinge pin?? was this a easy enough job if so whats the procedure.
View 3 RepliesPassat (B6) :: Driver Side Door Hinge Squeaky
Randomly my driver side door hinge squeaks....
View 6 RepliesFord Aerostar :: Doing Work On Door - Need Hinge Pins Kit?
I need to do the doors on my work van..Is there a hinge pin kit that works?
View 4 RepliesYukon :: 99 Replace Hinge Pin And Bushings On Barn Door Hinges?
Replacing the hinge pin and bushings on the barn door hinges? My drivers side upper hinge pin has completely sheared in two. I took it to the body shop today for replacement and they could not fix it. I think it was more labor intensive than they had imagined.
Anyway, they say I have to replace both the door side and the truck side hinge which are both welded on despite the bolts on the truck side. I found a site that retrofits the front door hinges and they have a special tool to press the old hinge pin out. Is this possible to press out the hinge, or should I try to drill them out?
Lexus GX 2010+ :: 120 VAC Power Outlet By Rear Door Hinge
Our 2010 base model GX 460 was 'born' in November 2009 and purchased new in February 2010, but we never used the 120 VAC power outlet at the back of the cargo compartment by the rear door hinge. I was cleaning and swapping 'summer' floor mats for 'winter' mats and decided to see if the outlet works. The appended pictures prove it does produce 120 VAC .... actually, almost 124 VAC, but I have no way to test if it can supply 100 Watts, much less the waveform shape. Perhaps it could light a 100 Watt incandescent bulb, but nothing sensitive to supply line glitches!
View 2 RepliesChevy - Impala :: Creaky Door Hinge Sound From Rear End Of Car
2007 Chevy Impala 1LT3.5L Flex Fuel 6 cyl engineauto trans50,500 miles
Note: All new struts and tires one year ago (approx 7,000 miles ago) after hitting raised pavement road hazard on interstate at 70 mph and bottoming out car. Entire suspension system was thoroughly examined for damage at the time and only struts, tires and one front wheel bearing needed repair/replacement. Also, just passed safety and emissions inspection about six weeks ago prior to this new creaking sound appearing.
PROBLEM: Since weather turned cold about two weeks ago, an intermittent "creaky door hinge" sound in the car rear end when driving over rough spots and to a lesser extent sometimes when turning. No noticeable change in how the car handles, rides, steers, brakes, etc. Just the creaky door hinge sound from somewhere in the rear end. No recent hitting of pot holes or other reason I can think of for why this has started other than the advent of cold weather. Pushing down hard on the trunk and trunk corners does not reproduce the sound, although I can't really push down all that hard so that is no proof one way or the other.
Lexus GS 2006-11 :: 2007 - Door Hinge Is Not Working Properly
The thread started from a guy with a 2007 LS where his door hinges were becoming basically awful to the point where it was very difficult to shut the doors. My response follows...
So it's almost been two years since the last post in regards to this but I thought I would share a similar experience I'm going through with my 2007 GS 350. 2 months ago I broke down and bought a set of hinges for the right rear door because it got to the point that you physically had to walk with the door to close it ($400 parts, labor, paint). I am now having a similar experience with the driver door and it's getting worse every month.
Sonata I45 (LF 2015+) :: Squeaky Front Passenger Door Hinge
I noticed earlier this afternoon that when I opened my front passenger door to reach in and get my phone out, the hinge creaked/squeaked. Everytime I would open/close the door it would make the sound. This door has only been opened about 5 times since I bought the car on April 30th. I have never heard tell of this on a new car, so it is disappointing. Had I had a passenger in the car and they heard that, well it would have been a little embarrassing on a brand new car. It sounded like a 30 year old car that had never had its door hinges oiled. It may just need some grease or something, but I would think this should have been lubed properly during assembly.
View 7 RepliesAzera TG (2006-11) :: Front Door Hinge Persistent Squeak
Have had a persistent squeak in my passenger front door since buying it used 9 months sgo. Tried WD40, even have had dealer install 2 new hinges.. but still have the loud squeak (starts about 1/2 way opening the door).
View 6 RepliesGolf IV / Jetta IV :: 2003 GTI VR6 - Door Hinge Creaking / Popping Noise
Got a 03 GTI VR6 and my drivers door kept on making this creaking/popping noise(it is very similar to the creaking noise of a old wooden door or the sound you hear in horror movies but for a lot shorter duration). The sound seems to come up when I accelerate, break take off from a complete stop. I took the car into the dealership and they torqed some bolt on the hinge and the creaking went away. Not a month later the passenger door develops the same creaking. The dealer tries to torqe the bolt on the hinge again and they say it cant be done and that their body shop needs to replace the hinge. They paint a hinge for me and put it on but don't get the door adjustments right so I get a lot of wind noise. Finally they adjust the door right and all is well.
A while later the drivers door starts creaking again! I went to another dealership and did an oil change while I was away on a trip to Toronto and the service technician said he could lubricate the door gasket and that this will take the creaking away. So he did. Now granted that has taken the creaking away but after some rain and 2 car washes the creaking came back in full swing.
I call the dealership to set up an appointment and they refuse to look at the door saying that as far as they are concerned the vehicle is up to manufacturers specs and that they will need to get a VW rep to look at it. In the mean time I call the vw customer care which tells me that they contacted the dealer and that the dealer beleves that the car is up to manufacturers specifications and that the noise I am hearing is normal and that all the cars have this noise.
Now I owned an 02 Golf GL 2dr and never heard that sound. It's been a month and a half and neither the dealer or vw customer care have called to inform me when the VW area rep. will be coming to have a look at the issue. It looks like I hit a dead end with having my issue acknowledged and looked at. Is this really a standard noise on the mk4 2dr platforms ? How I should pursue this issue ?!? Anything ?!
Golf/GTI VII :: Slight Rust Spot On Driver Side Door Hinge
I got pics, will upload as soon as I'm off work. But anyways, there's a small rust spot on the drivers side hinge, as well as a small spot on the passenger side rear door hinge. It seems rather hard for me to believe considering I'm the guy who periodically washes their car, and waxes all the door jambs and under the hood.
View 1 RepliesPrius (Gen 3) :: Opening A Door With A Broken Lock Mechanism?
My 2011 Prius apparently had a broken lock actuator on the driver's door, and knowing that the dealer would charge me over $500 for installation of a new actuator, I decided to order a new $5 motor off of ebay, and change the little motor inside the actuator myself. Everything was going fine until I put everything back together, and gave it a try. Now my door won't unlock at all. All of the other doors work fine. I've tried the little key from the keyfob, and turning it kinda feels mushy. My guess is that something is wrong with my re-installation of the cables.
View 1 Replies