Prius (2001-03) :: HV Battery Removal To Clean And Remove Corrosion?
I'm thinking about removing my perfectly functioning HV Battery to inspect it for corrosion and clean if necessary. I read so many posts both here and elsewhere that talk about corrosion being the number one reason Gen I HV Batteries fail. With that in mind, does it make sense to clean the corrosion off the battery (and related components) in an effort to extend the life of the battery.
The car is an '01 with 109,XXX miles, original traction battery, new 12V battery. The car has been very good to me (I believe that's due to steadfast preventative maintenance). There are no error codes and really nothing to complain about.
Prius (Gen 2) :: Changed 12V Battery - Found Water In Compartment
Just changed out my 12v battery in my 2008 Prius, I found water in the battery compartment. There have been heavy rains this past weekend but it should not have entered the car.
View 11 RepliesTouareg :: 2004 - Low Voltage / Key Battery Not Found Error Message
2004 V8 Touareg. Was getting all the "low voltage" error messages. "workshop fault" "headlight adjust" "brake system". Then one day I used my second key and get a "Key Battery not Found" message.
Dealer says the "low voltage" error messages have to be reprogrammed out of the computer and cannot be simply cleared. FYI I have a vagcom. They say there is no fix and I can either pay for a new battery or come back in to have them reprogram when they come up again. Is this true? New battery makes no sense to me as the battery is only two yrs old. Seems like quite the hassle as any cold weather and not starting up the car for a couple of days and I got to make a trip to the dealer. Is there a fix for this?
"Key Battery not Found"- Never saw this message until I used my second key. It obviously has a key battery since it opens the doors. Dealer is stumped and they wanted me to pick up the vehicle telling me that it was fine and the message didn't mean anything.
Prius (2010-12) :: Found Battery Tray Was Filled With Water
I am considering purchasing a 2010 as an upgrade from my current 2008, I have been reading recently as these last 3 days of constant rain made me check my current one for leaks and like normally the battery tray was filled with water.
View 3 RepliesPrius (2010-12) :: Found Water In Battery Compartment / Bad Odor Coming
OK, I've been reading a lot about this problem occurring in the pre 2010 prius where there is a crack around the hatch that fills the 12V battery well with water. About a month ago, I started getting a whiff of something rotting. A mix of the dead smell and rotting fruit. I was certain one of my kids left some food in the car or something got in the HVAC vent. As time has gone by, the odor has changed to more of a rotting leaves kind of smell.
I got out my shopvac and a snake camera. I went through the HVAC system and found that the filter was pulled back a bit. I replaced it on the spot. I found a few leaves and dust and that was it. The air coming from the vents from the outside smells clean. There were lots of wet leaves in the engine bay, but it wasn't the problem.
I started tearing apart the trunk because sometimes stuff spills into the tire well. I found the spare tire had turned brown on the tread.
I opened the battery compartment and found about an inch of standing milky white water. The kicker here is that the water didn't seem to smell that bad! I dried it all up and bleached the metal to kill any mold that might be in the residue...but the odor remains. The car smells awful!
I have torn apart the back of the car but I cannot find the source of the leak. I actually think it was from the car wash or going through a puddle and water got in the rear vent. The battery fender vent vanes were flapping with gusts of wind today, but even after a heavy rainstorm no new water has gotten in.
The car was hit in the parking lot and the rear fender moved about an 1/8th of an inch from the bumper, but there are no obvious signs of water entry anywhere... in fact, I was even suspicious that it might have come from the battery itself, but I didn't touch it (used paper towels on a snake to dry it up under there). I didn't think to try baking soda to see if it was an acid, which makes bleach pretty stupid to use...but I didn't see any foaming.
TL;DR Found water in my 12V battery compartment. My car smells bad. Cleaning out water did not improve smell. Nothing in HVAC system, it is only clean air source in car. No signs of water ingress above 12v battery well. After rainstorm, no additional water found in battery well. Fender vent flaps in gusty wind, but still no new water.
Prius (2004-09) :: Corrosion On Steering Knuckle Where Wheel Bearing Hub Assembly Seated
I have removed knuckle assembly and pressed out bearing hub assembly, I have the new bearing hub assembly..... I live in Iowa so there is corrosion on the knuckle assembly - I have removed enough that the new bearing assembly will go in....
My question/concern : With the corrosion removed the surface of the knuckle where the bearing will seat is not uniform all the way around. The bearing hub assembly will go in and will require pressure to do so but will the bearing last? I can buy a steering knuckle but do not want to if I don't have to.
Subaru - Outback :: Corrosion Of Tie Down On A Battery?
Having problem with corrosion of the tie down on a battery? The terminals are fine. It's just the metal plate that holds the battery in place with bolts. The paint has corroded off. I clean it up and cover it with dielectric grease. I have to do this every 4 to 6 months or so, because the corrosion keeps coming back. I had the same problem with my 2004 Subaru Legacy, and had to replace the battery holder as a result.
View 1 RepliesCorolla / Matrix 2009-13 :: Corrosion Around Terminals On Battery
So, I cleaned out my car yesterday and I noticed a bit of corrosion around the terminals on my battery. I just wanted to know if it is actually bad and how I should clean it.
View 11 RepliesNissan - 370z :: Battery Leak - Corrosion Under The Front Passenger Side
We got a certified used 370Z about 4-5 months ago from a Nissan dealership. The car was great until we happened to look underneath at around the 3 month mark and noticed that there was a TON of corrosion under the front passenger side. We had not even had the oil changed in the car- it was exactly as it was when we got it from the dealer. We took it back to them, and they said the battery had been overfilled and had leaked all over the car. Now it is in with them, and they say they have to remove the engine in order to sandblast it. They also happened to mention that they wish they had caught it before because if they had they never would have certified it.
View 13 RepliesFord F-150 (2009-2014) :: 2013 - Positive Battery Terminal Corrosion
My new to my 2013 f150 needs the terminal replaced due to corrosion. Need the p/n for just the terminal not the whole cable.
View 2 RepliesPrius (2004-09) :: Burning Oil - No Leakage Found
My 2005 Prius has 281,000 miles and is burning oil. No smoke or leakage just have to add oil between oil changes. I drive about 30,000 miles per year with my job. Car is paid for and I love not having a car payment, but fear this may be the beginning of the end.
View 4 RepliesPrius (2004-09) :: 2005 - Car Is Loosing Oil, No Leakage Found
My 2005 Prius is 161,000 miles old and I have only taken it to the dealership exclusively for service from the start.
Right before my last oil change the warning light (red triangle or with exclamation point) came on and the oil icon came on on the control panel. It would only come on when I pressed on the brakes. I finally pulled over outside an auto parts store and checked the dipstick. It was not showing any oil at all.
I went inside the store and put in three quarts. Took the car to the dealership the next day and they could not figure out why the car had apparently consumed so much oil. In fact, their scanning did not even show the warning light had ever come on.
Odd, since there were no leaks found. They changed the oil and told me to bring it back 1,000 miles later. Today, 1,000 miles later, I checked the dipstick and found that it shows only 1/4 full. When I last checked the dipstick, leaving the dealership, it showed close to full.
Prius (2004-09) :: Scanner Found Code U0293
Scanner found u0293,,,recommended reseal power inverter. what I have read for two days says its Power source ECU.. What happened,,,kids was driving car, had 3 phones plugged in, ac, lights, and when she tried to set cruise, car went into limp mode, gear lights flashing,,,went into neutral,,,stop beside highway,,had to be towed.
12 volt battery charged and tested ok. no blown fuses. I reset ECU by jumping pins 14 and 4. no change, tried master reset by holding brake and power button down, no change..removed ecu fuse to reset, no change.
Prius (2004-09) :: Check Engine Light On - No Codes Found
I have a 2005 Prius with 131k miles. The check engine light came on. I had my mechanic check for codes, he had 3different scanners. There were no codes posted. Next day light went off. It has been off for a week. Now it has returned.
View 5 RepliesPrius (2004-09) :: Knocking Sound Coming From ICE And Found No Oil On The Dipstick
This morning when I heard some knocking from the ICE and found NO oil on the dipstick. You wouldn't BELIEVE the drive the car did the day before when I lent it to my sister-in-law). Anyway, I thought the red triangle would illuminate with low oil. I can't seem to get the light to illuminate. Even when I first start the car and "all" indicators light up during the test. I'd say this is one important light. We've had the car less than a month and I could swear that when we first got it I saw the triangle at start up.
View 5 RepliesPrius (2004-09) :: 2007 - Oil Level Dropping Gradually, No Leakage Found
Up until my last oil change at 105,000 miles, I didn't notice any oil usage. When draining my oil, it didn't look like it was quite 4 quarts. After the oil change, I ensured that I had the engine exactly topped off to the upper mark on the dipstick. Around 600 miles later, I parked in the same location and have noticed that the oil level has dropped enough to notice. I am guessing that I will lose well over a quart between oil changes. Before I resign to the normal mechanical reasons (rings, cylinder wear, etc.)
The loss doesn't seem to be gradual which has me looking for other explanations. I also had a Toyota mechanic go over the car and replace the other fluids and filters at 100,000 miles (coincidence I think ).
Prius (2004-09) :: Thin Coat Of Oil At Bottom Of Filter / No Leak Found
Maybe I am running out of my beginner's luck. Recently when I did the second oil change at 10K miles, I placed the drain pan without taking into account the fact that the oil drains partially sideways. The oil stream ended up splashing off the edge of the drain pan and made a mess. Then I did not withdraw my hand fast enough when unscrewing the oil filter and allowed a stream of oil running down my arm and staining my new shirt. The I filled the new oil filter too full and had one more spill when installing it.
About two weeks later I found there was a very thin coat of oil at the bottom of the oil filter but no drips either on the filter or on the ground. I checked the oil level and it was the same as before. I checked the filter tightness with a torque wrench and it was also as tight as before. I wiped the bottom of the filter clean with paper towel. Now about another two weeks passed and a corner of the bottom of the filter is coated with oil again.
I am thinking maybe it was just the spilled oil gradually making its way from the (outside) top of the filter to the bottom? If there is a leak then I should get at least some drips, not just a thin film every two weeks, right? I also thought about untightening the filter and then tighten it again but I was afraid of large amount of oil coming out, would it? Also I had carefully checked the o-ring and wiped the flange clean before installing the filter and there are so many threads to screw the filter on - it is hard to imaging the filter would not seat correctly.
Prius (2004-09) :: 2005 - Two Lights On Dashboard / No Code Found When Run Scangauge
I have a 2005 prius and I got a scanguage to read the codes. I have two lights on my dash. One is the check engine and the other is the (O) light. I think this is something to do with the regen braking. Anyways when I run the scanguage it says no codes found. What type of scanner would be able to pull up all prius codes?
View 6 RepliesPrius (2004-09) :: 2005 - ABS / Check Engine And Red Triangle Codes Found
My 2005 Prius was working quite fine until few days ago when the dash lit up with ABS, Check Engine, red triangle, ((!)), and the red car symbol on MFD. Additionally, the hybrid battery fan now comes on once in a while. Mileage on car is 164K; changed the 12v and hybrid batteries at about 153K. Running it through codes scanners, the following codes were read off it:
* B1421 (Solar Circuit malfunction, passenger side. Also, AC malfunction [although on the car, the AC still seems to work fine])
* P3000 (Hybrid control fault, and cruise control error)
*C2318 (Low voltage error-power supply malfunction)
I have checked 12V status using the diagnostic mode this morning and found it to be 12.0V (although 2 days ago when I checked it was 11.8V.)
I have not used the car since as I wouldn't want it park up by the roadside. I'm scarred to think its the hybrid battery again... For now, the car still moves well. What should I check to confirm real cause(s) of all these?