Prius (2004-09) :: Coolant Heat Storage Tank Pump Making Noise?
I'm getting a noise that sounds like "woooooooooo" from the right front of the engine compartment when the outside temp gets below about 20F and I just start the car. The colder it gets, the longer the noise lasts.
I suspect it's the pump that's part of the CHS. Just a very wild guess. The noise goes away when the car starts to warm up. No drive ability problems.
Prius (Gen 2) :: MIL Showing Up Intermittently - DTC P1151 Coolant Heat Storage Tank
My MIL has been intermittently showing up, and I'm pulling DTC P1151 - Coolant Heat Storage Tank. This is the only DTC that I'm getting. I have recently replaced the Coolant Control Valve, as I had been getting a P1121, and attempted to refill the coolant myself.
View 5 RepliesSaturn - Sl :: Coolant Leak After Replacing Belt Tensioner Assembly
We have a 97 Saturn SL2. The belt tensioner assembly cracked and after the guy replaced it, immediately upon driving, the low coolant light starts flashing.
Drove it this way a few times while keeping an eye on coolant level. Parked car for a few days, then notice a big puddle of green coolant under car. It has been sitting now for several weeks.
Could increased tension from the new tensioner pulley cause the water pump to die?
The car has never overheated, though. If water pump was toast wouldn't it overheat?
Prius (Gen 2) :: 2005 - Intermittently Noisy Coolant Storage Pump
I have an 05 Prius with pump issues. My coolant storage pump has been making an intermittent coarse squealing noise since I've owned the car. It seems to be worse in cooler weather. It only happens when turning the car off. Does this pump only operates after shutting the car off? If that's the case, then I won't worry too much about it. If it's supposed to function when the car is on, then I may worry. Does the pump keep running until it's finished, or is it just a timed cycle? I'm concerned if there's air in the line, it may prevent the pump from completing it's job if it's on a timed cycle. Also, if I have to replace this pump, how would I go about bleeding all of the air out of the system?
View 5 RepliesGolf IV / Jetta IV :: 2004 GTI 1.8t - Car Not Turning Over After Replacing Headlight Assembly
So car not turning over after replacing (right side) headlight assembly. Was turning over prior. Replaced the battery, same result.
View 4 RepliesFord F-150 (2004-2008) :: 2006 XLT - Replacing Wheel Hub Assembly?
I've got an 06 XLT 4x4 with the 4.6L. I'm replacing the wheel Hub bearing assembly this evening and got the old one removed. Opened the new on to find no grease! I was shocked considering I just replaced the IWE and they come pre-greased. I plan on adding some grease around the hub gear but wondered if i should some how get grease in on that inner needle bearing? I have to have this put back together in a couple of hours so I can drive to work tomorrow.
View 6 RepliesPrius (2004-09) :: Rattle In Center Storage Compartment Lid?
Have a rattle in the center storage compartment lid? If so, what did you do to get rid of it? In the meantime, I put my right arm on it while driving.
View 5 RepliesPrius (2004-09) :: Long Term Storage Of High Voltage Battery
I have an opportunity to get a high voltage battery from a salvage Prius. I don't need a replacement now but thought having an extra battery would be a good idea. How long can the battery be stored? Maybe switch them out every few months to keep both charged?
View 3 RepliesPrius (2001-03) :: 2002 - Gas Mileage - Replacing Coolant And Inverter
I read in the owners manual that the engine antifreeze should be an ethylene glycol type. I believe that Prestone makes this type of coolant in a 50/50 mix. Is that correct? Also, what type of coolant does the inverter use? I want to try and stay away from buying it at a dealer. Also, my gen 1 has 117,000 miles and I must admit that I have been slacking with the maintenance. My gas mileage is down to 40/mpg compared to 48-49mpg when I got the car two years back with 40k. I am pretty sure the original auxillary batter is still in it, so I order a new one today. I also plan an changing the transaxle fluid, PCV valve, air filter, and cabin filter. The plugs where changed at 80,000 miles. Where can I order a gasket for the transaxle pan? I intend on dropping it and cleaning it out. Do you think this will get the gas milage back up?
View 3 RepliesPrius (Gen 2) :: Coolant Tank (close To Radiator) Empty?
I just noticed this morning that the coolant tank (close to radiator) is empty. The other coolant tank level is normal. Big surprise! I thought they are connected, and coolant can flow between them.
View 5 RepliesPrius (2004-09) :: 2008 - Headlight Assembly Replacement
The drivers side headlight assembly on my 2008 Prius has moisture in it. I have 52,000 miles on the car, so I do not think it is covered under warranty. What / how can you replace the headlight assembly?
View 7 RepliesPrius (2004-09) :: Brake Light Out / Replace Whole Assembly?
My dealer wants to completely replace the whole tail light assembly because the rear passenger break light is out. Is this really necessary just to replace a light bulb? (2004 Prius)
View 10 RepliesGolf IV / Jetta IV :: 2004 GTI 1.8t Started Overheating - Little Steam Coming From Coolant Overflow Tank
I have an 04 gti 1.8t and last night it started over heating. I pulled over and checked the coolant and the oil but everything looked good. I let it cool down and drove it home. When I popped the hood there was a little steam coming from the coolant overflow tank but I saw no leaking. I decided to vent the pressure off the system and then I got a little drip on the passenger side close to where the inter cooler is. I can't pinpoint the leak though.
View 4 RepliesPrius (2004-09) :: Corrosion On Steering Knuckle Where Wheel Bearing Hub Assembly Seated
I have removed knuckle assembly and pressed out bearing hub assembly, I have the new bearing hub assembly..... I live in Iowa so there is corrosion on the knuckle assembly - I have removed enough that the new bearing assembly will go in....
My question/concern : With the corrosion removed the surface of the knuckle where the bearing will seat is not uniform all the way around. The bearing hub assembly will go in and will require pressure to do so but will the bearing last? I can buy a steering knuckle but do not want to if I don't have to.
Prius (2004-09) :: Awful Noise Coming From Front Driver Side Of Car - Mid Hub Assembly Stuck
I've had some awful noise coming from the front drivers side of my car. Determining the likly cause to be the wheel bearing, I decided to tackle replacing the hub assembly as a lovely weekend project. Things were going along ok - Removed brake caliper, removed the axle nut (that wasn't fun), removed the rotor (rather persistently stuck on, but it gave in the end), and then came removing the hub assembly itself. Had a rented hub puller, put it on, started tightening it down and tapping on the hub as I went. It was getting pretty tight on there (was starting to worry about the safety of the cv shaft), and then as I tapped on the hub one last time, the hub and hub puller popped off the car... I was elated, until I realized rather than pulling the entire hub assembly out, it had actually separated the inner track of the bearing from the outer track, leaving the wheel bearing and flange behind inside the steering knuckle.
So, here I sit, with half my hub assembly on the ground and the other half still in the car. How to get the rest of the hub assembly out, now that there is nothing to really pull on? I've tapped around on it for a couple hours, and soaked it in enough penetrating oil to make the car flamable, but no give. I've even tried putting the hub bolts back in through the back and tapping on them with a hammer to no avail (probably going to have to replace the bolts now, but one problem at a time).
Prius (2010-12) :: Long Term Storage - 7 / 8 Months
Had to store prius for 7 or 8 months? Does the hybrid battery need to be disconnected?
View 4 RepliesPlymouth - Sundance :: 1991 - After Replacing Fuel Tank Gas Gauge Showing Less Than Empty?
I recently replaced my gas tank in my Sundance, it was getting very rusty around the sending unit area and was starting to leak. Everything is back together and it is running well with no leaks. The new problem that it has, when the car is running, the gas gauge shows less than empty, even though it has a considerable amount of gas in it. When I shut the car off, the gas gauge slowly moves up to where it normally would be when it would be running. Did I somehow mess up the ground or did I cross something? This is my daily beater car and need a working gauge.
View 1 RepliesLexus RX 2004-09 :: Crack Appearing On Passenger Side From Storage Box Upwards On Dash
09 RX acquired late December 09. Now we are seeing a crack appearing on the passenger side from the storage box upwards. Car is always garaged and hardly eve in long times in sun. Is this a warranty event?
View 2 RepliesPrius (2004-09) :: Replacing New Struts / Shocks
I'm looking at replacing the struts and shocks in my 04 Prius. Last time I replaced them with some cheap KYBs I found on auto parts warehouse. I was hoping for an improvement over the old worn out parts, but didn't feel an improvement. Well after 5+ years and who knows how many miles I figured it was time to replace them again.
View 7 Replies