Prius (2004-09) :: Code P1121 - Coolant Flow Control Valve Position Sensor Stuck?
The check engine light on my '05 Prius has gone on and off a couple of times and is giving me a P1121 code, which I found out means "Coolant Flow Control Valve Position Sensor Stuck". Does this have anything to do with the hybrid electric coolant pump that was replaced under recall a while back?
View 5 RepliesPrius (2004-09) :: Code P1121 - Coolant Flow Control Valve Position Sensor Stuck
It's been a long week for me and my 2007 Prius. Brought it to the dealer after receiving my first ever CEL. I have 222,000 miles on the vehicle. The a/c was also blowing warm when the CEL came on. They checked that and told me that the compressor was "breaking up." Then they call me back to tell me that my 12V battery died. They asked me if I had problems with starting the vehicle. I said never. Never had any issues with the car in 222,000 miles.
Well, told them to replace the battery (no choice) and the car is 5.5 years old in Florida heat so it was ready to die. Very suspicious that it died while they had the vehicle, but what can I say. Told them to not repair the coolant flow valve or the a/c until I could investigate further on my own. CEL is now off. The a/c is blowing cool again.
Prius (2004-09) :: CEL Along With Code P1121 Coolant Valve Came On
What is the to cause to check engine light go off. I will take my car to auto zone tomorrow morning to hopefully get a code and see if I can fix it myself... if not, then I am going to have to go to the dealership.
View 19 RepliesPrius (2004-09) :: 2005 - Code P1121 / Coolant Valve Control
i have a 2005 Toyota Prius that the air conditioner wont work in. it has Freon in it the compressor wont kick so I did some research and my cooling fans aren't kicking on so I did a by pass test and the cooling fans motor is good they just wont kick on. I just replaced my 2 cooling fan relays and they still wont kick on. the check engine light was on in the car when I got it. it throws the code P1121 coolant valve control. I got the part just got to get it put on. Could this part stop my cooling fans from kicking on or my ac compressor from coming on.
View 3 RepliesPrius (2004-09) :: Coolant Flow Valve Code 1121 With CEL On
I have read all the posts pertaining to this code, replaced my coolant flow valve, bled all the air out of the coolant system and still am getting the cel with the 1121 code.
I have tried setting multiple coolant flow valve positions, checked all wiring in harness, coolant level is full in rad and reservoir, checked temp sensor at bottom of storage tank, checked pump operation at top of tank to attempt to clear this code to no avail.
Is there a default position the valve is to be in before cold start up?
Is there anything else that can trigger this code? What am I missing?
Prius (2004-09) :: What To Do About Check Engine Message - Code Is P1121
About once a week my check engine light comes on. The code is P1121, which is about coolant valve sticking. In about one or one and a half days it times out and i dont get the warning light for another week or so. Do you think I should have something done right away or wait and see what happens?
View 1 RepliesPrius (2004-09) :: Check Engine Light Just Came On - Coolant Control Valve Sensor?
My wifes 2008 prius check engine light just came on. Its the control valve sensor. My question is, does that have any serious impact on safety? I've heard mixed on what this valve does (overheating etc).
View 6 RepliesPrius (2004-09) :: 2009 - Check Engine Light Came On / Coolant Valve Replacement
I have a 2009 Prius and the check engine light came on last week. I decided to take it to a highly recommended auto repair shop instead of the dealer. The error cord was P1121 and they replaced some kind of coolant control valve. When I went to take the car home I noticed the check engine light was still on and they said there was another similar but different coolant valve that needed to be replaced. They replaced the other part and everything seemed fine.
View 10 RepliesPrius (2004-09) :: Intermittent Buzzing Sound From Engine Bay - Bad Coolant Flow Control Valve
For several months now, my 2007 Prius has been making an intermittent buzzing sound from the engine bay. When I first heard it, I thought I had hit the little lines they cut into the road to let you know you've drifted over the center line - the sound is like that, a low-pitched buzzing noise. Today, the check engine light came on as it was making that noise. I put a code reader on the car and got P1121, a bad coolant flow control valve. Wondering if the sound and the faulty control valve are just coincidental or if the valve might make that noise when it fails? And if not the valve, what the sound might be?
View 19 RepliesPrius (2004-09) :: Check Engine Light Came Up With P1121
I took my 2009 Prius in to have the check engine light read and they came up with P1121 and recommended I have the coolant flow control valve replaced. I bought my prius used and noted that in the service history, the valve was replaced under warranty in Feb. of 2013, about 40,000 miles ago. I'm going to have the valve replaced, the prius and I are embarking on a 1500 mile journey in a week or so and I'd rather not take the risk of not replacing it.
View 6 RepliesPrius (2004-09) :: Check Engine Light Came On - DTC P1121
The narrative: The check engine light came on and the DTC reads P1121, which indicated trouble with the coolant control valve. I cleared the code several times and it reappeared. It has been >100F every day here in OK. Investigating under the hood I noticed the engine coolant overflow tank was empty. Opening the radiator cap showed no visible coolant in the tube! OK, I have not seen any leaks and the car has had dealer service 3K ago. I filled the radiator and overflow w/ SLLC (Toyota pink). The DTC has not reappeared and it has been about a week.
My comments/questions: The car is getting old and I can accept a little maintenance. 2004 Prius @96k...
Prius (2004-09) :: 2008 - Getting P1121 / P1116 - Replaced Coolant Control Valve And Red Triangle?
So I drive a 2008 and a couple months ago I started getting the Check Engine Light. Codes P1121 & P1116. Found out it was most likely related to a faulty Coolant Control Valve or Electric Water Pump. Since the pump was just recently changed I went ahead and got the valve changed.
The light is still coming and going but now when I go on the expressway that red triangle with the exclamation pops on with a little beep. Only pops on for a couple seconds and keeps coming back until I drive a bit slower.
Prius (2004-09) :: Check Engine Light Codes P1116 And P1121
Just last week I bought a 2007 prius from a local dealership in Houston. The check engine light recently turned on and had it checked out by an auto parts store. The codes they read were the p1116 and p1121 (issues with the coolant valve). I know it would cost much to replace the valve, and I am not wanting to pay that much, especially since i just bought the car. I'd also be willing to fix it myself if i had some guide or step by step instructions...
View 3 RepliesPrius (Gen 2) :: Overheat Light Coming On After Coolant Flow Control Valve Replacement
I was getting a check engine light with a P1112 code, so I had a mechanic replace the coolant flow control valve. There's a TSB on that and it seems to be the thing to do. But after the replacement, I'm getting overheat warning light whenever the engine needs to work hard. Also, the cabin heater only works when the gasoline engine is not running... when the engine is off, I get heat (though it's not as hot as I'd think when I have it on max heat), but when the gas engine kicks in, the cabin heat disappears.
View 8 RepliesPrius (2004-09) :: CEL For P1121 / Valve Replacement?
I have a 2004 toyota Prius with 185k miles on it and recently got the CEL for P1121. I checked both coolants and turns out that the engine coolant was completely out. I immediately filled it up and the CEL went off for a couple days. It has come back and is on constantly, I checked the coolant and the coolant is at the correct level.
View 19 RepliesBuick - Terraza :: 2005 - Check Engine Light With Low EGR Flow Code
I am having a hard time getting the low EGR flow check engine code to clear. The EGR valve and tube from the exhaust manifold were replaced, the wiring harness verified, the passage channel between the EGR valve and the intake manifold cleaned out...but the check engine light remains... what to try next?
View 12 RepliesBuick - Terraza :: 2005 - Check Engine Light With Low EGR Flow Code
I was going to look into getting a replacement EGR valve from AutoZone, which I did. After installing the valve and on my way to reset the check engine light, it went away and has not come back.
View 1 RepliesFord - Explorer :: 2001 - Check Engine Light With EGR Low Flow Code
I have an 01 Explorer Sportrac with a 4.0, 105,000 milles. Got the check engine light with the EGR low flow code. I get this code about once a year and a new DPFE usually takes care of it. I get the sensor from Advanced Auto which explains the short life I am guessing. Last time i replaced the sensor the light came back on a couple weeks later.
After highway driving smoke starts pouring freon under the hood, passenger side, but by the time I get the hood opened its done. Cant tell where it is coming from. Could a faulty DPFE cause the smoke or do you think the EGR valve may be sticking? I was going to try a Ford DPFE this time but I hate to just throw parts at it. Where do the smoke is coming out of, air filter box????? cant see anything else over there related to the EGR system......
Mazda3 :: 2009 - Check Engine Light / PO101 Error Code For Mass Air Flow
My check engine light keeps coming on sporadically and giving me a PO101 error code...then I'll reset it after making sure my MPG hasn't dipped a significant amount (which is my "concrete" way of gauging if it's performance is impaired) and it'll come on 1-600 miles later. There's no consistency in environment or conditions that are triggering this sensor, at least it's not obvious to me. I finally looked under the hood at the filter and it's a little dirty, but not nearly dark enough for it to be the problem.
View 4 Replies