Prius (2004-09) :: P3024 Code After Reconditioning Battery Pack
Back in November/December I discharge/charge-cycled each module in my battery pack 3+ times after replacing 3 bad modules. I didn't get to reassemble everything and drive the car until the holidays. On short trips around town, everything seemed okay, but on longer trips (limited data here, but say 40-45 miles) I got the red triangle and some other lights (see photo). I read the code as P3024 which from what I find means Battery Block 14 Becomes Weak. I can clear the code and the car is happy until the next trip...
View 19 RepliesPrius (2004-09) :: Triangle Of Dead With The Code, Replace Battery Pack
About 1500 miles ago, I replaced a cell in the battery pack. Now the triangle of dead is back and the code is "replace battery pack" again.
I tested all the cells and here are the results.
(the previous one I replaced was 4.5 volts, very low and easy to find)
Prius (2004-09) :: CEL And Triangle Of Death On 2007 Gen 2 - Replace Hybrid Battery Pack
I have a 2007 toyota prius. The car drives, but pulsates. The Check engine light and triangle of death are on. Diagnostic test says "replace hybrid battery pack", but wouldn't the car not even start if the bat pack were dead? What it could be? perhaps a bad cell or two? a bad ecu?
View 19 RepliesPrius Plug-in 2012-15 :: EV And Hybrid Mode Run On Same Battery Pack?
Does PIP have two different batteries for each mode (EV and Hybrid) or is it the same battery?
View 10 RepliesPrius (Gen 2) :: 2005 Won't Start After Replacing Bad Cell In Main Battery Pack
I have two Prius's, a 2008 and a 2005. My 2005 with 129k miles on it is the one in question. Recently I got a check engine light with the code P0A80 and P3016. I purchased a pair of tested to be good cells from Ebay which finally arrived in the mail yesterday. Today I finally got around to installing it and everything was pretty self explanatory... One of 28 cells tested to have 6.24v in block six and all the others had between 7.98-8.00v all around. I went ahead and replaced the bad cell with the new one and put everything back together and now the car will not start.
Cliff notes: Replaced bad cell in main battery back due to CEL P0A80 and P3016.
Car will not start, only turns on...
Getting error message on the radio screen about the Park position is not correct and to park the car on a flat level ground with parking brakes and try again.
Have charged the 12v battery to make sure it has enough juice in it.
Prius (2010-12) :: Hum / Buzz Coming From Back End (Battery Pack Area)
On more than one occasion, when I have gone in my garage at around 5 a.m., I hear a hum/buzz coming from the back end of my Prius. It has to come from the battery pack because the sound seems to come from under the back end of the car and is not as audible when I open the hatch.
View 2 RepliesPrius (2004-09) :: 12V Battery Drained And AC Stopped Working
I've had a 2004 Prius for about one year. It has ~120K miles and has been a great car. We left a light on, and the 12V battery died. We jumped it and everything seems to work fine, except now the air conditioner isn't working.
View 2 RepliesPrius (2004-09) :: Nav And Menu Not Working When Got The 12v Battery Replaced
I've attached some pictures of what it looks like. Sometimes there are no lines and just black but the display button still overlaps. Everything else seems to be working. I think this happened when I got the 12v battery replaced. I am also not sure I have a nav dvd. How do you eject those DVDs?
View 2 RepliesPrius (2004-09) :: Smart Key Quit Working After Replaced Battery
I am not sure if I need a new fob.
My smart key quit working. I have replaced the battery, and checked the button under the steering wheel. The little red light on the fob does not blink or light up when I push it. I think I recall this light coming on when a button is pushed.
Prius (2004-09) :: Regen Battery Charging / Working Extra Well But MPG Is Down
I've been noticing that my battery is almost always fully charged or close to it. Then I noticed that when I 'should' be getting assist from the MG2 and not charging the battery, i'm not getting the assist I would assume I should be getting. Seems like most of the energy is getting put back into the battery instead of assisting the MG2
Notice how the arrow is going to the battery from the MG2 (ELECMOTR) and not vice versa. This is majority of the time. Getting less of this also. hince - MPGs are down also.
Prius (2004-09) :: Engine Charge For HV Battery Not Working Properly
When stuck in traffic jams, and my 2004 Prius shows 2 bars on the HV battery charge, it attempts to start the engine to maintain the charge on the HV battery. What was happening was the engine would attempt to start and then it would immediately die. It would keep repeating this process, over and over again, and would not charge the HV battery. Once I started driving out of the traffic jam, the engine ran fine and it charged up the HV battery while I was moving down the road. I decided to clean the throttle body. My charging problem did change due to me cleaning the throttle body. Instead of starting and immediately dying, over and over again, the engine no longer dies.
It now revs up, and slows back down to idle over and over again when sitting still with 2 bars of charge. The display does not show any charging going on during this revving up and slowing down episode. I need some more hints as to what to check out. I am studying electrical diagrams of the vehicle, but I need a synopsis of which system starts the engine for HV charging, and which system keeps the engine revving at the same RPMs during charging while not in motion. The throttle body cleaning made my 257 K mile Prius run like a scared deer again. I just need to get her charging while sitting still again. 12 volt charging system is in the 14+ volt range and 12 volt battery with no load is around 12.2 volts.
Prius (2004-09) :: 2005 - Battery Not Working - Dying Repeatedly At 120,000 Miles
Trying to figure out whether to fix or scrap our 2005 Prius with 193,000 miles and a mysterious 12V battery problem. What would you do in my situation?
We've had a recurring problem with the 12V accessory battery: I have replaced it myself three times. The last failure was the most mysterious, because after replacing the 12V battery for the third time, I conducted nearly daily voltage tests using the Prius' "secret" vehicle signal check. Voltage coming off of the 12V was normal, if not high the entire time in all of the Prius's various starting and ready modes. I wired up a solar panel to trickle-charge the 12V battery when we weren't around, and we plugged the 12V in at night to a trickle charger to keep the battery topped up.
Nonetheless the day came a few months after the latest replacement when we had our usual 12V failure symptoms: the time on the clock started resetting, the car didn't turn on on the first press, the Prius computer rebooted, and eventually the car wouldn't start without a jump start. This has been super-frustrating, and googling around, I haven't been impressed by people's reported experiences trying to have the dealer try to resolve such problems. My worry is that a dealer repair person will change the accessory 12V battery without fixing the underlying problem. I would suspect a parasitic draw somewhere, but voltage tests when the car was overnighted without any kind of charging did not suggest a serious voltage draw on the 12V battery.
Other details about the car: our keyless entry hasn't worked for several years (dead batteries in the key fob?) and we open the car manually using the key each time. We stick the fob in the slot each time we want to start it. MPG is comparatively low vs. other Priuses, perhaps 44-45 MPG, and lower when the 12V battery starts to die (37-40). I have had the car serviced (oil, etc.) like clockwork every three months; recently, I've noticed the engine is starting to burn oil a bit (level is reported low on each change).
Most of the driving has been done in the flats and the heat of California's Central Valley, and we've put something like 120,000 miles on it just in the last five years. Besides the fact that the 12V battery keeps dying, the car has been very reliable.
We just inherited a free Prius with just 60,000 miles on it, and I have a 1993 Camry with 150k miles on the chassis and maybe 60k miles on the replacement engine I had dropped into it a few years ago. The Camry just passed California's smog test and seems to be running well. We don't want or need three cars.
Our choice is to try to fix the Prius with 193k miles on it and donate the Camry (which gets about 20 miles to the gallon, the horror...), or keep the Camry and donate the Prius. My instinct is to not drop thousands of dollars into the high-mileage Prius, especially if these issues might be pointing to a dying main battery.
Prius (2004-09) :: 2006 - Battery Won't Working Properly After Two Month Rest
We spend summers away and our 06 Prius stays in the garage. I connect a battery minder and it keeps the 12v battery charged with no problem. I also turn off the switch under the steering column that works with the remote.
When I started the car after two months and driving for a few blocks, I noticed the MFD showed the battery at a low of two purple lines. After a while, it charges up normally. The car has 47000 miles and the 12 v battery has never been changed. Would that have something to do with it or am I being concerned over nothing?
Prius (2004-09) :: Smart Key Stopped Working After Replacing 12 Volt Battery
A purchased a new 12 volt battery at the dealer. I was getting weird warning lights, so I had them run diagnostics. They said all the codes were voltage and I needed a new battery. Shortly after this I noticed the Smart Key no longer opened and closed the doors.
The car starts ok.
My question is this, could the changing of the battery have caused this? I tried searching for the answer BUT all answers refereed to adding a new smart key purchased on Ebay.
Lexus LS 2007+ :: 2008 - LS600h Swapping Of Battery Pack?
So with the nice weather here I can start driving the SC430 more which lets me think of projects for the 600 that might leave it in bits for a few days or week or so. I know that in 09 or 10 the 600 got a change to the battery pack that ended up increasing the room in the trunk by about 15 or 20%. I think they changed the NiMH traction battery pack.
The question is - can I swap out just the battery pack or does I need to swap other parts from the hybrid system? Was the increase in trunk space worth the trouble?
Honda - Accord :: 2006 - CEL Code For Battery Pack Deterioration Came Up
My husband and I just bought a 2006 Accord Hybrid with 123,000 miles on it. The IMA and check engine lights came on two days later. I had the diagnostic check done on it and the code for battery pack deterioration came up. I read online where this code could be caused by the 12-volt battery going bad, and as it had the original battery in it, and the check on that showed it needed to be replaced, we did that. Two days later, the lights were on again. So we know we're going to have to replace the battery pack, which we're okay with, but what we want to know is whether the car will still run once that battery is completely shot. So far, it's still showing a good charge on it - whether that means anything, I don't know. Also, if it will run without the IMA component, will we be doing any damage to the car if we let it go for a few weeks?
View 8 RepliesPrius (2004-09) :: 2008 - CEL Came On / Battery Display Shows The Battery Is Green
I tried to turn on my car this morning, but the "Ready" sign didn't go on. The whole display is black. "Check Engine" sign blinked briefly. Battery display shows the battery is "green". Everything else works - cd/radio/bluetooth, etc. As I tried to start it, the screen showed that the engine briefly charged the Prius battery, then it was all quite. I tried to wait and restart a few times, but still the display was all black and no "ready" sign. I WAS able to still move the car, but I didn't chance to drive it out of the garage. I just had it serviced (oil/fluid change). Small battery was replaced in July.
View 19 RepliesPrius (Gen 1) :: Vehicle Won't Start After Sitting / ECU Consider Pack Disconnected
I have a Gen 1 that won't start after sitting. ECU considers the pack disconnected. 12v brand new.
What is the easiest way to get it going without removing the pack?
Prius Plug-in 2012-15 :: Charging The EV Pack While Driving
From my understanding, there are 3 batteries in the PIP. 2 of them are for EV mode, and 1 is for Hybrid mode. they are all hooked up together and also the electric motor when it is fully charged. when the first pack (ev pack) get's depleted, it will disconnect via relays from the remaining 2 packs. then when the second pack is depleted (second EV pack) it will discontinue from the last remaining pack. below is a small simple diagram of what it looks like:
Fully charged: (EV1)-----(EV2)-----(HYBRID)-----[motor]
1st pack depleted. still in EV mode: (EV1)---x---(EV2)-----(HYBRID)-----[motor]
both EV packs depleted and in HYBRID mode: (EV1)---x---(EV2)---x---(HYBRID)----[motor]
(x = disconnected)