Ford Super Duty (1999-2016) :: 2001 F350 - Instrument Cluster Lights Will Not Work
I have a 2001 F350 and instrument cluster lights will not work. Fuses are good and the gauges still work just not the lights.
View 5 RepliesFord Super Duty (1999-2016) :: 2003 F550 - Batteries Not Charging / Instrument Cluster Does Not Work
I have a 2003 F550 6L diesel flatbed truck. Last week, the overdrive button would activate by itself. I'm assuming there was a loose wire so I taped the button to keep the overdrive off. Two days later, the overdrive came on while the button was pressed in and then smoke came out of the steering column/lever area. I pulled over and turned off the truck. The smoke stopped after 10 seconds and I restarted the truck. The overdrive light/functionality no longer worked and the instrument cluster also wasn't working.
The next day I was driving, and the truck died at a stoplight. I got it towed home, and opened the steering column and noticed that the overdrive button wire had burned. I removed the harness clip and charged the batteries. It started but the instrument cluster still didn't work. 2 minutes later the truck died. I replaced the alternator but still it won't charge the batteries. The truck dies 2 minutes after getting a battery boost to start the truck. The instrument cluster also doesn't work. What could be causing this issue?
Caravan/Voyager :: 2001 - Short In Hazard Circuit / Instrument Cluster Is Dead
My problem is similar to that of coyote54 back in 05. I have a 2001 Grand Caravan Sport. Instrument Cluster is dead, Information lights on top of dash are dead, Turn signals and Hazard lamps are not working. Found Hazard Lamp fuse to be blown. Replaced fuse and blows immediately indicating a short. Haynes describes a Turn Signal/Hazard Lamp and Daytime Running Light Module located on the junction block but there is no such animal that I can find. One of the responses to coyote54 described a Hazard relay located within the steering column........again, I do not see anything on the column that resembles a relay. Is there a hazard flasher/relay on the 2001 GC.
View 14 RepliesPlymouth - Voyager :: 1999 - Smells Like Gas
My 1999 Plymouth Voyager smells like gas, really bad. I have taken it to my "car person" and he has tried everything he knows to find out what may be causing this. He has checked all the lines and even run pressure thru the lines to try and find a leak but hasn't. Yet the smell remains. It is really strong on the drivers side near my door. As my husband 90 ford ranger just recently caught fire while he was driving down the road and burned completely up I am more that worried about this happening to me. I am even afraid to park it in the garage most night. My mechanic did say he didn't find any leaks and especially any in the engine....so why does the smell stay???
View 7 RepliesFord Super Duty (1999-2016) :: 2012 F350 - Change Out Instrument Cluster With Mph Cluster?
I have a 2012 F350 XLT that came out of Canada. So of course the speedometer is in KM. (Large numbers are km and smaller numbers are mph). I am trying to find out if I can simply change out my cluster with a mph cluster???
View 4 RepliesGolf IV / Jetta IV :: 2003 - Instrument Cluster / Interior LEDs Work Sometimes
I just picked up an '03 Golf and decided to put in the euro switch I had from my old Jetta. When I turn the headlights on (either parking or full) the instrument cluster blue back lighting and the red interior LEDs work only sometimes. When they work, they all work, but probably about 9 out of 10 times, they just won't come on at all, so I have to sit there turning the switch on and off repeatedly until they do come on. What could be causing this? It's definitely not a fuse since they do come on eventually, so my first thought was maybe a relay, but which one? What else could be going on?
View 5 RepliesHyundai - Excel :: 1993 - Swapped Instrument Cluster / New One Doesn't Work
My car is a 93 Hyundai Excel with the automatic transmission. The donor car was a 94 Excel with a manual transmission. This instrument cluster had the rare tach so that is why it was to go in mine. Everything I have read on the Hyundai forums said it is 100% plug and play regardless of year or transmission. The upgraded instrument cluster worked in the donor car, but in mine nothing works. Fuel gauge goes to full but that's about it (my tank is almost empty). What would cause this? I've checked the printed circuit board, fuses, everything.
View 5 RepliesPlymouth - Voyager :: 1999 - Front End Wobbling / New Tires Aligned
We have a 1999 Plymouth voyager that is wobbling bad, we have new tires all around and it's been aligned. Still can not get it to stop wobbling, what do we do now? We also replaced one wheel cylinder on one side too.
View 2 RepliesSanta Fe (CM - 2007-12) :: P0463 And P2067 - Fuel Sensor On Instrument Cluster Doesn't Work And MIL Is On
2007 Santa Fe Limited. The matter is that, fuel sensor on instrument cluster doesn't work and MIL is on. I replaced both fuel sensors and it didn't work. May be instrument cluster is bad? Or should I replace ECU? I don't know what to do.
View 3 RepliesToyota - 4Runner :: 1999 - Instrument Cluster Went Totally Dark
The instrument cluster on my 99 4runner went totally dark recently. All the individual lights still work such as open door, brake, check engine light, etc. My first thought was to replace the 3 lights that lights up the speedometer, tachometer, etc. Bought new lights from dealership and installed. Still dark. I'm not sure if it matters but I took them out and installed the opposite way. Still dark.
One more interesting thing. Still drove it while I was waiting for lights to come in at dealership, they had to order them. Well during that time my tail lights went out. Saw a video that confirmed I blew a fuse. Replaced fuse. That fixed tail lights but instrument cluster still dark. Is there a fuse that would only effect those three lights on the instrument cluster??
Plymouth - Voyager :: Stalling When RPMs Are Low
My voyager stalls when rpms are low--turns, backing up, stop signs etc.., RUNS FINE WHILE COLD!!!!!
Replaced fuel filter, iac, whats next!??? nothing shows up on computer - no error codes etc etc....
Golf IV / Jetta IV :: 1999 - Instrument Cluster Removal Affect Immobilizer?
I am going to remove my Instrument Cluster for an illumination LED changing, to convert them to the white colour. I found out that Immobiliser is located on Instrument Cluster, is there anything I have to be careful?
It's 1999 Bora. I think Immo 2 on it.
I found one Thread that someone had the problem with Immobiliser after cluster removal (it was also for LED job), a car was not starting, he suffered some time tried lots of things, but then everything went OK, even though he wasn't sure what was wrong.
So, do you think there is a high potential risk to take it out? Do you think I have to cut battery connection beforehand?
Ford Super Duty (1999-2016) :: Instrument Cluster Went Dead?
So, on my drive home from the pub tonight, my clusters went dead, then came back on, then died again. This behavior repeated for the 5 mile drive home. In addition, I believe the lights weren't working as well. The engine was still running, so I simply continued on home and parked for the night. The only thing I can think of might be the problem is the fact that I replaced the serpentine belt the day before yesterday. Is it possible that the alternator is not charging the battery properly and that is what my problem is?
View 14 RepliesFord Super Duty (1999-2016) :: No Instrument Cluster Lighting
2003 f350 5.4L auto 4x4. The lights stopped working on the dash so now I can't see the speedo at night. All the dummy lights and gauges work. I checked the 3 fuses for the cluster from the owners manual. All 3 are good. Here's the thing, fuse 35, Checked for continuity, my meter read 192 not all zero's like it should have. I pulled the fuse and rechecked it, it was good.
I replaced it anyway. rechecked with fuse in, I get 192 again. pulled fuse again, checked both sides of socket for voltage and I'm getting 12.64 volts on both sides of the socket. Even though the fuse reads good, could this be the reason my cluster isn't lighting up? Is there a fuse on the back of the cluster?
I see a lot of threads on the cluster lights being out but its usually no tail lights or power windows or other things, and if there's a solution nobody is posting it. Mine is simply no lights on dash or I should say (No Back lighting). All my lights inside and outside work.
Plymouth - Voyager :: None Of Instruments On Dashboard Are Working Right
The vehicle is a Plymouth Grand Voyager Expression, year 1999.
So we've tried to get this fixed in the past, we know a mechanic who has tried multiple times to fix this himself.
So here's the issue: All of the meters, lights, everything on the dashboard very rarely work(if they do they go back off while driving). If you hit the top of the dash hard enough, they will all sometimes come on and then go back off after an unpredictable amount of time.
Plymouth - Voyager :: Vibration In Front End At 40 To 50 Speed
Vibration in front end at 40 to 50 new tires have been balanced and checked 4 times can run up past 50 and put in neutral and no vibration as it slows down...
View 1 RepliesFord Super Duty (1999-2016) :: Instrument Cluster In Not Working / Alternator Went Out
I am really hoping that my instrument cluster in not working because my alternator went out at the same time. I really hope they are connected somehow. I really need a wiring diagram for this one. Just got the truck last week and have been taking care of the little things to get it fixed up and make it my own. my new rear step bumper came in today. I will be dropping off the the alternator for a rebuild tomorrow. So looking for a wiring diagram?
View 7 RepliesFord Super Duty (1999-2016) :: Running And Instrument Cluster Lights Out
Just the other day I fired the truck up and turned the lights on and my headlights came on but my gauges didn't light up. I figured I probably had a blown fuse or something so I didn't bother checking it immediately and decided to drive home anyways and on the way home I got a phone call saying that my running lights weren't working either. Front or rear. Still have brake lights and turn signals but no running lights. I've checked all the fuses and none of them are blown and I'm going nuts trying to figure out what is wrong before I get a ticket. I'm tired of lightly holding the brake as I pass by cops at night. What could be causing this issue?
View 11 RepliesFord Super Duty (1999-2016) :: 2005 - Instrument Cluster Malfunctioning?
05 6.0L xlt if that matters. Occasionally, I'll be driving and the speedometer will stick at a certain speed as I slow down. So yesterday it happened again on my way to work, but it was worse. I noticed that as I was driving, the needle was stuck at 0mph. Then a minute later as I was accelerating from a stop, It began working again. A few minutes later, as I was slowing down for a red light, it was stuck at 55mph. As I accelerate again, the needle moves as if 55mph is 0mph. Then it stuck at 85. And as I drive, the needle is just pegged well past 100mph, even though, I'm doing 65-70 max. I have Torque Pro, and all the info from the computer is correct, I can accurately measure my speed from there. Turning the truck off does not reset the needle or anything. It still remains stuck with the truck off, which makes me think it's something mechanical. Eventually, the needle usually lets go and begins working normally for a while.
In addition to the speedo issue, which has happened multiple times, The tachometer was working correctly, then all of a sudden was showing that the RPMs were about 800-1000 lower than normal. When idling, the needle was at zero. When at 65, the needle was around 1000-1100, when it normally reads about 1900. When I left work last night, the tach was fine, but the speedo was still stuck at 85.
It doesn't do it very often, it's just frustrating when it does. All the other gauges seem to function normally. The temp gauges still move, although, I know that means pretty much nothing. The boost gauge is good too.