Passat (B5) :: Electric Fan Not Kicking In
I just got this project running recently (replaced head after timing belt failure) and on the first night I got it running I noticed the electric fan was not kicking in (belt driven fan works fine). Investigated a bit and found the fan was some what seized. I was able to work it free quite easily so I chalked it up to corrosion from sitting.
fired it back up and let her get to operating temp and once again no fan. checked and it spins freely but never comes on. I did some checking and I (visually) cant find the plug, fan switch, or any fuses that deal with it... So I checked the bentley and it talks about a couple relays that have to do with it, but no fuses (at least that Ive found so far). Before I start tearing into wiring diagrams in the back of the bentley, I'm hoping some of y'all might have some input for me. Maybe some common faults, where to look, etc...
Car is a 2000 Passat 1.8T auto. Just had the head swapped due to TB failure which included waterpump, thermostat, fresh coolant, and all new belts.
Passat (B6) :: Rev Limiter Kicking In At 5000 Rpm
I cannot go hard on the car bc no matter what gear i am in the rev limiter kicks in at 5000 rpm. it kicks the car back so hard that I am afraid to keep trying and testing it. it seems like every time i fix something, something else goes wrong.
View 8 RepliesFord 6.0L Power Stroke Diesel :: 2006 F350 - No Power At All / Turbo Was Not Kicking In
I have a 06 f350 superduty with a 6.0 I have had injector problems before with the motor even hydro locking no start this is the problem my truck started blowing white smoke with a strong diesel smell everyone said it was oil cooler but I took it to a ford garage the guy said I had 2 injectors hung open and wasn't hydro locking and suggested to put all 8 in so I did 3400.00 not I went to pick it up had no power at all turbo was not kicking in so I took it right back to them they checked it out said turbo was sticking had to clean it it would take 6 hrs. said the fuel In the motor caused it it was working fine when I took it to them now they say maybe a new turbo are they giving me the run around or is this possible....
View 9 RepliesPassat (B5) :: Brakes Feel Like ABS Starts Kicking In When Come To A Complete Stop
Wierd new noise from my brakes - No issue when I press the pedal, and they work just fine. However just as I'm about to come to a complete stop the brakes feel like the ABS starts kicking in. I can make it not stop by lightly pumping the brakes but this can't be right. What it could be. I just had CV boot replace if that could have done something.
View 1 RepliesFord - Explorer :: 1999 XLT V6 - 4WD Randomly Kicking In And Out
1999 Explorer XLT V6 4 Door. So my 4WD was randomly kicking in and out to the point that it was intolerable. Don't have the $$$ for a repair, so the mechanic disconnected the plug from the 4wd motor. Now the car is doing all sorts of crazy electrical stuff. Is there a way to more surgically disable the 4wd without the unwanted electrical freak-outs?
View 1 RepliesPassat (B5) :: 1999 VW Not Starting After Turned It Off
My 1999 VW Passat is having some starting problems. I drove it home, and turned it off myself, and then it never started again. I replaced the starter, and it works, because i can hear it. The Engine just wont turn over.
So i looked inside the car, and when i turn the key to the battery spot, PRNDetc. doesn't show up on the dash. I also noticed that i can push it backwards in drive.
I have had the transmission replaced recently, and i took it to a couple places and they tried to tell me that my engine was seized. I tend not to think so, because it there was something wrong with the transmission, the engine wouldn't turn over since it is connected to the transmission.
It is a tiptronic transmission. By any chance do you think it could be the transmission circuit board under the shifter? or a fuse, or some kind of linkage in the transmission that is messed up? Possibly the flywheel?
Ford F-150 - 1997-2003 :: 1999 - No A/C - Compressor Is Not Kicking On
4.6L engine.......Well my A/C isn't working I just found out. The compressor is not kicking on. I checked the charge with my gauges and it is good so I don't think the low limit switch tripped, but I don't have a manual or anything and was wondering which number relay and fuse goes to the A/C compressor.
I also need to know which fuse goes to the power mirrors as well. I downloaded a manual from the ford fleet site, but honestly I haven't gotten around to looking at it. Not home.
Ford 7.3L Power Stroke (1999-2003) :: Replaced Everything - No Power When Key Turned?
I am currently cab swapping my 2001 F250 with a 2005 350, I have everything installed but when I turn the key theres nothing... Dead in the water pretty much. I have power running to inside fuse panel but when I turn key there is nothing? no dash lights or anything, what I am missing or where I should be looking?
View 9 RepliesFord 7.3L Power Stroke (1999-2003) :: Power Lost And Engine Turned Off While Pulling Onto Highway
While pulling onto the highway and pulling pretty hard lost engine power all boost then engine truned off. Top of engine is covered in oil..... What happened?
View 11 RepliesPassat (B5) :: 1999 V6 Cooling Fan Was Running Long After Car Turned Off
Went outside to start my '99 V6 and nothing! No interior lights, no door chime, no annoying ding ding with the key in the ignition. The car ran great yesterday but I noticed it sounded like the cooling fan was running long after the car was turned off in my garage.
I tried using a car starter/charger and charged it up for 3 hours - was reading a positive charge on the gauge- but it won't start. When I get ready to crank the car with the charger attached to it, the fan noise kicks in again but it isn't coming from the radiator fan- it sounds like it is coming from under the air intake for the air filter.
When I attempt to start the car,I can best describe the sound as a machine gun like cranking noise that lasts as long as I turn the key. I am hoping it isn't the starter. The battery is less than 2 years old with about 10k miles on it.
Ford 7.3L Power Stroke (1999-2003) :: Power Loss And Truck Started Hiccuping When Wipers Turned On
A few weeks ago I replaced my CPS on the 99 7.3. Today was the first day I drove my truck in the rain. When I turned my wipers on, I noticed that I lost power and my truck started hiccuping. I read on these forums that an aftermarket CPS is most likely the problem, so I am planning on getting a ford CPS this afternoon. My biggest concern is that before I replaced my CPS, my wipers only had 2 speeds. Also, if I pressed the end of the blinker switch to squirt the cleaner the wipers would not turn off until I turned the truck off. I am not sure why this would be happening and I wanted to ask if there is more than just the CPS involved with this.
View 7 RepliesFord Super Duty (1999-2016) :: 2004 - Overdrive Not Kicking In
How many gear shifts I should have on my 6.0 2004 super duty, Ive counted 5 but it seems not to be in overdrive, I'm running a little over 2000 rpms at 65 mph?
View 8 RepliesFord Super Duty (1999-2016) :: 2000 - A/C Clutch Kicking On And Off?
I have a 2000 F-550 w/7.3. I am having a bit of a problem with the hvac system. When I turn the selector switch to floor heat only or put it on vent or both the a/c clutch kicks on and off. Not when I put it on defrost but as I said only when it is in the other positions. I do know that the clutch will kick in and out when on the defrost position. That is fine. But why would it kick in and out when in the heat only position?
View 2 RepliesFord Super Duty (1999-2016) :: Bucking And Kicking In Deep Snow?
This is the first winter for my truck, and the first time I've driven a truck in the winter. I struggled to get out of my street this morning, through 15" of unplowed heavy snow. As the traction control seems to engage, and even sometimes when it doesn't, the truck literally shakes very violently. I even had to lock the rear diff to get out this morning, but that didn't seem to make the shaking any worse. What causes the shaking? Is it just my truck? I've driven Land Rovers with full-time 4x4 for years, never any shaking even when they are spinning like crazy and traction control is operating. One thing I did learn that seemed to be a question of several on this forum...traction control does operate on the front wheels when 4x4 is engaged, in addition to the rears.
View 14 RepliesFord 6.0L Power Stroke Diesel :: Clogged Oil Cooler - Fan Kicking On Under Normal Driving Without A Load
I know I have a clogged oil cooler and normally I'm not home much during the summer months to know how it does during the summer. The outside temperature is around 95*, but the thermostat on the Ex is reading from 102 to 112, and it actually read 122 yesterday. Also, with the hot weather, I'm not noticing the fan kicking on under normal driving without a load. The AC is working, but it's not the ice cold AC I'm use to and does get better while cruising down the highway.
View 2 RepliesFord Super Duty (1999-2016) :: Slight Hissing Noise When Compressor Was Kicking In And Out
Bought a 2014 SD 4x4 in December of 2013 and this is the second time the big girl has been to the shop with A/C problems. First time it was the evaporator about three or four months ago. During the last few weeks of the summer I began to smell something strange (like band-aids) when the A/C was on and it lingered until the next re-entry. ALso, began to hear a slight hissing noise when the compressor was kicking in and out. They replaced the evaporator, smell remained as they said it was the refrigerant I was smelling. About two or three weeks ago the smell got slightly "larger", and last weekend she would not cool. This is the fourth time shes been to the shop with other problems such as the My Touch system..............
View 7 RepliesFord 7.3L Power Stroke (1999-2003) :: Won't Crank When Key Turned On?
I have a 1999 7.3 super duty that won't crank when the key is turned. All lights work, power windows and mirrors work but after the WTS light goes out... Nothing...now I do have a slight leak in the roof and a little water does get in the cab. I opened my door the other day and it smelled like an electrical fire had occurred. I checked under the hood and the same smell, if not a little stronger. I pulled my fuse box and GEM tonight. Once I got away from the truck, I expected them to smell like the electrical fire smell, but they didn't. Now I did try cranking the engine over by jumping the starter relay before tearing the fuse panel out, and I got it to crank, but not strong at all. The batteries are good.
View 11 RepliesFord 7.3L Power Stroke (1999-2003) :: Almost Died When Headlights Turned On?
I have a 2003 F350 SD FWD Dually With 4.10 Axle Ratio. I'm looking for some front rotors and pads and I'm looking for recommendations. I tow a 44' Goose neck racing trailer on a regular basis so I dont want autozone crap rotors that are going to warp in a few thousand miles. I was on rockauto.com, they have Wagner, Bendix, Motocraft, Powerstop, etc etc. I thought maybe those Powerstop drilled and slotted looked interesting, but I dont know much about them.
View 14 RepliesFord Super Duty (1999-2016) :: 2000 F350 Takes Forever To Start When Cold / Water In Fuel Light Keeps Kicking In
So the first issue is, if the vehicle is cold (regardless of temp outside) it takes forever to start it. It cranks and cranks and cranks and after a couple seconds of cranking I stop, wait a second, then try again. Usually it takes two sometimes three tries to start it. The guy who I bought it off of said it has newer glow plugs (last year I believe) and also I have replaced the batteries. Once its warmed up it does not do this at all.
Secondly and also something that just recently started happening, my water in fuel light keeps kicking in. I drained the water out of the water catcher reservoir under the truck multiple times and the first time water actually came out but every time after that simply diesel fuel comes out. I added a bottle of water remover to the fuel as well and ran it down to a quarter tank. Then filled the truck up completely, added two more bottles of water remover. The light still comes on. I noticed it only comes on when I am going up or down a fill. When I am driving on flat ground it does not kick on.