Ford 7.3L Power Stroke (1999-2003) :: Replaced Power Steering Pump / Gear Box Still PS Bleeds?
I just replaced my power steering pump and gear box and I flushed the system until the fluid came out good. I have done the whole lock to lock and pump the brakes but nothing is getting better.
View 3 RepliesGrand AM :: 2002 Pontiac Died - Lost Gas And Power Steering
I have had various issues with my car over the years but on my way home last night my car just died coming down the interstate. It didn't make any noise, it simply kicked off the cruise, the battery light and oil light came on, and I lost gas and power steering. The security light did not come on and my car's forgotten who I am often enough I know how to do the key relearn by heart. My service engine soon light stays on because I no longer have a catalytic converter. When I turn the key over I smell gas (which I can only assume means there's not an issue with my fuel system), everything turns (alternator, belts, etc.) but it doesn't fire.
I had someone suggest that it could possibly be the EGR valve, but when I went to investigate, turns out there isn't one installed on my engine, where it should be there is a metal plate bolted to the "hole". In the past my ignition control module had to be replaced about every 11 months, so I had two and carried the spare in my car. This stopped happening when we finally replaced the entire coil pack. My car has always idled rough (I'm assuming I can attribute this to the lack of EGR valve).
Over the past two weeks it just seemed to get a little worse, it was making noises when accelerating when the car was cold, almost like a whining and the engine was idling hard. When looking for the non-existent EGR valve I did discover my air filter was ridiculously dirty and the air intake is full of oil. The oil was low but not enough to make the engine seize. I know that's a lot of information but was trying to be as clear as possible about previous issues and what I have ruled out. I did read that it could possibly be the CPR, but didn't know and I need it running again.
Mitsubishi - Endeavor :: Sputtered Out And Won't Start After Timing Belt And Water Pump Replaced
A mechanic has my car and replaced my timing belt and water pump....he said he had it running and then it sputtered out and wont start..i have never had a problem with this car. Just replacing before it went out.. he is missing something.
View 19 RepliesFord F-150 - 1997-2003 :: Replaced Water Pump - Overheating Occasionally - CEL On
We had my son's water pump replaced in his 97 F150. It is now occasionally jumping to completely hot. If you turn it off and back on it returns to normal. The power to the engine is cut when it shows to be overheating. The check engine light has now come on.
View 9 RepliesPontiac :: 2003 Grand Prix Intermittently Won't Start And Sometimes Dies While Driving
We have a 2003 Grand Prix. For the last few years it has this intermittent problem. Sometimes it just won't start and occasionally it will die while stopped at an intersection. I did some digging online and found out what the likely culprit is, but do not know how to fix it. I already spent a lot of money for a mechanic to claim he fixed it, but didn't.
According to online sources [URL] .... the security system TDM is at fault. It stops recognizing the VATS transponder in the key and thinks the car is being stolen. So, it cuts the connection to the engine. Clearly a dangerous situation if you are driving. My 17 yo daughter recently got stuck in a very busy intersection.
The temporary fix is to turn the key to the on position without turning the engine, wait 10 minutes then try starting the car. This is supposed to reset the security system. Now this is starting to not work. Someone suggested bypassing or modulating the TDM signal by adding in a resistor. I really don't feel equipped to do this though. Another solution is to buy a bypass module.
Caravan/Voyager :: Power Steering Pump Not In Line 2000 Grand 3.3?
I had a VERY bad leak, to the point where I would fill it, an hour later it all leaked out. I had a mechanic work on it, and he rebuilt the PS pump, BUT the pulley was cracked, they DON'T make that size anymore. He put a bigger one on, only to find out, it was rubbing on my brake lines so I couldn't drive it! SO I had another grease monkey work on it, went through a few new pulley's FINALLY found one! BUT went through 4 Serpentine belts!!
After 3 months with NO VEHICLE, we finally got it all back together. BUT now it is not all lining up we couldn't tell until we had the belt on. it is about a 1/4 of an inch to much to the right.
I'm thinking maybe washers or spacers would work?
Ford 7.3L Power Stroke (1999-2003) :: 2001 F250 - No Start After Changing Water Pump
I have a 2001 F250 Super Duty V8 7.3 L. I removed the water-pump then waited five days for the oring for the new pump. I installed it and now the truck will not start. I have drained the fuel water separator and replaced the filter. On the passengers side through the kick panel I found that button popped out so I pushed it back in and still it will not run. It acts like its not getting fuel but if my fuel water separator is filing up I'm assuming mu fuel pump is working??
View 7 RepliesGrand AM :: 1993 Pontiac - Fuel Pump Fuse Keeps Blowing
Ok so I just bought this car, 1993 pontiac grand am se, from a neighbor. When I test drove it, the back seat was all unscrewed so I thought no biggie and it drove really nice for being a 1993. Ended up buying the car. I get the car home, husband puts seats back together and we go to leave for town and the fuel pump fuse blew. Put a new one in, go to start the car, fuse blows again! Tow the car home. Husband checks the wires to make sure there is no faulty wires. Has to reground the ground wire. Car then starts. Go to drive down my driveway and the dang fuse blew again! Mind you there is a new fuel pump in the car so we know this isn't what is wrong with it.
View 4 RepliesBmw - 325 :: 2004 - Replaced Power Steering Pump Thrice?
Bought my daughter a 325Ci about three years ago and have replaced the power steering pump 3 times so far. That's four pumps including original which went out two years ago with about 60k miles. Car has 95k miles now and changing pumps faster than tires. Dealership said original had known defect and would be replaced with newer improved model. I fail to see the improvement...
View 8 RepliesC/K :: 99 K1500 5.7L Won't Run After Replaced Timing Chain And Water Pump
I just replaced the timing chain and water pump on my 1999 K1500 5.7L. After spending several evenings and a few early mornings working on it, I get everything back together and go to start it up. It starts then immediately dies. After double checking that the CKP sensor, two plugs on breather, and a/c and alternator wires (these are all that I unplugged) are connected I try in one more time before coming in to work today.
Timing chain was installed with No. 1 at TDC and mark on cam at 12 o'clock position as stated in the Haynes manual for the truck. I did not remove or even touch the distributor since replacing the intake gaskets ~3 years ago. Will check to see if any codes are showing in the morning when I have my laptop at home.
C/K :: Fluctuating Temperatures On The Gauge - Replaced Water Pump
My brother has a '92 K1500 5.7L in which he had a leaking water pump. He replaced it with an Autozone unit. After replacing the pump, he now states he is experiencing fluctuating temperatures on the gauge. He has little heat at the heater, even after letting the truck idle and after driving it. This was not a problem prior to replacing the water pump. He has put approximately 200 miles on since the replacement and it has been about 2 weeks since he replaced it. He believes he has all the air out of the system, as he has checked the overflow container and radiator several times and the coolant level has not gone down.
This now "suddenly" appears after the pump replacement, we are thinking it is not the temperature gauge sensor or bad thermostat. We are thinking possibly still air in the system or water pump cavitation.
Camry :: Replaced Pink Coolant With Red And Water Pump Went
Four cylinder, 2004 Camry (2AZ-Fe), Auto with 98,000 miles.
I had to replace my water pump after driving with newly replaced Toyota Red antifreeze from the 8 year old Pink. I drove only two weeks and 1000 miles on it.
I believe that was just a coincidence. Some Camry's water pumps do not last even that long. Even if the coolant was not compatible with Toyota specification, it still could not destroy the pump seals in two weeks.
Golf IV / Jetta IV :: 2001 GLS VR6 Engine Lag After Water Pump Replaced
My girlfriend has a jetta and I work at a DODGE dealership in service. I recently replaced the water pump and flushed the coolant twice and replaced the coolant with G13 coolant from the local VW dealership. After I finished burping the coolant system of air bubble. After I finished I took it for a spin and being the speed demon I am, I don't hold back on the throttle. I noticed immediately the engine lagging and being extremely sluggish. I ran my shops snap on code scanner on it and I came up with cylinder 1 fuel injector open circuit. Cylinder 6 fuel injector limited power. And last but not least o2 sensor 1 open circuit. If your facing the motor I undid the left motor mount from the frame, lifted the car on a hoist and took the bottom side motor mount off of the motor. I took the cv shaft off of the transmission and lowered the car and jacked the motor up by the oil pan to expose the water pump for removal and replacement. I'm wondering if possibly the o2 sensor could cause the ECU to seize power to two of the cylinders to ensure no engine damage or if its 3 separate problems.
View 3 RepliesPrius (2004-09) :: Water Pump And Belt Replaced / Now Car Is Running Hot
Toyota dealer said computer indicated the water pump and belt needed replacing. We decided to do the replacement ourself. Now the light comes on which indicates car is running hot. We did replace the coolant. The 2005 Toyota Prius never ran hot before the replacement, What did we do wrong?
View 3 RepliesCamry :: 2008 SE Heating - Replaced The Water Pump And The Temp Sensor
I have a 2008 Camry SE with about 118K miles
I have replaced the Water pump and the temp sensor recently.
The problem is when you turn the thermostat control to hot on the HVAC dial only warm air blows and it is only warm when the engine is revved or going down the road.
My question is: Is the door on these electronically controlled or vacuum controlled? it is like the blend door gets stuck and is not closing fully or something.
Tiguan :: Replaced Water Pump To Resolve High Pitch Noise
Bought new 2012 Tiguan SE 4Motion three weeks ago, today replaced water pump regarding high pitch noise issue. btw, how to make sure if the wastegate rattle issue has been fixed or not.
View 12 RepliesPrius (2004-09) :: Code P1121 After Main Water Pump Replaced
On my 05 Prius (65K miles) I recently had my local Toyota dealer replace both the inverter water pump (for free per recall) and main engine water pump (~$500 based on their recommendation because of some coolant leakage). 1 week later, I got the P1121 code coming off and on intermittently.
My dealer says that the work they did is not related to P1121.
Accent MC (2006-11) :: Can Water Pump Be Replaced Without Removing Timing Belt?
I have a 2007 Accent with 119K on it.
I wanted to replace the water pump and I was wondering if this can be replaced without removing the timing belt or the lower timing belt cover?
Mustang :: Replaced Water Pump / Thermostat / Underdrive Pulley But Still Overheats?
My son has a Mustang GT 5.0 that is overheating. I replaced the radiator with a heavy duty 3 core radiator. It had underdrive pulleys so I replaced them with stock pulleys. I put dual electric fans on it. I flushed the block and put a new thermostat and replaced all the hoses (made sure the bottom radiator hose had wire in it so it wouldn't collapse). I put a new water pump and drive belt but it still overheats when sitting in traffic and overheats when driving with the A/C on.
View 14 Replies