Prius (2004-09) :: Metallic Rattle Sound During Acceleration
I'm back with another question! My 2006 Prius now has 60,XXX miles and the other day while driving with the windows down, I was climbing a hill to my house and when the engine is at a certain RPM, there is a metallic sound that comes from under the car, but more in the front. You can't even hear it when the windows are up barley, but more when they are down, you can hear it, especially when you're beside a wall or guard rail and the sound can reverberate back.
View 2 RepliesAccent LC (2000-05) :: 2003 - Rattle Sound On Acceleration / Load
My '03 gives a rattle sound under load/acceleration conditions. This does not happen during the warm up period, so it appears that the engine runs lean under acceleration. There is no check engine light on for this. Approx 172k KM, (100k miles). The noise appears worse when it is hot/humid outside. I have run a can of Seafoam through it (half in the crankcase, half in the fuel line), and that doesn't seem to have worked. Therefore, I don't think that it is the injectors. Possibly fuel filter (still original)? Any easy way to test?
View 8 RepliesTiguan :: Metallic Rattle Between 2.4 To 3k RMPs Under Load
Getting a metallic rattling sound between 2.4 and 3k rpms under load? It can't be reproduced by just revving however, I can reproduce this easily while holding it in gear with the triptronic and accelerating in that rpm range. I want to say it sounds like a exhaust or heatshield rattle but it's coming from the front the car, like behind the firewall or directly below me. I took it to the dealer and of course, in a typical dealer fashion, they cannot hear it.
View 5 RepliesPrius V :: Engine Ping (rattling Metallic Sound) Under Load
When accelerating up a steep grade the engine will ping (rattling metallic sound) when reaching a certain RPM, but stop pinging as I continue to push the accelerator down and increase the RPM. Should I be concerned? Could it be something else, loose exhaust heat shield or something? Or is this normal behavior for a gasoline engine? My old Honda Fit never had engine ping/knock that i can recall in its 200,000km of service running the same 87 octane gas.
View 15 RepliesTouareg :: Loud Metallic Rattling Sound Under Moderate To Heavy Engine Load When Cold
Problem description: A loud metallic rattling sound from under the car under moderate to heavy engine load, only when engine/exhaust is/are cold. It is noticeable from within the cabin with the windows rolled up and the sunroof closed. Crack a window or the sunroof and it's pretty loud. The first time I heard I, I thought "this is not good".
This is not an octane ping or valve train noise. It sounds like a coffee can with marbles being shaken in concert which what might be the rapping of a V8 engine's exhaust. I had a Sunbeam Tiger that rapped in the upper rpm ranges and this reminded me of that but instead of rapping, it shakes a can with marbles.
There has been much discussion and speculation as to what causes this. It does seem to occur only with late - 04 and up V8 Touaregs with the "sport" exhaust that replaced the "std"(?) exhaust used on the majority of the 04s.
Observation: I looked very closely at the heat shields, looking for ways they could rattle. On the passenger side (LHD), the heat shield has three main sections:
- Front: around/near the secondary cat (tightly secured)
- Rear: around/near the rear differential (tightly secured)
- Middle: between the two mentioned above (loosely secured)
The three sections overlap a little where they meet. It was very easy to tap on the middle shield and make a loud metallic sound. I put my finger between the two shields (where they meet) to isolate the two metal pieces and tapped again, and the noise was gone.
Theory: The harmonic resonance of the exhaust under load vibrates the middle heat shield and it rattles against the front and/or rear shields. As the shields heat up, they flex enough to provide clearance between each other and the noise goes away. This may be unique to the "sport" exhaust if (and I am only speculating) the heat shields were changed (in design or fitment) when they changed the exhaust.
Experiment: I tried a very simple experiment. I slightly bent the edges of the middle shield (~1/2 inch) where it was coming in contact with the front and rear shields. The allowed me to tap rather hard on any of the shields without them rattling against each other.
Result: I make the tweaks to the shields Sunday night. When I drove to work this morning, I put the transmission in sport mode and ran WOT until it shifted. Normally, I would have heard the sound (very loudly) but it was gone. No metallic sound. Not completely convinced, I repeated the experiment on the way home and, again, the sound was gone.
Summary: It was cool out when I was going to, and from, work (64F) and this would normally be the perfect set up for making the sound. I think that tweaking the heat shield has solved the noise on my Touareg. I am tempted to go back under there and pop-rivet a little brace between the shields so that they cannot rattle against each other again. On the other hand, I may just leave it be and do the pop-rivets if the noise comes back.
Anyway, I was excited to find a potential solution for my Touareg and wanted to share it will you all. I will post back after a while and report how it goes in the long term. Lastly, I really liked being able to put the air suspension in xtra-offroad and get under the car (easily) without using a jack....
Sonata I45 (YF - 2011+) :: Metallic Rattle Sound At 2k RPMs
So on my new 2.0T Sonata I noticed a brief metallic rattle in the 2K-3K RPM range when you rev the throttle. I was very concerned.
The sales rep said it may be the heat shielding that is coming lose. He was concerned and said to bring it back when Service is open.
I just got back from the dealer: The service manager didn't know what it was but his tech said it was part of the turbo system, it's a 1/4 inch bar (parallel with the bumper) you can plainly see between the firewall and engine. He said what it did but I forgot to take notes.
I listened to another 2.0 Turbo Sonata on the lot and it has the exact same rattle when rev'd.
Sonata I45 (LF 2015+) :: Grinding / Metallic Sound Under Acceleration?
I have been having a grinding/metallic sound when going up hills in 4th/5th gear. It sounds like if you threw metal into moving parts. I believe it's coming from my engine or transmission. When i was at the dealer last month for a campaign and ecm upgrade i mentioned this problem and they replaced the vcm motor assy, however the problem still exists. What could be causing this problem?
View 3 RepliesPrius (2010-12) :: 2013 - Metallic Rattle Sound Coming From Back Of Interior
On the December day my 2013 Prius Five model (hatchback with all the safety add ons, bigger wheels) turned 18 months old, i was on the way to have one of the freebie services. I heard a metallic rattle, seemingly coming from the back of the interior. It continues and I cannot find a source for it. I just read a thread about rattles in the 2011s. Not particularly comforting given what I spent on the car.
Is this something I could have the dealer chase under the warranty? (this is the first new car i ever bought in my 50 years of driving, so my familiarity with new car warranties is a little thin.)
My dealer has been pretty responsive -- swapping out an interior door panel as a freebie when the armrest portion separated from the lower portion and collapsed into the door.
Ford 6.7L Power Stroke Diesel :: Squeak / Rattle Type Sound Coming From Front Driver Side Wheel
I'm having a squeak/rattle type sound coming from my front drivers side wheel (more rattle). It only happens when I go over a quick bump and happens going straight and while turning. 2012 f250. 87k miles. 4x4. I have a two inch block level (southern truck) up front..
View 14 RepliesPrius (Gen 2) :: 2006 - Faint Rattle Sound When Engine Under Load?
Today I drove my 2006 G2 Prius with 59,000 miles to the park and had the windows down. I climbed a hill for a good while that had the engine under load and there was a concrete wall beside me, and I could hear a very very faint metallic-like rattle. I mentioned it to my partner who listened and said he couldn't even hear it, so maybe it is just me.
View 2 RepliesGolf/GTI VII :: Metallic Rattle From Passenger Hood Area
Ever since day one with my new MKVII GTI, there has been a consistent metallic (tinny - like the sound of someone shaking a soda can with the tab inside) coming from what seems like the passenger side footwells. This rattle can only be heard at low RPM. I can hear it most around 2,000 RPM, and I can force it to happen by applying light pressure to the gas peddle. I don't know if the rattle doesn't happen at higher RPM, or if I just can't hear it over the engine and the typical road noise. The rattle is pretty consistent in tempo.
I've done some research, but can't determine if it's the waste gate actuator, fuel lines, or something else. I'm new to maintaining cars properly and I'm not the most mechanically savvy person, but I want to learn. So, I haven't tried to locate the actuator because I don't know where to start and I haven't tried to "tie down" the fuel lines because I'm not comfortable doing this fix on my own.
I've taken the car to the dealership once, and I was told that the waste gate actuator doesn't even exist on the MKVII. Interestingly, two different techs told me this. They deny that the actuator is even real, much less causing any problems. I suppose it could also be the armrest, as some people say it tends to sound like it's coming from the passenger side.
Golf VI R :: Buffeting Type Sound At 40 - 50 Mph?
Between 40-50mph, I have a buffeting type sound. (not sunroof related) ... There's no vibration, and it seems more apparent as I'm slowing or driving at a constant speed than it is while accelerating. I'd think it was tire related?
View 5 RepliesGolf IV / Jetta IV :: Vibration On Acceleration Or Under Load After 20 Miles Driven
Info: O2J 1.8t, Peloquin LSD, clutchnet 6 puck, VF mounts
Getting a vibration on driver's side during either accel or load up a hill after driving for 20 miles. It's related to distance driven versus engine warm or cold. I can feel it in the pedals, definitely driver's side.
Things checked:
-axles, replaced driver's side, no change
-transmission is full of fluid, looks good
-motor mount bolts tight
-called Peloquins, they said the diff would cause issues while turning and would occur anytime under load, not just when cold
Wheel bearings have about 15k on them and were INA's, and those shouldn't vibrate only on accel or load. I thought about the dogbone, the poly bushings in it are about 35k miles, but makes no sense why it would appear after driving 20 miles.
Golf IV R32 :: Metallic Clicking Sound When Turn Hard Right Or Left
When I turn hard right & left, near the left wheel well there's a little metallic clicking sound. Either way I still don't what it is. Upon inspection when I removed the wheel the I noticed that the red portion with the large arrow is able to move clockwise and counter clockwise. Just curious as to whether or not this should be capable of happening.
Wheel baring, control arm and bushings have been mentioned from Le Shwab's workers... I dunno though I need Vortex's opinion
When collar 3 is turned all the way down it can't rotate, but I'm almost positive that collar 2 and 3 are suppose to remain in contact with one another to prevent movement of collar 1. Just making sure that my theories are correct.
Golf/GTI VI :: Loud Metallic Scraping Sound From Rear Brakes
I had a super loud metallic scraping and clanking noise when I was backing out of my driveway the other night. It was so loud I though my exhaust was dragging or something.
It turned out to be a rock trapped between the heat shield and rear brake disk. I pressed the heat shield away from the disk a bit and the rock fell out. It's kind of crazy that such a little rock caused such a loud sound.
Golf/GTI VII :: Loud And Consistent Metallic Whining Sound When Engine Warmed Up
So I started getting this metallic/harmonic whining sound from my GTI's engine a few weeks ago. It was barely noticeable then, but has now gotten louder and more consistent. The sound occurs once the engine has warmed up and can be reproduced by holding the revs constant anywhere above 2k. The sound does not change in pitch with engine speed. It doesn't matter if the car is parked or moving.
I've attached a video... The sound can heard starting at 00:23 and becomes constant after a few seconds. Its hard to hear at first, but if you listen carefully its definitely there.
I have an appointment with the dealer tomorrow and will update with their findings. In the meantime, any clue as to what this could be? I can't really pinpoint where its coming from, seems loudest near where the oil filter is? By the way I'm 100% stock.
Golf/GTI VII :: Irritating Rattle At About 2000 Rpm Under Acceleration
So I'm experiencing a very irritating rattle at about 2000rpm under acceleration. I've only noticed it in sport mode. Seems to be coming from the front of the center console.
View 10 RepliesGolf VI R :: Single Bang Sound Only Happens Under High Load
I recently installed a 42 DD DP in my 2012 CW Golf R. I have noticed that under high load (mostly down shifts) that something is knocking under the car. It is a single bang sound and only happens under high load. I did the DP install myself and I have since done a quick check to see if the exhaust is loose. It is not. I have checked the Drive shaft and all the bolts are tight. I suspect it is the exhaust hitting something but I don't know what.
View 5 RepliesGolf VI R :: Buzzing Sound Under Light Load In First Gear
Installed the wastegate actuator rod rattle clip on their R? I've been getting a buzzing sound under light load in first gear- very audible when it echos off a wall, etc.
[URL] ....