Golf IV R32 :: Noise Is Coming From Clutch Flywheel Area
I did replace one of this days the rear main seal in my r32, and reinstall the clutch like i normally do, and right after i start the car I notice this horrible noise, scare the hell of me cuz i thought i did not had oil in the car for a moment, but i did never drain it, so I ran to get my stetoscope and the noise is coming from the clutch flywheel area, so i did remove everything apart and reinstall it, resurface the flywheel got another clutch and pressure plate, and nothing the noise is still there, do this noise sound familiar to u?
Timing chains? engine is new, and when I mean new I mean only 175 miles, got it from the dealer.. Main bearings? Clutch? only 100 miles got it new about 3 months ago. I already check all the pulleys and none make any kind of noise, [URL] ....
Golf V R32 :: Metallic Scraping / Rattling Noise Coming From Underneath The Car
My R32 has got about 9,400mi on it, and for the past 3k miles or so, i've been dealing with this metallic scraping/rattling noise coming from underneath the car. When I took it to the dealer, they said it was the exhaust flex pipe, so they replaced it under warranty. Next day after picking the car up, same noise. So i took it in again this morning and they are saying its the flex pipe again, and they don't know if it is fixable.
They are talking to VW tech assistance, and trying to figure something out. I really love this car, but if VW says there is no fix for it, I'm weary about possible future issues without fixes too. Apparently it has something to do with the length of the flex pipes and the material its made out of. He was saying one possible solution is stiffer engine mounts. We'll see where this goes.
Golf V R32 :: Knocking Noise Coming From The Lower Rear Area Of Car
Just had my 40k service done, and also got an alignment done at the same time. On my way back from the dealer I noticed a knocking noise coming from the lower rear area of the car which is more noticeable when going over bumps. Its intermittent. Thinking something got messed up when they were doing the alignment? What this might be?
View 2 RepliesGolf IV / Jetta IV :: 2003 - Buzzing Noise Coming From Driver Side Lower Firewall Area?
A months or so ago, after turning off my car I noticed a loud buzzing noise coming from the drivers-side lower firewall area. I cranked the car up and the buzzing stopped immediately. The problem began as intermittent but now within 2 minutes of turning my car the buzzing noise always starts, and runs my battery dead! I have taken my car to 2 local shops that have good reputations and they both began guessing and throwing parts at the problem to no avail my last resort is a dealership but it is 100 miles away and I'm not sure if they would do any better. I feel like this is something simple that an expert should have no problem diagnosing.
I have been searching around the internet and never seem to find someone with the exact same problem - until today!
[URL]
Prius (Gen 3) :: Metallic Rattle Noise Coming Under The Passenger Seat
Lately I've started having an intermittent metallic noise that has been bugging me. At first it occurred on long runs and sounded like it could have been the brakes or something similar. It is not too loud but is continuous, rather like gently rattling your set of keys.
It got steadily worse and I eventually tracked it down to the passenger seat. When I held the seat the metallic rattle stopped.
Prius (2010-12) :: Metallic Rattling Noise Coming From Transmission When Switched To N
Noticed a weird metallic rattling noise coming from the transmission when switched to N with the engine running and the car is stationary? Almost like the gears are rattling inside while in N position. I took it to the dealer and their Prius guru said this is normal characteristic of eCVT....
View 4 RepliesGolf VI R :: Loud Metallic Rat-tat-tat Coming From Somewhere Around Passenger Side Front Area
So was driving home from work today and was fairly close to home waiting at a light. Light turns green and I start to move forward (going up a moderate hill). I shift into 2nd and all of the sudden I hear a loud, metallic "rat-tat-tat" coming from somewhere around the passenger side front area of the car. Almost like a snare drum but more metallic sounding. Then this is followed by what sounds like a second or two of metal-on-metal type grinding noise. Don't feel much of anything, maybe a slight shudder. Then it seemed fine.
I was only about two blocks from home and it was driving okay so I continued on home. No warning indicators of any kind on the dash. When I got home I looked in the engine compartment and under the car for any signs of something obvious being broken. Nothing. I haven't driven the car since but I'm worried about what might transpire in the morning. It's even possible that it was one of the cars next to me and I was hearing the sound from their coming nightmare echoing off of the buildings to my right. But, it seemed like it was coming from my car, and that metallic popping sound has me very nervous. But as I said I drove it a few blocks after this and it seemed fine.
Sonata I45 (LF 2015+) :: Metallic Click Noise Coming From Rear Cargo Area
Experiencing a metallic click or something alike when coming to a full stop?
I've notice this new noise and it seems to happen about 0.5 seconds after the car has come to a complete stop, not during the stopping. It only happens when stopping at a red light, and it doesn't do it on stop and go traffic.
It also doesn't seem to coincide precisely with applying the brakes because is AFTER the car has stopped, again, in less than a second. I hope that makes any sense.
It happens maybe 25% of the time but, then again, if I go to the dealership I'll probably won't be able to reproduce it.
Golf IV R32 :: In Cabin Noise When Accelerating / Deep Metallic Grind Noise But Car Drives Fine?
I've been working on my car for a few weeks now and I've been doing my best to figure out. The source of this sort of 'metallic grinding' that I'm hearing within the cabin. I cant seem to pinpoint where it's coming from within the engine bay with the hood open (maybe due to the magnaflow exhaust diffusing the sound from the outside of my car). I can easily hear noise when I'm inside however with indications its coming from the lower central area of the engine bay. I drive an '04 Volkwagen GTI 1.8T
In the days I've been working on it I've replaced the:
1. Timing Belt (and tensioner pulley/tensioner dampener)
2. Water Pump
3. Serpentine Belt
4. Thermostat (and housing)
5. Clutch disk and flywheel (from a SMF to a LUK DMF clutch)
6. CV Axles (both drivers and passengers)
7. Clutch Cylinder Slave
8. Wheel Bearings (front left and right)
9. Rotors (Front Left and Right)
Diagnosis**
The car starts without any problems just as it use to prior to the replacements done. BUT it's once I get the car moving where I begin accelerating I start to hear a dull grinding noise/rumble that becomes more and more apparent the faster I go. It seems the sound is directly correspondent to wheel movement upon accelerating. Nevertheless I could be wrong.
I had a friend tag along to diagnose the sound and to him it sounded similar to the "tunneling of air not being properly sealed" but to me it sounds like a metallic grind. My friend also mentioned that he felt it was louder towards the passenger side in contrast to the drivers. As mentioned before the sound is reproduced anytime wheel movement occurs. I've checked torque spec for every replacement job done to the car so there are no loose bolts/nuts/brackets. (but there are exceptions, which I will get to).
Knowing that I've replaced both of the wheel bearings (and hub assembly) I can only assume the sources isn't from there. But I do admit a few mistakes while I had the car on jacks.
1. During the timing belt replacement I thought I would need to remove the exhaust (because I felt it would interfere with the lowering of the engine) so I, (without success), tried to remove the connection between the "bend of the exhaust" to the manifold which were 4 'turbo studs'. I had the worst time with the removal of studs but I was able to impact one them off, and as I tried another the strength of the impact broke one them half way through (meaning that I was able to unthread it a few threads but it snapped in the process, so I would need to somehow drill it out in order to replace it). This is where I gave up and did my best to install the one I had removed. Which I could only get threaded half of the way in.
-All in all I have 1 broken stud that still making a connection, and 1 protruding stud out of the 4 that connects the exhaust to the manifold.
Question: Can this be the cause of the sound? Without the full connection of 4 studs bolting exhaust to the manifold? Can this be the sound That my friend was referring to as the "tunneling air not being properly sealed"?
2. The second "mistake" isn't necessarily a mistake but a fault I found later that has to do with the Passenger CV Axle. I read a few forums here and read that it could be a problem with the axles, so I put the front end on jacks once again and found that there was a bit of movement of play on the axle shaft itself. In detail, the 2 connection points for the axle both at the Output differential flange and Hub assembly are secure and torqued to spec without any loose bolts.
BUT the rod itself seems to shift about a 1/2" between these two connecting points.
Question: Could THIS be the problem? With this type of 1/2" shift in the rod is it possible it can recreate the dull metallic grinding I'm hearing so much?
Ford - F150 :: Intermittent Metallic / Rattle Noise Coming From Front Passenger Side
2008 F150 4x4 27000 mi There is an intermittent metallic /rattle sound (like marbles or a chain in a can) seems to be coming from front passenger side; sometimes on first acceleration , sometimes after turning a corner, sometimes after hitting a bump. Doesn't last more than a few seconds Had my mechanic friend look at it on hoist and no apparent loose parts in exhaust system or breaks; 1st noticed it last August ( 7000 miles ago) but it subsides and then reappears with no distinct pattern. best guess is a bad wheel bearing but it's never gotten any worse; other guess is transfer case/ chain problem but 4x4 use isn't much and it goes in and out of 4x4 mode with no problems.
View 2 RepliesCorolla / Matrix 2009-13 :: Brakes Are Clunky / Metallic Noise Coming From The Back Undercarriage
Well this week, everytime I was backing up, hit a pothole or sometimes when I turn either left or right or hit the brakes a clunky or sometimes metallic sound appears coming from the back the undercarriage.
First I thought may be one of the bars (TRD or the Ultraracing sway bars) were loose, we lift, checked the car with the guy who installed the bars and all of them were tight ,nothing loose, we discovered on the front is time to change the bushings of the front stabilizer bar and also the rods who run parallel to the shocks absorbers but we couldn't mimic the sound the shocks are fine.
Tonight my daughter was driving the vehicle so I have a chance to hear the clunky noise, which I think is coming directly from the inside of the drums the sounds intensified at the time of hitting the brakes but is not all the time you hit the brake when it happened.
Also I can't explained why I heard the sound when I turn left or right and still coming from the back, doesn't make sense I can't find no relation whatsoever
I just add this 2 videos..
[URL] ...
[URL] ....
Steering - Pontiac - G6 :: 2006 - Rhythmic Metallic Grinding Noise Coming From Driver Side Front End
I've been hearing a rhythmic, metallic ringy grinding noise coming from the driver side front end of the car that seems to be in time with wheel rotation. It happens between 5 and 40mph, worsens while the steering wheel is turned even the slightest to the right, goes away completely during left turns, reduces and becomes intermittent above 45mph, and between 0 and 5mph, as I turn the wheel to the right from any position, I hear squeaking. I recently had the front control arm, ball joints and struts replaced. It has 140k miles. What could it be?
View 4 RepliesSubaru - Legacy :: 1997 - Metallic Clunking Or Cracking Noise Occasionally When Coming To A Gentle Stop
We hear a horrible metallic clunking or cracking noise - only occasionally - when coming to a gentle stop, like at a stop sign. The noise is coming from the driver side front and happens more often when the car is stopping gently on a flat or slight downhill. It does not seem to happen when we stop on an uphill. It does not happen during sudden stops. A mechanic recently replaced the driver side tie-rod, thinking that would solve the problem, but it didn't. The same mechanic looked at the brakes and found no apparent problem. The sound is very loud and sounds almost like something is settling.
View 2 RepliesVolvo - S60 :: 2002 - Metallic Popping Noise Coming From Right Front Side Every Time Making A Turn
I have owned a 2002 Volvo S60 2.4L for the past two years, and she has served me well. However, I have been having issues lately. She has hit 179,400-ish miles and with age things have started to fail. I want to know how much it will cost to fix these things and if I can do it myself.
There is a metallic popping noise coming from the right front side of the vehicle every time I make a turn (I haven't particularly noticed if it's a left- or right-hand turn when it happens.) I have been advised by my father that it's probably a CV (constant velocity) joint. Is that what's causing the noise?
My right front headlight has gone out, and I've replaced the bulb as well as the fuse, but it's still out. Could it be faulty wiring? The left front blinker has stopped blinking, I hope that's as simple as changing out the bulb.
The shift is automatic, but in the mornings (I've noticed it's mostly when it's cold outside) I attempt to move the shifter out of park and it won't budge for several minutes. Sometimes I have to turn the engine off, and then turn it back on for the shifter to move.
One last question- how often should I change and/or flush my transmission fluid and the filter, and can I do that myself or should I take it to the dealership? (Which I am reluctant to do.)
Golf V R32 :: Intermittent Metallic Clicking Noise From The Middle Of The Car
I think I have a bad prop shaft CV joint. The car has been intermittently making a metallic clicking noise from the middle of the car. It can happen at any speed, a slow crawl to the highway. The frequency is completely tied to speed over the ground and seems to be once per revolution of the prop shaft. I put the car up on a lift yesterday and slid back the heat shield under the CV joint and bearing in the middle of the prop shaft. There is grease there that looks like it was thrown off of the shaft. Can the CV joint be replaced by itself or am I looking at replacing the entire prop shaft assembly?
View 4 RepliesGolf V R32 :: Noticed Slight Non - Metallic Vibration Noise
I know it's stupid but rattles and vibrations in an otherwise quiet car drive me absolutely crazy.
So, driving I have noticed this slight non-metallic vibration type noise. It seemed to come and go. So I emptied the car thinking it might be something I was carrying around. No such luck. Turned off the climate control, still there. I had the better half drive while I searched. I could never really see anything but thought it sounded like it might be either in the dash or around the floor area. Totally frustrated I unbuckle my seatbelt and crawl into the passenger floor head first. Nothing on the passenger side. I glance over to the Driver side footwell and notice the slightest vibration from a panel that covers the steering shaft as it goes through the firewall right behind the pedals. Aha! A plastic panel being held in place by 2 plastic type screws that are both loose. i tighten them down with a straight screw driver when I get home and silence! The rattle goes away. You might look at yours as well. I think this might apply to all Mk5 cars. Finding/Fixing a rattle like this for me is like finding money.
Golf V R32 :: Power Loss / Metallic Noise From Exhaust
Ive been noticing my R32 getting progressively slower the past few weeks. Disappointing as I was hoping the cooler weather would be making it feel a bit faster. Started off with just a little power loss now it feels like the car just does not want to go anywhere. I'm think clogged cats as the exhaust is sounding now (very metallic and raspy) but wanted to check if there was anything else I should check into first. Car has 83K. Any other symptoms to check for? There is no CEL or codes.
View 10 RepliesFord - F150 :: Knocking Noise Coming From Lower In The Engine
Recently, I was stopped in my 03 F-150 with 124,000 miles. All of the sudden one day, the engine started knocking. The knocking was coming from lower in the engine. After sitting for about two hours, I started it again. At first, no knocking, then intermittent knocking, then steady and after about 3 or 4 min, the knocking stops all together. Oil level has always been checked and it has never run low on oil. What on earth causes an intermittent knock?
View 6 RepliesGolf IV / Jetta IV :: Thumping Sound Coming From Lower Front End
It's come to my attention that I have a thumping sound coming from my lower front end. It only happens on low rpm's and I can hear it best when it's in neutral, if I give the brakes a little push I can hear it louder, more profound, and can also feel it on my feet a little, but I don't only hear it while I have the pedal depressed. So..what it could be?
View 1 Replies