Golf IV / Jetta IV :: Replaced Battery And Alternator Now AC Stopped Working?
I have a 2000 VW Golf 2.slow. I have done some research from other threads but I'm wondering if mine is a simpler fix then testing all the wiring. After taking the car to Auto-Zone and having my battery and alternator tested they said the alternator was the problem. I had to wait a day to get paid to buy the alternator so I had them charge the battery. After I put the battery back in and started her up I got a flashing e-brake light, ABS light and no A/C. My A/C clutch compressor isn't kicking in either. I checked my brake fluid and it's fine as well.
View 15 RepliesGolf IV / Jetta IV :: 2002 1.8T - No Start After Alternator Cable And Fuse Box Replacement
I own a 2002 Jetta 1.8T now here is my story.
A week ago whiles driving lost power when accelerating, EPC light illuminates so I turned on my hazard light and limped home since I was far away from home. As I limped home, all the lights on the dash went off. I got home, shut engine off, restarted the car but car wont accelerate.
I popped the hood and saw the dreaded melted fuse box on top of battery with charred alternator cable. I ordered the fuse box and alternator cable and prepared to replace them.
I realized that with the driver side door open with no key in ignition, I could hear a clicking sound with inside lights blinking. Didn't worry because I believed it had to do with the melted fuse box and charred alternator cable. I noticed that the clock was off too.
I replaced.the fuse box and alternator cable. My battery is just a year old so when I tried starting the car and it won't crank, I tried to jump start it but no sound. Car won't start. Dead silence,no click nothing.
Golf IV / Jetta IV :: Replaced Oil Pan, Car Won't Start
Cracked my oil pan somehow on the way home. I didn't notice it at first because I didn't go out to start it till the following evening. I went out to let it warm up for 5 minutes that evening and it started perfectly fine. I went back in the house to grab a couple of things, and i could here a loud ticking so i run out side to shut the car off and just as i get to the car it dies. so i push it into the shop and of course i notice the huge splotch of oil on the gravel. It sat in the shop for close to a month, as I got busy with school, and what not, I didn't get a chance to replace the oil pan.
I finally replaced the oil pan on Friday night, there was no metal bits or shavings in the old oil pan. it wont start. everything turns on in the car just fine. It just wont start. Battery is at 12.6 v all the grounds are solid no corrosion. The car tries to start, but the starter will maybe turn over once or twice and then stop.
Is the Motor pooched or is there something I'm missing.
Ford - Crownvictoria :: 1996 - Won't Start - Replaced Alternator
why after 3 or 4 plus days, a 1996 ford crown Vic will not start. have replaced alternator, courtesy of the ford dealer.
View 3 RepliesGolf IV / Jetta IV :: 2001 - No Start After G68 Sensor Replaced?
Monday get CEL with codes p0722 and p0322. Car is in limp mode during these codes. Yesterday I change g68 sensor. Cleared codes, rough start but was sitting most of the week. Drove around fine, no limp mode, shifted fine. Started up a few times immediately after. Hours go by I go to leave and it won't turn over though it sounds its wants to. No clue why this is happening or what changing the sensor could have done. This is a 01 GLS 2.0 auto. Not sure where to from here especially since it drove so well afterwards.
View 4 RepliesGolf IV / Jetta IV :: Car Turns Over But Will Not Start After Timing Belt Replaced
I just got my timing belt replaced by my mobile mechanic thats been doing it for years. I saw him do the work and get the timing right. When he was done the car turned on and ran perfect. After about a minute the car just shuts off. Now the car won't start at all. The car turns over but no start. The car ran perfectly before I had this job done.
View 9 RepliesGolf IV / Jetta IV :: TDI Won't Start After Timing Belt Replaced / Cranks And Blows Black Smoke
So i just spent over $1700 at a vw service ctr having a sched 140k timing belt replaced with thermo and fuel filter. This was 3 days ago and when i picked it up it was slower to turn over then got worse and todsy it won't turn over at all even when jumped. It cranks and blows black smoke. Problem is i'm 160 miles from that svc center and it's sunday. There is a vw svc center 14 miles away but i feel like it needs to ho back to where the work was done because it ran great before taking it there.
View 5 RepliesGolf IV / Jetta IV :: Brand New Alternator Bad?
I had a battery light come on and saw the alt wasnt charging my battery. So, I replaced the alt with a rebuilt hitachi. Well it was charging at 14.10 and thought all was well til I went out this weekend and was stranded. Tested the alt with my voltmeter and sometimes its 14 and sometimes the battery drops below 12. I charged the battery up overnight and its holding a good charge. I REALLY dont wanna drop this alternator out again so is there anything else I should check? Im getting the battery tested anyway.
View 4 RepliesGolf IV / Jetta IV :: Headlights Won't Come On After Changing Alternator
My car is a 2.0 AEG manual for reference.
So, my alternator died last night and when I changed it this morning, I fired her up and now when I turn my light switch one click I can see my high beam light illuminated on the dash. If I have the switch on any setting, it's illuminated but no lights are on out front except the dtr lights. Turn signals work fine and so do the brake/tail lights. I checked the fuses for both low/high beams but they were fine. I saw someone mention an ignition switch while I was searching but I'd rather get other opinions whether it is that or not.
Edit: My original test drive the car ran fine minus the headlight issue. But upon driving it through the city when I was coming to a stop at a redlight the battery light came back on and it died. It fired right back up and barely made it across the street to a parking lot before it died again. It'll fire up but won't stay on. On my way to an parts store for charging system check.
Golf IV / Jetta IV :: Battery Died - Alternator Malfunction
Been the proud owner of a '04 Golf for a few years but it hasn't been without its share of hiccups. I recently had my battery die on me. Got the car looked at and apparently the alternator was the culprit, ie, it wasn't functioning and re-charging the battery. Swapped out the OEM for a rebuilt Bosch 120A (my car is a 2.0GL, so it's supposed to be 90a default, but I looked online and saw that I could use the 120). Even put in a new battery as the old one was past its prime. Now the new alternator (which was not fun to install) isn't working either. I had a different mechanic look at it and they said that while the auto shop gave me the right part number, that apparently VWs are hinky with aftermarket parts and I'd have to take it to a VW dealer for a diagnostic? Makes no sense as I've seen tons of people online who've used aftermarket alternators with no problem.
So now the car essentially is dead in the water. Battery light comes on when the car is started and I'm not tempted to not drive the car anywhere out of fear that the new battery will die in mid-traffic. I've checked the grounds, pulley, etc, everything looks fine and connected proper. What could be going on?
Golf IV / Jetta IV :: 1999 Mk4 VR6 - Battery Will Not Charge And Alternator Seems To Be Nonfunctional
I am having a really curious issue with the charging system on my 1999 Golf VR6. The battery will not charge and the alternator seems to be nonfunctional. While running the voltage at the battery starts normal but drops until the engine dies within 20 minutes. Over the last two days I have replaced the alternator, battery, and the battery grounding cable with no change in behavior. The exciter wire on the alternator is showing 9 volts when the vehicle is running and 0 when it is off. There is 1.6 ohms of resistance between the B+ terminal on the battery and the respective terminal on the alternator. There is 0.3 ohms of resistance between the B- battery terminal and the case of the alternator. My task for tomorrow is to trace the exciter wire back to the cluster and try to troubleshoot it there.
View 9 RepliesGolf IV / Jetta IV :: 2002 VW - High Pitch Whine From Alternator
I had a rebuilt alternator installed on Thursday and for the past two days when I start up the car there is a high pitch whine coming from what I believe is the alternator. Do some rebuilt alternators make noise when charging the batter after start-up? The alternator has a 3-year warranty and I'm going back to the shop tomorrow.
View 4 RepliesGolf IV / Jetta IV :: 2001 2.0L - Loud Rattling Sound When Started / Bad Alternator?
So im trying to diagnose my girlfriends issue with her car. When she starts it, the car will make a very loud rattling sound, not really grinding, but like metal on metal contact. Sometimes the sound goes away, but when the car is cold it is a guarantee. The battery light is also on, which was not the case when the rattle first started. I first thought (and hoped) it was perhaps the serpentine belt tensioner as I researched that when it fails it can make a loud rattle sound.
Once replaced, the same issues occurred. So I went ahead and put the old one back on since it was not the issue. Note that the old one and new one both shared the same tension applied to the belt and the pulley was still smooth without issues.
Using a stethoscope to try to determine the location of the rattle a bit more precisely I found the noise to be coming more from the alternator. Weird because I recently replaced it within the last year. I went ahead and removed the tension from the belt and played with the alternator for a bit. The clutch felt good when i used a screw driver to hold the fan and tried to move the pulley. One direction moved with ease while the other direction refused to budge, perfectly normal as I researched. The thing that I noticed that I thought was unusual was the fact that the shaft of the alternator had some play (Video below).
The belt has plenty of tension on it so i do not believe that it is slipping on the alternator. I push the belt with the tensioner engaged and the tensioner does not budge.
I decided to measure the voltage coming off the alternator with the car running and it was at 10.95 which im pretty sure is very low for these cars.
Golf IV / Jetta IV :: Tranny Replaced, Can't Reverse
This weekend I replaced the transmission in my 2000 12v vr6 5 speed golf. Got In drive around block going through each gear all seemed fine. Then I tried reverse and couldnt find it. Seem like it reverse was more like 5th cause car would try and move forward. I have the new style shifter and the bearing is quite a bit beat up. However if I in engine bay operating the gears directly on shift paddle I still can't seem to find reverse. Is there some kind of lock out or what could I be missing. I tried adjusting the cables but that seemed to make things worse not better.
View 5 RepliesFord Excursion :: 2004 - Alternator Replaced - Won't Working Again?
I have a 2004 Big X. Original alternator was replaced as it only was producing 9 volts under a load. Replacement alternator failed within a day. Did I just get a bad re-manufactured one or would something else cause failure?
View 14 RepliesGolf IV / Jetta IV :: Replaced Radiator - Can't Fill With Coolant
I just replaced my radiator in my vr6 jetta. I've replaced my coolant before, with this same problem,but it never affected anything and did not find any answers. But here's the deal. It filled with about 2 gallons of mixed coolant. No noticeable air bubble sounds, coolant flows back into the reservoir. I opened my top rad hose and poured coolant in also. It is not overheating. My heater is also hot, no problems there. It just seems suspicious that my car takes so little coolant, and runs just fine. I also flushed the system with my garden hose, and let all the water drain out.
View 3 RepliesGolf IV / Jetta IV :: Replaced Thermostat Now Alarm Going Off All The Time?
So I replaced my thermostat today... to do that I unhooked the negative terminal of the battery, removed the hose off the thermostat housing (I think that's what it's called) and disconnected the switch to the alternator as well as take off the 13mm jam nut holding the wire to the side of the alternator. I reconnected everything up, put the key into the ignition and just turned it before starting the car and the alarm started going off. I disabled the alarm from controlling the lights and horn by unplugging the electrical connector just behind the fuse panel so I could do some errands today. I then disconnected both terminals on the battery and touched them together to reset the ecu.
After reading that holding the key into the door lock until the windows roll down would reset the alarm; this weekend I'm going to hook up my driver side door lock mechanism (been a little lazy) and give that a try.
Golf IV / Jetta IV :: Replaced Knock Sensor Still Sputtering And CEL On?
I replaced the knock sensor because I was getting the p0327 for the front knock sensor. Drove it again and still sputtering and CEL came back. What are other causes of this? N75 solenoid? Low fuel pressure?? It has a spectre air filter kit on it. Didn't know if this would do it. I cleaned maf. Just put new plugs in it too.
View 5 RepliesFord - F250 :: 2006 - Replaced Alternator But Cannot Get The Batteries To Keep A Charge
I have a 2006 Ford F250 Superduty 4x4 6.0L Diesel with an alternator/battery problem. We have charged the batteries (had them tested at auto zone), and replaced the alternator and still cannot get the batteries to keep a charge. I'm not talking a slow drain, with the ignition switch on for less than a minute it drains about 4 amps and the truck dies. We also noticed a trouble code "TBC fault" and discovered that was to do with the trailer brakes. Disconnected the trailer brake system (have been noticing a "check trailer" warning occasionally recently). What could be causing such a massive drain on the batteries?
View 3 Replies