Golf V R32 :: Squeaking Noise By Right Rear Quarter Panel Inside Cabin
I am hearing a squeaking noise by my right rear quarter panel inside the cabin. How to safely remove the panel. I tried searching but the instructions were vague.
View 3 RepliesGolf IV / Jetta IV :: 1.8t - RPM Going Up And Down / Hesitation After Cleaning Throttle Body
I decided to take out the throttle body and clean it with throttle body cleaner that I got from autozone, after I put everything back, I started my car and the motor was shaking and smoking a lot out the muffler and just would not be drivable at all. the RPM was just going up and down and hesitating bad. later I took off the spark plugs and they were very much burnt black at the tips and that is probably not normal right? but I replaced them with NGK BKR7E spark plugs and it still gave me the problem.
View 13 RepliesGolf IV / Jetta IV :: Throttle Body Not Working And Car Is Surging
I have a customer that has a 2.0 mk4 with 260000 miles on it..about 20k miles ago we had 6 codes saying throttle body was not working and car was surging, so we ordered a vdo tb, installed it reset tb and it ran fine for 7 months and 20k miles. Again car is surging, so i tried a tb reset. tb was under guarantee so we took advantage and replaced it/reset it and it threw a code within 5 min of driving and hesitating/surging. He is original owner? possible ecu getting sleepy?
View 22 RepliesGolf IV / Jetta IV :: 2000 - Throttle Body Causing CEL?
So the other day I went to the mechanic for him to see what code(s) were causing my CEL. He simply told me that there was an issue with the throttle body and it didn't know what position to be in; he cleared the codes, clean the throttle body and said if the light came on again I needed a new tb. The CEL came back on, but his diagnosis doesn't make sense to me.
From what I've researched if the throttle body had this issue the car would run like crap; however, it runs fine. Smooth idle, good throttle response, accelerates smoothly through the rev range, and I'm still getting decent fuel economy. Given that, it doesn't seem like it's the TPS either, and the tb was just cleaned so I'm confused. Could it actually be the throttle body, or is there some sensor that has just gone bad? The car is a 2000 Golf with an AEG engine & 5-speed box.
And here are a couple pic for clicks of a stock-ish car.....
Golf IV / Jetta IV :: EPC Light Keep Coming On - Faulty Throttle Body
I have been having the dredded EPC light coming on and according to the vag scan its the throotle body. What I need to know is if one off a 2003 2.0 jetta will work on my 2004 2.0 jetta. The number on the side of mine 06A 133 062s is not the same number on the 03. I was told that they must match to work properly.
View 2 RepliesPrius (2010-12) :: Small Gap Between Headlight Assembly And Body Panel
A few weeks ago my 2010 Prius was involved in a minor front end collision. The car has since been repaired. Today I noticed that the passenger side headlight assembly (which was replaced) doesn't seem to fit quite right. There is a small gap between the assembly and the body panel at the most extreme point on the side of the car. Is this just a cosmetic issue, or could water seep in at the location and cause internal damage?
View 1 RepliesGolf IV / Jetta IV :: Rough Idle / Small Hose Behind MAF In Front Throttle Body Split In Half
I searched but couldn't immediately find anything about this particular line. I've been struggling with a rough idle for the past couple weeks, throwing codes that I'm running to lean all the time. I cleaned the throttle body and MAF, and was in the process of replacing the MAF and noticed a small hose fitting behind the MAF but before the throttle body was pretty much split in half. I don't know what it's for and I'm replacing it regardless, but could this be the source of my problem?
View 5 RepliesGolf IV / Jetta IV :: 2002 - Replace Throttle Body And Coil In Cylinder 2 But Again Error Message P0638?
I have got a 5 door 2002 Golf 1.6l petrol, manual transmission with 190k kilometers on the clock. It has been playing up recently and the authorized VW garage is clueless, but still happy to charge for a miserable job...
The "symptoms" are always the same: I can start the car no problem. Plenty of water coming out of the exhaust and EPC light comes on, no power transmission (or very little). In this state, the engine runs irregular. Before all this happens, you can tell there will be a problem (this is not super obvious), as the car does not run smoothly in neutral, especially when it is at a a hill You might get away with another 50k but that's it.
Breakdown 1: Called out road side assistance and got it towed. Volkswagen dealer retrieved the error code P1564 and they replaced the throttle and some of the contacts of the throttle. (Costs 800 GBP)
Breakdown 2: However, 300 km later, same problem as before road side assistance retrieved error code P0638. The memory was reset and it did run perfectly fine for a short while (2000 km).
Breakdown 3: As before, error message P1564 was read. This time they thought there was a problem with the coil in cylinder 2 and replaced it (250 GBP) - also the one in cylinder 1 as "old". Picked up the car and it was not running smoothly in neutral and it eventually broke down after only 90 km.
What to get changed next? What is the real root of the problem here?
Golf IV / Jetta IV :: Instrument Panel Lights Are Very Dim?
This has bothered me a while. I turn the instrument lights to max brightness, but they are very dim. I can see them, but they are all very dim.
View 6 RepliesPrius (2010-12) :: Protect Rear Door Lower Body Panel From Scratches?
I just purchased a 2010 Barcelona Red Prius II to replace my 2008 vehicle of the same color (which is going to our daughter). We have a terrific dog who, in my 2008 car, would often step onto the metal part of the car when getting onto or off from the backseat. This has left scratches in the paint, as it lies behind the area protected by the grey plastic in both cars (i.e., where it begins to slope upward). Is there anything that can be done to protect this?
View 7 RepliesPrius (Gen 3) :: Strange Rattle Coming From Inside Main Body Of Car
I strange "tinny" rattle has started and I cannot seem to find the cause. The location seems to be on the driver side some place in front of the gas panel door and someplace behind the rear door. It seems to be coming from something inside the main body of the car! If I slam the rear door I hear it for a few seconds.
View 19 RepliesGolf IV / Jetta IV :: Rusty Passenger Side Rocker Panel
Recently I made a corrosion claim about some rust forming on my jetta. Long story short VWOA accepted to replace my passenger side fender and trunk, but refused to replace my passenger side rocker panel. Once all the warranty work is taken care of I would like to treat the rocker panel rust the best way possible. I'm not looking to spend hundreds of dollars on this procedure, but I don't want there to be a hole in my car by next winter.
Personally I'm thinking of sanding it all down, treating the rust, applying some paint to it, and then trying to protect the area a little more by investing in OEM side skirts.
Golf IV / Jetta IV :: MFA And Climatronic Panel Don't Give Accurate Reading
My display on the MFA and Climatronic panel is really wrong (-44C now). I was taking a look at the sensor in the front left grille but the only thing that's changing into the readings with my Vag-Com is the outside temperature sensor but not the displayed temperature.
I didn't find any other sensor on my car. Nothing into the rain tray...
Golf IV / Jetta IV :: Interior Backlights And Instrument Panel Lights Not Working At All
So I know these posts a a dime a dozen but unlike most i know what did to cause the lights to go out.
I unplugged the dimmer switch harness and headlight switch harness to clean the air vents. When i plugged everything back in, none of the red or blue backlighting turns on when i turn the headlight switch. The instrument cluster and all the trim remains dark.
At first my turn signals were not working but they have begun working again. headlights and break lights all work. and my interior dome lights work.
I checked every fuse i could think of that would relate to the interior lighting and everything looks fine there. is there something else i can check?
Golf IV / Jetta IV :: 1.8t - Oil Smell Inside Car And From Exhaust
I've got an awd 1.8t and ever since I did my 3" downpipe and cat delete I've had an oil smell both inside my car and from my exhaust. I thought at first maybe it was the valve cover gasket which I did last summer, but it looks to be fine. Also it does smoke out of my exhaust sometimes, but a buddy told me if it was my turbo seals my oil level would reflect the seals being gone, which the oil level hasn't moved. What else could it be? Do I just need to put a cat backin?
View 5 RepliesGolf IV / Jetta IV :: How To Clean Inside Door Handle
I need to clean the inside door handles badly on my Jetta. See pics. It seems that there outer layer of plastic is stained and rubbing off. I want to take this layer off completely, and protect it, but want to make sure I use something that's not harmful to the plastic.
Additionally, I need to re-glue a couple of trim pieces. I looked into trying to get replacement wood burl pieces, but VW stopped making them years ago, and I can't find them anywhere. My local dealer last sold a single piece a year ago for $303 (yes - a single piece - the driver door simple 1" strip; not the whole kit). So I'm going to try to re-glue the broken piece to try and make it look decent. I'm wondering if others have had experience doing this and can suggest the best type of glue.
Golf IV / Jetta IV :: 2003 - Door Won't Open From Inside Or Outside
So I noticed my door wouldn't open from the outside when my friend was trying to get in the backseat. It opened from the inside, and like an idiot I turned the child safety lock. So now the door will not open from the inside or the outside.
Is there any possible way I can get to the cable to get the door open from the interior or exterior?? Can I take the door panel off without the door being open?? It's a 2003 Jetta GLS 1.8t...
Golf IV / Jetta IV :: Cleaning Rough Area On The Rocker Panel Non Side Skirt Cars?
Any tips and tricks on cleaning this? Just did an entire wash clay compound with orbital and a wax. Car looks great for a 12 year old but This area is a bit tricky clay gets stuck in the pores and nothing seems to clean it well. Id like to clay it but its not working well.
View 2 RepliesGolf IV / Jetta IV :: Rattling Noise When First Start The Car
I own a MK4 Golf GTI which has recently started making a rattling noise when I first start the car (Perhaps cold weather?). It will continue for roughly a minute despite load (A/C, acceleration) before It stops and It won't happen again until the car has cooled down hours later. It's quite an unsettling noise and I would like to be set in the right direction.
After a couple hours online I'm leaning towards perhaps the belt tensioner being to blame? I haven't delved too deep into the noise but do believe it is from the left side of the motor. Can likely clarify on the weekend.
Is there anything to worry about? If so, where do I start? I myself was trying to fiddle around and see if the noise would happen at higher revs, which it seems to. [URL] .....