Golf IV / Jetta IV :: Starter Motor Doesn't Engage Or Spin When It Is Very Cold
My starter motor in my 2004 Golf 2.0 doesn't engage or spin when it is very cold. By very cold, I mean below 5F.
The battery has plenty of juice, and jumping the battery doesn't work. I turn the key to "start" and nothing happens. When key is in the on position, fans, wipers, etc all work fine. When the car warms up to 20F or so, everything is fine and the car starts.
Here's the funny thing. If I put a little space heater on the driver side floor to warm up the fuse and relay panel, it starts with no issue.
I don't know enough about the interlocks between load reduction, starter motor, ignition switch etc to make a good guess as to which relay (if any) may stick in extreme cold. It's a tough problem to diagnose, because I can only experiment when it gets REALLY cold, when it isn't very fun to experiment anyway. I don't think it's the piggy back harness, because the wipers, horn and fan all work.
Golf V R32 :: Squeaking Noise When Starter Motor Engages
I've had my .:R for a while now, gotten used to its little quirks. But one thing that sparks my interest (not really worrisome though) is I have a squeaking noise when the starter motor engages. It definitely squeaks once per revolution for about 4-5 sqeaks, and it's noticeable in and out of the car. Is it a bearing going bad?
View 5 RepliesGolf IV / Jetta IV :: Starter Grinding Noise
So I have the well known starter grinding noise since I bought the car six months ago. Is there really any danger to the flywheel or the starter itself not fixing this? I don't mean from a purist point of view, of course it's not good. I don't really care about the noise. Does it maybe 1 out of 3 starts in the cold. Are things really getting chewed up, or it's really no big deal.
View 13 RepliesGolf IV / Jetta IV :: VR6 Won't Start When Engine Is Warm
Mmkay.. 2000 GTI VR6.. Will start initially, when engine is cold (sat overnight, or through the work day) but once the engine is at normal running temp, if you shut it off, it wont start. Acts like its out of gas.. have to "prime" and keep hitting the gas pedal while cranking, to (sometimes) get it to start when warm, and then it runs like crap until I get a few miles down the road.
Brand new plugs and wires, and just this evening, pulled a plug, and its obviously fouled, and covered with unburnt gas. Coil Pack maybe?
Golf IV / Jetta IV :: 2002 - Starter Relay Click But Won't Start
About 2 weeks ago, my jetta decided it didn't want to start. Was getting symptoms of a bad ignition switch prior to this. Could get it to start one by jiggling the key. Replaced the ignition switch and now could hear the starter relay click but still no start. Yesterday, installed a reman starter and got it to start once. Could here the solenoid click when trying to start. Was reading on here or somewhere that it my be my power control relay, so took the top off to look at it and it was fine. Battery was down about 100 amps so it was replaced and still no start. Going to go see if my vag com will talk to to the ecu. Thinking about pulling the starter out and having it tested.
MK2 are so much easier.
Golf IV / Jetta IV :: Random Hard Start After Car Is Warm / No CEL
I have a 99.5 golf gls with an 02' engine in it. 5 Speed, neuspeed supercharged with a bunch of other stuff done to it.
I've had this issue as long as I've owned the car (3-4 years). Starting the car cold, it usually fires right up and can drive it e, no problem. However, when I get the car up to operating temp and turn the car off, if I immediately try and restart the car it either :
A.) chokes but will fire or
B.) will have a long crank and usually starts hard.
Another thing I noticed is that at low RPM right after the clutch has been engaged, the car seems to almost hesitate like something is holding it back, even if I give it more gas. I have checked my codes with Vag com and the only CEL I have it for not having a post cat o2 sensor (picks up that the heater circuit is unplugged). I also have run some diagnostics on my fuel trim and both long and short term fuel trim are within spec. I tested two different mafs and both were around 2.5g/s at idle. Checked for vac leaks and didn't have any.
I have read that a dead/dying crank sensor can give me the symptoms I have, but I seem to be lacking a symptom where the CEL is on for the sensor, and my car doesn't randomly die when driving. So my question is, have any of you had the same symptoms but no CEL?
Golf IV / Jetta IV :: Turbo Set Up - Motor Won't Start
Well I have been working on my build for about 2 1/2 years. Built the motor for the turbo set up that I had on the car and a few other goodies.
Now the motor turns over with no issue and I have spark. So I know my problem lies in the fuel delivery. My pump tested fine and I have fuel at the rail. So my next guess is the injectors. After trying to start the car I pulled 2 spark plugs out and they where dry. So this proved to me there's an issue here.
Before I go and rip my manifold off and start pulling injectors is there anything I could check first? I'm thinking from sitting that have gotten dirty and clogged.
Looking for wire diagram for the injectors on the vr6?
Golf IV / Jetta IV :: Random EPC And CEL - Can't Communicate With ECU - Doesn't Start When Warm
So, the very first time it happened was the weekend after I installed my new motor mounts I am not sure if it is a coincidence or if there was something that I touched while installing that is causing the car to act this way. So I notice that it's more common on the wet days even though I have started to doubt this recently as well. The instrument cluster illuminates CEL and EPC for a brief second and the car feels like it looses all power and sometimes even stalls when at idle but then after that goes away it runs like a champ. Also ever since this started happening the car is really hard to start after it sits off for few minutes when at normal running temperature. Right, when it happened I tried to scan it and I thought it was the scanner that was not able to communicate with it but that wasn't it since I have tried over 10 different kinds now( that includes the ones that have scanned my car with no problem before). I did have the CEL to stay on once but I still couldn't scan it and it went away by itself or I have reset it by disconnecting the battery. Its really driving me crazy and I am stuck but not giving up on this car, I love it too much and it's been very faithful to me so far! I mean there was literally two days recently when the weather was dry when I drove the thing without the random occurrence of EPC and CEL but it still didn't want to start when warm. In fact, one time after work after it has been sunny all day it didn't want to start when the engine was still cold as well.
The things I have replaced or tried so far that have not repaired it are:
*New Camshaft Sensor
*New Crankshaft Position Sensor
*New Purge Valve
*New Coil Pack
*Took off and cleaned my Throttle Body
*Checked with and OHM meter as many grounds as i could find between battery and they all checked good(the main engine ground looks good)
*Cleaned MAF sensor
*New Coolant Temperature Sensor
*Checked that all fuses were good and seated
*Verified that the k-line is good.
*Able to scan the ABS module and radio through vag com so i know its something with the ECU communication
That's all that I can remember as of now. the car went through many stages but here is how it looks as of now.
[URL]
Golf IV / Jetta IV :: 2003 VW GLI Takes A While To Start When Engine Warm?
I have a 03 vw jetta gli and whenever the engine is warm when it was recently on, takes a while to start like 3-5 second but normal when it is a cold start..
View 6 RepliesGolf IV / Jetta IV :: Knocking Noise When Installed New Motor
Okay just installed a newer 24v into my existing 24v VR6 GTI both with 135k. I have heard the motor run before it was pulled and sold to which sounded fine. Upon receiving the motor I put new timing chains, guides, headgasket and new gaskets all around. The timing was right on the mark and I tightened everything up to torque spec and I'm getting this noise which sounds like it's from the timing cover area. A code just popped on which I'm going to scan as soon as I get my hands on one. The car was running great for about 20 minute and I shut it off then turned it back on about 5 minutes later and experiencing these scary noises. I tried pulling each individual coil with no results to get the noise away. What could this be?
[URL] .....
Golf IV / Jetta IV :: 2003 - Tires Making More Noise In The Warm Weather?
My car has 130k miles and has recently developed a worrying noise. It makes an extra whirring sound, like another set of gears spinning, but I don't think I would describe it as a grinding noise. I live in VT and I thought maybe it was my (studless) snow tires making more noise in the warm weather because I noticed it about a month and a half ago when it warmed up. Now that I have my all season tires on, it's still making the noise. The tire guys didn't notice anything wrong when the swap happened (but they only do tires there and I didn't ask them to look for anything).
As far as I can tell it is dependent on wheel speed, not engine speed. It starts at about 20-25mph and gets louder the faster I go. At about 65 the normal road noise is louder than the new noise. If I turn the wheel to the right to any degree the noise goes away. I can't tell if it is completely gone, but it seems like it is. There is no real change if I turn the wheel to the left, though it might get slightly worse. When the noise is going I can feel a vibration in the floorboard that matches the sound. The sound seems like it is coming from in front of me, but I can't really tell if it is left, right, or center. As far as I can tell that is the only new noise, no clicking/griding when I turn the wheel etc.
I'm taking it in for normal 130k maintenance in a week....
Golf IV / Jetta IV :: 2008 - Makes Annoying Noise When Engine Is Warm And A/C Is Turned On
Mk4 Golf City*, 2008, gas, manual, sunroof. Canadian budget-model.
Mysterious noise like WOMMMMM, WOMMMM itinerantly: Noise is only when air conditioning is on and the engine is warm. I can feel vibrations in the brake pedal. *You can't hear the noise under the hood*. It is quite loud in the cab, though, definitely coming from under the dashboard.
I have stuck my nose in. I removed the glove box and listened to the blower motor, it seemed to be coming from further toward the driver's side. It will be like wmmmmOMMMMM WOMMMMM pause WOMMMM like something is vibrating too close to something else and the friction causes it to go back to where it was.
I hit a speed bump going a bit fast. I broke the small cooling fan somehow so it was just loose hanging on its hub. I had that repaired but the noise hasn't gone away. It seems to be getting more frequent but so far there isn't any indication of the car suffering. This is the second summer it has made the noise.It haunts my sleep.
Ford Ranger / B-Series :: No Movement From Starter Motor When Key Is Turned To Start
I have a 2002 Ford Ranger with a 3.0L engine that is having some issues with starting, here is what is happening.
Every so so often when the key is turned to start there is no movement from the starter motor. The battery is fine and all of the dash lights stay on while the engine is not starting. I have replaced the starter with a remanufactured model (possibly a mistake), and also replaced the clutch interlock switch.
I have attempted to change the ignition switch but the replacement I received did not even try to turn the starter (after many tries), like possibly it was faulty out of the box. I am currently using the OEM ignition switch as it will at least turn the starter eventually. I just worry that this problem will develop further at the wrong time.
Ford Super Duty (1999-2016) :: Starter Just Barely Turns Motor Over And Definitely Not Fast Enough To Start Truck
I have a 96 f350 that I just replaced the batteries on and now when I go to start it does not hardly turn over. Starter just barely turns motor over and definitely not fast enough to start truck. Battery connections are tight and starter was replaced about 4 months ago.
View 4 RepliesFord Super Duty (1999-2016) :: 2002 F450 - Starter Motor Fuse Kept Blowing / No Crank No Start
2002 F450 7.3 Turbo
Ok first problem : Starter Motor fuse kept blowing and I spent weeks trying to figure it out. No luck. so wired up a push button just to get the truck started, its a work truck so it was needed asap.
2nd problem : he truck stopped starting completely. Wont start in Park or neutral and after a NEW STARTER (because I thought the solenoid on the starter was bad I replaced it) Everything work correctly for one start with the key. After the second time trying to start it blew the starter fuse again. So I tried the straight wiring to starter. still nothing. I was wondering if there are any shims or anything at the transmission housing to correctly position the starter. I am thinking that maybe the gear is stuck or gets stuck sometimes. when I straight wire the starter it does nothing but the wire gets hot so I know its pulling.
Jetta - Volkswagen :: 1996 GL Won't Start When Temp Start To Warm Up
I have a 1996 VW Jetta GL 4 cyl. 2.0L. When the temp. start to warm up the car won't start. I don't know if its the temp. outside, or in the cabin of the car. all the dash lights turn on, and accessories turn on. sometimes I hear a clicking noise, which I think is the sound of electricity going to the starter. I have replaced the starter, alternator, & battery. I had a family friend mechanic look at it for about 3 hrs. and he couldn't figure it out. I have a suspicion that it might be the ignition switch faulting out, but how would I know for sure with out taring apart the steering column?
View 6 RepliesJetta :: The Starter Is Making A Sound After Start Up
Ok, here another brain buster that I cant let go a minute longer(i'll explain later). I just got back inside from replacing the starter in my 02'' VW Jetta tdi. The starter is for a 97" VW passat TDI manual. A little over a year ago, I had my auto transmission swapped with a manual passat so its the right starter. Regardless, i just replaced the starter and and upon start up the starter is making a WWW ZZZing sound after start up.
I've been down this road before, its partially the reason for the swap in transmission. About three years back i replaced a starter on the original trans and this familiar sound was present after start up. During the course of a year i went thru 3 starters and and they eventually ate my fly wheel. By that time the trans was starting to grind when it downshifts from 2nd to 1st. not all; three four replacement starter made this sound.
Golf IV / Jetta IV :: Starter Won't Crank / Not Even A Click
Removed battery cables and held together to clear ECU ... Re-attached and no crank not even a click ...
View 3 RepliesGolf IV / Jetta IV :: Starter Clicks Once But No Startup
I've bought new starter cleaned starter contacts battery contacts jumped it bypassed the ignition and relay but taking a wire and touching the positive to the signal wire..used jumper cables as a direct ground to to the starter the torque converter spins so it's not seased...I don't understand what could possibly be stopping this thing...it's just one click like the starter is jumping out but not enough power to turn... 2002 Jetta 1.8t auto
View 18 Replies