Golf IV / Jetta IV :: 1.8t Turbo - Hissing Sound When Accelerating
There's this 1.8t gti I'm buying this week from a family member and we've been trying to solve an issue that we ran into. When accelerating the car there is a hissing noise, safe to say that it is air. Then when accelerating a little harder and you feel the turbo pulling you everything seems fine. But a second or so after , the turbo dies off and so does the hissing noise. Then I can let go of the gas and repeat the process and it happens again.
My issue is that I cant figure it out since I Need to be driving to hear the hissing and the turbo cut off. I looked around the threads but nothing really seems to match my issue. No codes either. On top of that I've never owned a 1.8t and don't know much about its turbo.
Golf IV / Jetta IV :: 2001 - Weird Turbo Spooling Sound By Passenger Side?
I just got a 2001 Jetta 1.8t 100k miles, and had some repairs done - timing belt - K03S Turbo - Forge Tip - 2.5 Turboback Exhaust. I bought the car without a working turbo, yesterday I got the car back from the shop and it was a night and day difference..... but to my point, today I had some CEL's pop - Charge Pressure control positive deviation, Pressure drop between turbo and throttle valve, and secondary Air injection system incorrect flow detected. Now I have never owned a turbocharged car before, but when my windows are rolled up and im accelerating, I can hear what I am guessing is the turbo starting to spin over by my passenger side(2k ish rpms+) except it doesn't have clean spin sounds, kinda sounds like bearings are goofed or something. This noise only happens when I am accelerating or cruising? I also have felt really no change is boost or power!!
View 2 RepliesGolf IV / Jetta IV :: 1999 - Knocking Sound At Idle
1999.5 gls vr6 ... 113k on the clock
Timing chain hasn't been changed yet .. Has new spark plugs & wires ..
Water pump was replaced & pulleys look fine ..
No CEL .. Yes there's oil in it.
I get a knocking sound at idle and it has absolutely no rhyme or rhythm which makes me think it's not a valve or rod(wouldn't that make a constant noise?). The sound comes from the passenger side floor board. Only happens at idle, and if you rev the engine, it will go away. Even if you don't rev the engine some times it goes away then comes back. Sometimes I hear it when i pull up to a red light real loud & most of the time the engine purrs like a kitten. I even sat in the car and told my dad when it was making the knocking/ticking noise and he went all over the top and bottom end with a mechanical stethoscope & heard absolutely nothing. Am I missing something obvious?
Golf IV / Jetta IV :: 2003 1.8T Engine Knocking / Slapping Sound
I've got a 2003 Jetta with the 20v 1.8t, today I was driving along and when I slowed down coming into town, my car started making this sound that I can only describe as sounding like a tractor. It sounds like something is rattling under the valve cover.
Here's a video with the sound : [URL] ....
Golf IV / Jetta IV :: 2000 GLS - Knocking / Clunking Sound While Coasting
My 2000 Jetta GLS is producing a clunking/knocking sound from the front end (possibly left-front) ONLY while coasting and going straight. It mostly goes away if I turn left or right and totally goes away when I give the wheels engine power or when I brake.
I recently replaced my front-left control arm due to a thrashed rear bushing. I didn't replace the bearing as I didn't have a pickle fork. Not sure if this is related.
Golf IV / Jetta IV :: Knocking Sound When Accelerating And Shifting From Stops
Quick q recently just got a gli and I've noticed a knocking sound when accelerating and shifting from stops could this be my motor mounts ? I was thinking my tranny or clutch but everything runs smooth and goes into gear fine...
View 1 RepliesGolf IV / Jetta IV :: Knocking Sound In Rear Passenger Side Area
There is a knocking sound in the rear passenger side area. Cannot diagnose the cause, what it could be. I checked the bushings for the anti sway Bar but that was not it.
View 1 RepliesGolf IV / Jetta IV :: Grinding / Knocking When Turn And Occasionally Make Bong Sound When Reversing
My 2003 Jetta GLI was making a terrible grinding/knocking noise when i would turn and occasionally make this "Bong" sound especially when reversing. I took it to my local shop and they say my spring in the front left is "either broken or unattached" and that i need spings/struts. I have like 150k miles on this car so the timing is probably right. So my question is, how much should they charge for this? Also, what should i have them order and install? Im not trying to lower or anything like that, OEM or a slight upgrade is what im looking for....
View 9 RepliesGolf IV / Jetta IV :: Turbo Set Up - Motor Won't Start
Well I have been working on my build for about 2 1/2 years. Built the motor for the turbo set up that I had on the car and a few other goodies.
Now the motor turns over with no issue and I have spark. So I know my problem lies in the fuel delivery. My pump tested fine and I have fuel at the rail. So my next guess is the injectors. After trying to start the car I pulled 2 spark plugs out and they where dry. So this proved to me there's an issue here.
Before I go and rip my manifold off and start pulling injectors is there anything I could check first? I'm thinking from sitting that have gotten dirty and clogged.
Looking for wire diagram for the injectors on the vr6?
Golf IV / Jetta IV :: 2004 - Turbo Is Leaking Oil
I have a GTI with a turbo that leaks oil.I don't exactly know what to do. The guy i bought it from said it had "Bad Seals" I've seen many rebuild kits online for my turbo(KO3) Looking through the kits i really only sea one seal. One single O-ring. So that doesn't seem right but this is my first turboed vehicle so i can honestly say I don't know much. Should I buy the Rebuild kit or should I just buy a new Turbo? Any video to reference too because i don't even know how to remove my turbo.
Also, on a side note. I was being a show off one day and tried speeding off like a dick.I went from first and grinded HARD into second and since then I haven't had first gear. Now i suspect its my synchros. But like i've said before. I don't know much.
Golf IV / Jetta IV :: Turbo Squeal In 1st And 2nd Gear / WOT At Low RPM
I have this odd turbo squeal in 1st and 2nd gear WOT at low rpm... turbo is new and was replaced in june of this year... had no issues with it up till probably a few weeks ago when the squealing started... it doesn't happen in any other gear at WOT, just 1st and 2nd... where do I start looking?
Here's a video of the squeal : [URL] .....
Golf IV / Jetta IV :: 2004 1.8 Turbo Growl At Idle
My wife just got his car and she loves it!. its a 1.8t 5 speed. Runs and drives awesome. She had 2 new beetles before this one with the same motor but they both had 2 1/2 exhaust from the turbo back. The jetta will be done soon but it has this slight growl when its idling sometimes. Doesn't seem like its every time or may be it seems more when its warmed up. We had just changed the timing belt and tensioner and water pump but we did it 2 days after we got it so I am not sure if it did it before or not.
Kinda sounds like a bad needle bearing where when you spin it and can feel little bumps in it...don't know if that makes sense or not. You can kind of feel it when your sitting in it but its hard to say because we just got it. I don't remember the beetles doing it though but may be the exhaust kinda made it less noticeable. It did have a code about exhaust something bank 1?? I am thinking the cat might be bad or the o2 sensors. i have more sensors im gonna try but when i do the exhaust I know the light will be on anyway.
Golf IV / Jetta IV :: Turbo / Engine HP Surging Occasionally
While I'm in the engine troubleshooting the AC system, I figured I may as well get into a few other issues I've noticed.
I have a stock 1.8T and my turbo feels like it's surging occasionally. A few months ago my diverter valve started making the "blow off sound" when I shifted (manual transmission).
Is it possible for a faulty diverter valve to dump the boost overboard and cause the turbo, and engine hp, to surge? It almost feels like I let my foot off the gas for a second or two (i.e., engine power is very peaky).
A second thing that comes to mind is a clogged fuel filter. I know VW does not recommend ever changing it so it's never been done. Is this a possibility as well?
Air filter is clean, by the way. There's a K&N washable one in the stock air box and I can see daylight through it so it's not too dirty.
Golf IV / Jetta IV :: 2001 - Installing Bigger Turbo?
So I recently got this GTi and I was wondering what steps I should take before putting a bigger turbo on this car and the steps I should take when putting a bigger turbo. What should I do first be for considering a new turbo?
View 1 RepliesGolf IV / Jetta IV :: 2000 - Turbo Back Exhaust - How To Fix It
I have a 2000 golf 1.8t 4 door Looking to make my car a little bit louder than the stock system. I am looking at getting a new downpipes from neuspeed. I don't know if I should go ahead to and get a new ecu, I don't have a ton of plans for the car just want to make it a fun daily.
View 4 RepliesGolf IV / Jetta IV :: Turbo Flutter Over 20 Pounds Of Boost
I have an 03 GTI 1.8t with the stock K03s turbo and i used to boost to 25 pounds. Had to put a new motor in and now i when i boost above 20 pounds i get turbo flutter and loose boost. I can boost anywhere up to 20 pounds and the turbo doesn't flutter at all.
I had a spring on my waste gate which i have taken off and it changed nothing. I tried a different diverter valve and it didn't change anything. I unplugged the MAF to see if the N75 or the there was a boost leak and extra air wasn't being monitored but still changed nothing. It has nothing to do with my RPM range just when i boost over 20 pounds. I am planning on doing a leak down test to make sure there isnt a boost leak....
Golf IV / Jetta IV :: 2001 - Odd Grinding Noise Near Turbo?
Have had this grinding noise going on with my 2001 gti GLS 1.8t, the cam chain tensioner has been replaced recently. Would really like to get this solved and fixed, car has 81k miles.
Found this video on youtube, same model and exact same noise as mine : [URL] ,,,,
Golf IV / Jetta IV :: 2002 - Turbo Fans Keep Blowing Out?
I bought a 2002 gti mk4 with about 127000 miles on it .I did not know the turbo fans were blown out , they were sitting in my down pipe next to my catalytic converter . So I replaced the turbo myself , and 2 hours later the fans fell out of the new turbo , what might be the problem ? why it keeps blowing.
View 7 RepliesGolf VI R :: No Turbo Boost - Weird Sound When Hit The Gas
I have a 2012 R with 85,000 miles, APR chip running 93 octane with a HPFP and VWR cold air intake. I was driving my car today (slow driving on highest) and all of a sudden I felt no turbo boost, and heard a weird sound whenever I hit the gas. Car moved but would not get above 3500 rpms and couldn't really get past 60 mph. Again, absolutely no boost (I have a boost gauge as well to verify).
About to drop off the car at a shop but had a couple questions:
1. If the turbo is blown, can I still drive the car to the shop (not too far) without damaging the engine itself?
2. if the turbos needs to be replaced, what are my options besides getting the stock turbo replaced, without getting some crazy setup? This is my daily driver and I don't want to spend money beyond what I need to get it fixed, but it there is a stronger more reliable turbo for about the same as a OEM, I would want to consider... Also price for OEM replacement??
3. Without the mechanic looking at it, I'm just assuming it's the turbo but what else could be the issue? All the lines looks intact and intake is fitted correctly. I did have issues with my cam follower getting damaged at 45,000 miles (there was a hole in it) and I have been replacing it every 20,000 miles since. Didn't have any issues for 40,000 additional miles, but could damage to that cause turbo failure?