Golf IV / Jetta IV :: Light Vibration Starts At 85 - 90 Mph And Stays Relatively Constant Above That
I have this annoying vibration that starts at 85-90 mph and stays relatively constant above that, but doesn't get super intense or feel like the car is going to fall apart. Its a light vibration that I can feel at 9 and 3 on the steering wheel.
Background: So about 6 months ago I realized my CV boot was torn. I tried to replace CV joint, but they sent wrong joint(Meyle) so we ended up trying to force it onto the CV shaft for like an hour before giving up. I remember one of my BMW Technician buddies literally smashing the joint onto the shaft with a plastic mallet but it just wouldn't go over the circlip.
We ended up just replacing the boot and putting the old CV joint back on, but we didn't have any extra grease to put in it because we had already put it into the new joint that wouldn't fit. Since then I've basically tried everything I can think of, including:
-Balanced and Road Forced
-Laser Alignment
-Replaced all 4 tires
-Fixed bent rims
-Refreshed suspension/steering:
-All new F+R LCA bushings
-New inner/outer tie rods
-New ball joints
-New sway bar bushings
-New strut top mounts
So what the hell is keeping her from being smooth as butter over 90? Did we screw up the shaft by beating on it? Or is it just vibrating from the lack of grease/damage from torn boot? Was I supposed to align the shaft when putting it back on or something?
Golf IV / Jetta IV :: Vibration In The Front End
I have an 04 Jetta that I recently had the trans replaced and ever since I picked it up there is a vibration in the front end. I took the car back and they said it was my DP hitting the cross member. They suspected mounts. I ordered and installed all 3 new mounts but the noise is still there and the trans mount looks crooked where the mount bolts to the trans bracket.
View 8 RepliesGolf IV / Jetta IV :: Slight Vibration From Front End On Driver Side
I started to notice a slight vibration coming from my front end on the drivers side last week and now is pretty loud. It increases with acceleration, fades slightly when turning left, and goes away almost entirely when turning right. Tie rods seem fine. The inner and outer cv boots are torn but have been that way for some time.
View 4 RepliesLexus RX 2004-09 :: RX330 - Vibration While Driving / When Go Over 60 Front End Starts To Wobble
I was wondering if a bad/leaking steering rack would cause a clunking sound when turning. Also if the rack is bad how many hours should it take to change?
When I am making turns I hear a clunking noise coming from the passenger side and the boot has oil on it but the fluid in the reservoir doesn't seem low.
When I am driving there is a lot of vibration and when I go over 60 the front end starts to wobble.
Ford Brakes/Suspension :: 2003 F250 5.4L 2WD - Front End Vibration Starts Around 40 MPH
My 2003 F-250 5.4L 2WD has a front end vibration that starts around 40MPH (sometimes) and gets gradually worse until it goes away at 55 MPH. It oscillates the wheel a good 3/4"-1". It also does it also when decelerating through those speeds. It "feels" like the left side, but I can't be sure. When I jacked it up, I could get some movement laterally on the left wheel, but not the right. Also Noticed that the drive shaft has about 1/4" of play at the carrier bearing. Leaning towards ball joints.
View 2 RepliesGolf IV / Jetta IV :: Alarm Goes Off When Car Starts
2000 Golf GTi 1.8t
Key fob has not worked for awhile so I use the physical key to lock and unlock the door. I locked the doors when I went to the movies last night come out and unlocked the doors as I always do, Get in and start my car and the alarm starts going off.
So of course I have a little freak out moment after about 30 seconds it went off. So I turn the car off and start it again same thing happened. I say screw it and drive it and the alarm shuts off once more.
I did notice when I got home and turned the car off the red light by the drivers side door lock knob was blinking.
I have looked all over the place and everything that I read says the car won't start. My car starts and drives just fine it's just when I first start it the alarm goes off for about 30-45 seconds.
Golf IV / Jetta IV :: CEL On Exactly 6 Seconds After One Out Of 5 Starts At Minimum
02 Jetta GLS Turbo 1.8. The car runs perfectly fine, and has good power, but one out of 5 starts at minimum it sets the check engine light exactly 6 seconds after starting the engine. It is most commonly a P0340 - Cam Position Sensor Circ Error, I'd say 70% of the time. The other 30% of the time it is a P0011 - Camshaft Position Timing-Over-Advanced. And once or twice it set a P0012 - Camshaft Position Timing-Over-Retarded. It will only ever set one of the codes. I clear it after it sets, and it will never set the code while driving the car.
- I've double-checked the timing belt, and it is spot on. Could not ask for a more perfect lineup of the timing marks.
- There is no noise or rattle on cold start
- The car carries good oil pressure and I'm on a fresh change with Pentosin 5w40
- I checked continuity on the outer two pins on the cam position sensor with a result of 1.910 ohms.
What I should be looking for next? Almost spent for a new cam position sensor, but hate to throw money if there is something I could test to narrow this down. I can't find any test procedures in the Bentley manuals, but maybe I'm not looking in the right spots. The index has no mention of the camshaft position sensor.
Golf IV / Jetta IV :: Car Starts Rubbing In Winter
Have a mk4 GTi vr6 with long beaches with sit at an offset of 38. Honestly the offset thing confuses me quite a bit. I'm running 235/17/45 tires. I had my car lowered before the winter and I can only go so low before it starts rubbing. What size spacers i should go with to basically go as low as possible. If not as low as possible, I love a wide rear end so maybe poking in the rear end and lowered in the front for like a rake effect.
View 5 RepliesGolf IV / Jetta IV :: 2008 - No Crank But Pop Starts
I am having a no start issue with my 2008 golf city( it is a mk4 with a facelift) i have already replaced the ignition switch but the car still will not crank. it starts up easy if i get it rolling and pop the clutch but i cannot get it to crank. when the problem first happened the car cranked what seemed like halfway then stopped and now will not crank at all.
View 2 RepliesGolf IV / Jetta IV :: 2004 Starts But Shuts Off Immediately
When I parked this car 2 months ago it ran fine. Went to start it up and it starts and shuts down. I do not think its the security issue. Both keys do the same thing.
Battery is new recently. There are no MIL lights working on the dash except the battery light. The actual dash lights will not come on. Doors will unlock but not lock. My VAG tester will not communicate with the ECU.
I have checked all of the fuses multiple times. I can hear the fuel pump prime up when the key is turned on. It appears that there is an electrical issue. I took the connections off of the ecu, waited a bit, check for cleanliness and reinstalled also.
Golf IV / Jetta IV :: 2000 - Car Starts Out In 3rd Gear When Put It Into Drive
I've been having 2000 Jetta GLS VR6. It has an automatic transmission and lately I've noticed that when I put it into Drive, it starts out in 3rd gear. In other words I've lost 1st and 2nd gear when put in Drive. When I manually put it in 1st gear with the shifter, I have 1st gear and all the way up to Drive. The issue just seems to be while in Drive (D)
I've tried the Automatic Transmission Reset :
[URL]...................
Perhaps I'm not doing it right as I can't seem to see any switch under the Gas pedal, just a round piece of plastic that protrudes an inch. I've even removed that and still see no switch.
Golf IV / Jetta IV :: Random Stalling On Starts / Have To Rev For Minute To Keep It On
It will randomly not want to keep running when I goto start it so I just rev for a min and then it's fine after that. It doesn't happen to often. 2003 Jetta 1.8t
View 2 RepliesGolf IV / Jetta IV :: 2003 Won't Rev Over 3k - Starts / Idles Rough
I have a 2003 2.0 gas Jetta (181k miles, automatic.) that won't rev over 3k, starts rough, idles rough and wont stop setting a P0341 cam position sensor code.
The car was not running when i got it, i replaced the coil pack and it ran but not over 3k. Cleared codes, it sets the P0341 immediately.
Had timing belt, water pump, tensioner and cam pos sensor replaced. Still, sets p0341 code, starts rough, idles rough and wont rev over 3k.
The throttle servo makes a little noise when actuated, shop thinks this is my demon - suggests replace throttle body.
Golf IV / Jetta IV :: Nasty Grinding Noise Before VR6 Starts
My car will start the first time just fine but if I turn it off it won't start anymore it won't even attempt to crank ...
It does have a nasty grind noise before it starts tho idk if that could be related to it or not ...
Golf IV / Jetta IV :: 1.8T Wolfsburg Starts Then Immediately Dies
I'm going to preface this by saying I've already had the immobilizer problem and I know about the light on the dash of the car + key flashing when you try to start the car without the immobilizer chip in the key fob.
My car has been running completely fine, I go out to start it, it fires up then immediately dies. If I hit the throttle while it starts up it will rev up but still dies even if I hold the throttle all the way open. After doing some research I was pointed to crank position sensor. Bought a new one, didn't change anything.
The strange thing about it is ever once in a while I can get it to start up and then it will run for as long as I let it, so its obviously getting air, fuel, and spark. I have also disconnected the battery and left it for a few hours, didn't work either.
Golf IV / Jetta IV :: Car Starts In 4th Gear After Replacing Shifter Solenoids
I have a 2000 Golf GLS which I tried to replace the shifter solenoids on and since I replaced them it shifts very very incorrectly it almost feels as if it starts in 4th gear and works its way to 1st.
View 2 RepliesGolf IV / Jetta IV :: 2002 GTI Barely Starts And Has Low Fuel Pressure
I got a 2002 GTI 1.8t , with about 109,xxx miles. Ran into a few problems, I took the hose off the fuel rail and turnt the key on. & noticed the fuel pressure was noticeable low & another problem i got is the car doesnt start most of the time. it takes about 3 or 4 cranks before it eventually tuns over. sometimes i noticed if i turn the key on and leave it for a minute or so itll start up. finally want to fix this POS. so I decided to run the codes & heres what i got
P0230
Fuel Pump Primary Circuit Malfunction
CONFIRMED
P0341
Camshaft Position Sensor A Circuit Range/Proformance B1
Golf IV / Jetta IV :: On Every 4th Or 5th Start It Cranks And Then Finally Starts / Sometimes Stalls
Recently my 01 Jetta 1.8T has started to not start like it should. Say every 4th or 5th start it cranks and cranks, I see the tach eventually flick a couple of times and then it finally fires up. It's also stalled while I'm driving, say when I stop at a light but will usually start up again ok.
After the not so good start I get the impression the car is kind of surging while driving - like a fuel supply issue although maybe the fuel pump has nothing to do with supply after starting?
So anyway my thought is perhaps fuel pump issue? I decided to try and search for my issue or fuel pump issues but it talks about things that happen when you open the drivers door which in my case isn't working properly (i.e., I believe it is a DLM as my windows sometimes all go down and I don't get any chime or door light when the door opens).
So just wondering if based on what I'm experiencing if fuel pump sounds likely and perhaps what further tests I should run. My battery is new and the engine does crank pretty good if that eliminate it. I guess I should be thinking fuel filter perhaps also.
Golf IV / Jetta IV :: 1.8T AWP GTI Overheating - All Of A Sudden Coolant Starts To Flow
I am having a overheating issue with my 1.8t AWP gti, it goes as fallows, start the car, engine warms up go for a drive (short 5-8 mi), park the car and temp gauge starts to rise, (turns off car)... I began to check some things with the system, I checked both rad hoses bottom is hot top is a bit hotter and fans work when ac is on; here is where it gets interesting i took off the coolant return hose on the reservoir (cold start) and nothing was flowing ...water pump?... So i turned the heat on and air full blast and all of a sudden coolant starts to flow.
It also seems like air is being spat out as well. Soon after the flow beginning my coolant in the reservoir starts to fluctuate (rising and dropping) with air bubbles and beginnings to over flow so i shut the car off. Now I know what the possible issues are its either the water pump, air in the system or bad autozone thermostat. Here is some history of the car TB was replaced at 70,000 by Previous owner, i bought the car had the belt inspected and was told it was good, about 2 months ago i had a coolant leak and had it misdiagnosed as a thermostat housing leak; it turns out it was a coolant bypass hose that was leaking so i ended up fixing it. I lost a lot of coolant but topped it off with g12+. My mechanic doesn't think its the water pump and recommended changing the thermostat for an VW one another mechanic recommended to bleed air of the system.