Golf IV / Jetta IV :: Exhaust Heat Shield - Slight Creaking Noise That Sounds Similar To The Rattle
I've noticed that potentially my heat shield or whatever guard that is 1 step toward the front of the car from where the inlet pipe connects to the exhaust system may be the reason for my rattle at 2k and 3k rpms. i think its a heat shield but I am not sure. the thing is it seems properly mounted, nothing is cracked/broken/or loose. But when I do try and wiggle it it does make a slight creaking noise that sounds similar to the rattle I get. So I could foresee this as being my issue.
But, is there anyway to fix this rattle w/out just taking off the part? i figure its there for a reason and it looks like its held on in 2 places. But they're not nuts they almost look like spot welds or something. 1 on each side. What to do?
Something to get you all in here:
Golf IV / Jetta IV :: 2001 1.8T Coolant Leak / Dripping Down Off Of Oil Pan
Just purchased a 01 golf 1.8t 5spd and noticed it has a small coolant leak.. Left parking over 2 days in the same spot and it builds up a little puddle.. It's dripping down off of my oil pan and I haven't been able to trace it back to where the leak is coming from..
I've been told it could be my water pump? The car has 92k miles.
Golf IV / Jetta IV :: Coolant Leak / Dripping From The Bottom Of Car
My 2000 Jetta 2.0 has a coolant leak. I searched and found a lot of mentions of the flange on the driver's side, and I have coolant dripping from the bottom of the car in a location that seems consistent with that, but I felt all around the flange and the hoses that are connected to it and it feels dry.
Where else could it be coming from? (yeah, I could jack it up climb under and look, but I haven't had time yet). I also seem to have an oil leak around the same location, but the dipstick tube was cracked near where it went in to the engine so I'm hoping that was the source of the oil.
Golf IV / Jetta IV :: Coolant Leak - Dripping At Front Right Tire
My car is a MK4 1.8t 2001 model.
Recently I've been losing a decent amount of coolant, and I noticed a puddle of water forming up right in front of my front right tire. I've inspected the engine bay, and the water seems to be coming from beneath the coolant reservoir itself, and forming a puddle under the windshield washer bottle. Which ends up dripping under the bumper in front of the right tire.
I didn't have any time to do more inspection, not even to take pics. The car is left at home as i don't want to drive it while it's leaking. Where to inspect or which parts to take off in order to spot the leak... No overheating has occurred, yet.
Golf IV / Jetta IV :: Slow Coolant Leak / Dripping Off The Oil Drain Plug
On my 1.8t jetta she is leaking coolant slowly. Just started when it got cold out. It is dripping down the oil pan right down the center. It is falling off the oil drain plug. Was reading that it could be the water pump leaking but then it wouldn't be in the center of the pan. Got it jacked up now so here are some pics.
View 6 RepliesGolf IV / Jetta IV :: 2005 - O2 Sensor Wire Disappears Above The Heat Shield
Didn't touch the downpipe during engine swap of my BEW TDI.
After swap, have code:
17524 - Oxygen (Lambda) Sensor Heating; B1 S1
P1116 - 000 - Open Circuit
The O2 sensor wire disappears above the heat shield above the exhaust. I am used to (Audi 1.8T, 2.7T, 2.8) seeing the O2 sensors coming up with plug on firewall.
Where is the O2 sensor wire going to.
I normally by the generic Bosch O2 if the SENSOR is bad (cut and splice), but suspect that maybe the problem (open circuit) is further 'upstream'.
Obviously, I am a TDI (and Golf/transverse engine) newbie, so bear with me.
Golf IV / Jetta IV :: Scraping Noise - Downpipe Is Touching Subframe Heat Shield
I just had a new downpipe installed and now I am getting a horrible scrapping noise when coming off a dead stop. I got under the car and looks like the downpipe is touching subframe heat shield. My question is should i take it back and have them make some clearance or is there a quicker solution. New downpipe and subframe heat shield.
View 2 RepliesGTI 337/20th Anniversary :: Exhaust Rattling Against The Heat Shield
I have a 42 DD tb exhaust. And so far I've used a 3" exhaust clamp over the last hanger (after the muffler) which raised the exhaust all the way up against the heatshield, eliminating the rattle over the rear axle beam. But the exhaust was rattling against the heatshield.
So I bought 15 ft of exhaust wrap and wrapped the section that comes in contact with the heatshield. It worked a bit but it still rattles a little! I hate this rattling! How to get rid of the rattling? Should I just use more exhaust wrap?
Elantra MD (2010-15) :: Exhaust Heat Shield Vibration
Had an annoying vibration when pulling from a stop til up to speed or if I was going up a hill at low speed. Figured it was the exhaust heat shield so I took it in for service. I was told that it was indeed the heat shield and that there is a service bulletin regarding it. I believe they repaired it with a pair of clamps.
View 3 RepliesCamry :: 2006 - Engine Noise Coming From Exhaust Shield
I have an '06 Camry 4 cyl. with an engine noise, and I want to repair whatever is causing it. Sounds like it's coming from the exhaust shield. When I press down on the shield while the engine is running, the noise changes.
[URL].....
Suzuki - Xl7 :: Exhaust Heat Shield On Catalytic Converter Fell Off
My wife drives a 2001 Suzuki XL7. While she was out, the exhaust heat shield fell off the catalytic converter. My question is does this affect the car's ability to function in any way? Is it still safe to drive? My wife is freaking out over it.
View 6 RepliesGolf IV / Jetta IV :: Coolant Temp Light Came Flashing On - Oil Getting Into Coolant
Okay so recently I was driving my 2000 Jetta and the coolant temp light came flashing on, when I went to check the coolant I was surprised to discover that it was like a mud brown color, almost looks like peanut butter. From everything I have read this can be from a few things, either rust build up that is gunking everything up and oil getting into the coolant somehow. I'm pretty sure its rust build up but I was wondering what everyone thinks about this, I was also not using G12 coolant which I'm told now is the premier brand for VW's.
View 3 RepliesFord Exhaust :: 2001 F150 4.2L - Moving Heat Shield Right Front Cat Converter
I want to replace the auto trans coolant lines on my 2001 F150 4.2L. I discovered I can actually see the top coolant line flare nut from outside the right wheel well, with the wheel and wheel liner removed. The lower line is just a few inches below. See photo, it's a little off, so the line connector is not seen:
The heat shield is just a little bit in the way for my hands, I have to put one through the red circled area. A 1/2" hex head bolt holds the shield to the frame (circled in green). This was easy to remove from the wheel well. After that the heat shield could be moved slightly away from the points I need to access.
I would prefer to unfasten the shield & move it out of the way for my hands. I found another bolt holding the rear end of the shield down to the frame, wasn't able to remove this - the bolt fastens to a U-nut in the frame that broke off & has trapped the bolt. Are there any other bolts fastening the heat shield down?
I was able to remove the old flare nuts with a 5/8" flare nut wrench, but have not been able to start the new nuts into their fittings, just not quite enough visibility and access.
Ford Excursion :: 2005 V10 Transmission Leaking / Dripping Right On The Exhaust
I have an 05 ex v10 4x4 with 3.73 gears, Was towing my camper (9000#s fully loaded) after about 100 miles pulled off highway and tranny fluid was dripping out of a grommet in the bell housing. Dripping right on the exhaust and it looked like it was on fire.
All gauges showed everything running cool. Checked fluid and couldn't see any loss. Continued to our location and it seemed to stop. Checked tranny fluid continuously and never really showed much loss. Just enough to cause smoke on pipes.. Drove home and stopped leaking. Got two miles from house and started again.
Tranny temp gauge never moved. Does seem to work because I watch it heat up and then stays at the same temp always. This was a 400 mile roundtrip here in flat Florida in the 90's.
Caravan/Voyager :: 2001 T&C - White Smoke Come From Exhaust And Gas Starts Dripping Out Onto Ground
I have a 2001 Town and Country and when I start it up, in about a minute or so, it starts to leak gas from the exhaust. White smokes come from the exhaust and gas starts dripping out onto the ground.
View 12 RepliesSanta Fe (CM - 2007-12) :: 2010 - ATF Drain And Mysterious Leak / Water Dripping Onto Exhaust
I have the 3.5 V6 Automatic 2010 95k miles. I have read places that say any fluid SP-III will work, then others that say any SP-IV. To my understanding, SP-III is not correct, and the fluid will need to meet SP-IV, is this correct? (Additionally, all the auto-part stores said Mecron SP-6 which is not easy to find).
Also, I have a mystery water leak, it is solely water dripping onto the exhaust just between the firewall and the engine. This happens for about an hour after the car is shut off; its getting cold here in Germany and haven't been running the A/C so that is not the issue.
Ford Fuel System :: 1990 Aerostar - Gas Dripping Onto Exhaust At Y-joint And Evaporating
I have a 1990 Aerostar 4WD, 4L, with about 120k miles. About 6 months ago I started my van and noticed under it that gas was dripping onto the exhaust at the Y-joint and evaporating. I shut off the van and drove another car to work. That evening with fire extinguisher at hand I drove my car up on ramps and quickly got under it looking for the leak. NOTHING. 6 months later...yesterday. I drove for a few blocks from home and notice heavy gas fumes etc. Stopped the van and again gas was dripping onto the Y-pipe joint.
This was an explosive situation... I pulled off the doghouse cover and saw, smelled and touched gas friom on the right top of the engine near the back. My questions are: What could randomly be leaking at this location and is it fixable without pulling the engine. I pushed the van to a secure location and am afraid to turn it on. Maybe I will drain the gas tank before then. I am just now trying to find the schematics for the fuel line delivery stuff. Where to go for a manual.
Escort :: 1997 - Coolant Dripping Under Timing Cover
Recently the timing belt went on my '97 Escort. It had been dripping coolant from somewhere under the timing cover so I bought the timing belt/water pump kit thinking that this would solve the two problems. It only solved one. I'm still dripping coolant from somewhere under the timing cover.
Are there any freeze plugs or things that would leak under the cover? When I had it all apart, there were no visible leaks at least on the upper end that I could see easily.
Santa FE SM (2001-06) :: 3.5L - Coolant Dripping / Reservoir Was Empty
I have a 2006 3.5L Sante Fe. and i noticed there were coolant drips under the car and that my coolant reservoir was empty. In the engine bay below what i assume is the water pump i noticed the coolant pooling (See Photos). I am not sure if the seal is bad where the top radiator house connects to the water pump (circled in red, or if the thin metal line (circled in Blue) sitting in the coolant pool would have anything to do with it, since it seems to trace back to the radiator.
View 4 Replies